Question about 2004 Ford Explorer

1 Answer

The heater flaps wont open and the heater keeps clicking unless set on air conditioner

Posted by on

Ad

1 Answer

  • Level 1:

    An expert who has achieved level 1.

  • Contributor
  • 1 Answer

Mine is doing the same thing it is the air blend door actuator that will need replaced

Posted on Dec 21, 2009

Ad

1 Suggested Answer

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi there,
Save hours of searching online or wasting money on unnecessary repairs by talking to a 6YA Expert who can help you resolve this issue over the phone in a minute or two.

Best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.

Here's a link to this great service

Good luck!

Posted on Jan 02, 2017

Ad

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

The right side of vehical puts out cold air and the left hot air when I have the heater on


The heater vents have mechanical flaps that open and close when you switch the setting from hot to cold air. Sounds like one of those flaps might of jammed in the cold air or the cable that is attached to flap has come off.

Nov 11, 2016 | Cars & Trucks

1 Answer

Carrier 42g series split system air conditioner air swing flap works intermittently. I can hear a click click of the drive motor when flap not moving. Is it the drive motor or a broken louvre? Does a


this indicates a fault in the drive motor for the louvres. There is a small electrical motor that works though a set of plastic gears to control a plastic arm
I suggest that you talk with the parts department for availability of the part and then get the carrier technician to fit it
If it is under 5 years old it should be covered by warranty.

Feb 09, 2015 | Cars & Trucks

1 Answer

Heater wont work on 97 honda accord replaced thermostat ran water through heater core and works wat else could it be


On top of the heater matrix is a flap and i suspect that this flap isnt lifting to allow the air through ,on this age car i suspect its a cable and the operating plastic wheel has broke or the outer cable has come adrift from its anchor point you will just have to follow your nose and have a look and as a temp thing wedge the flap open with something

Feb 18, 2012 | 1997 Honda Accord

2 Answers

Iv changed everything that i can for my heater and i only blows cold air. Is there a device that opens and close for the heater and AC?


Its probably your vacuum lines for the heater doors under the dash. These lines open a close doors to allow air to blow through the heater core.

Jan 05, 2011 | 1988 Ford F 150

1 Answer

Why does the truck shut off when I turn the air conditioner on?


I JUST HAD SAME YEAR AND MAKE VEHICLE IN SHOP FOR SAME COMPLAINT AND THROTTLE BODY COKING WAS THE PROBLEM THIS VEHICLE SHOULD HAVE DRIVE BY WIRE SYSTEM MEANING NO THROTTLE CABLE THE THROTTLE BODY IS ELECTRONIC AND HAS ACTUATOR MOTOR TO OPEN AND CLOSE THROTTLE PLATE REMOVE INLET AIR DUCT @ THROTTLE BODY PUSH FLAP OPEN WITH FINGER I SET THE HANDLE OF MEDIUM SIZE SCREWDRIVER UNDER IT TO HOLD OPEN CLEAN THE OUTER EDGE OF FLAP AND THE BORE WHERE FLAP RESTS IN CLOSED POSITION YOU WILL SEE THE BLACK CARBON DEPOSITS MAY NOT SEEM LIKE ALOT BUT THE SYSTEM REQIURES A SET AMOUNT OF AIR @ IDLE AND THE DEPOSITS HENDER THE FREE FLOW OF AIR HOPE THIS HELPS AND NOT CONFUSES IF IT DOES NOT WORK REPOST @FIXYA

Jun 25, 2010 | 2002 Chevrolet TrailBlazer

1 Answer

Heating problem driver side blowing hot air passanger side blcold


its likley to be the pipe has been riped off or fell off or its the flaps on the heater box its self not opening,,,have a look under the dash to fine any pipes that are off the heater box,,
anyhow, who cears if the passanger gets cold,,, its the driver who needs to keep warm!!!!
unless its the other half? or worse still its the mother in law!!!! ho ho ho!

Nov 05, 2009 | 1995 Oldsmobile Ninety Eight

1 Answer

CLICKING SOUND WHEN HEATER IS ON, UNLESS RECYCLE MODE IS ON


Sound like a vacumm leak at one of the baffle door controlers. Look at heater box when makeing noise, should be able to see which controler is going in and out. Once you isolate which is the culprit check the hose circuit for that door.

Jun 19, 2009 | 2006 Pontiac G6

1 Answer

Heater stays at max temp, air conditioner hot except on max cool.


it sound like one of the flap in the duck work is not working. check your heat contrell unit in the dash

Mar 22, 2009 | 1998 Mercury Mountaineer

Not finding what you are looking for?
2004 Ford Explorer Logo

259 people viewed this question

Ask a Question

Usually answered in minutes!

Top Ford Experts

Marvin
Marvin

Level 3 Expert

81285 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

22326 Answers

gerry bissi

Level 3 Expert

4376 Answers

Are you a Ford Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...