Question about 2002 Saturn L-Series

Open Question

How do you repair fuel pump on a 2002 saturn L100

Posted by on

Ad

6 Suggested Answers

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
Best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
New users get to try the service completely Free afterwhich it costs $6 per call and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.
Goodluck!

Posted on Jan 02, 2017

Ad
  • 3600 Answers

SOURCE: replacing a fuel pump on a 2002 saturn lw300

You can check in the trunk and remove the felt cover see if there is a round panel cover that you can remove to get to the tank. If your unlucky and have to remove the tank you will have to remove the tank. The cover may be under the spare tire so pull it out. It is not to difficult to do, if you drive it till the gas is almost out you can remove the two bolts that hold the tank in place. Use wd-40 to spray on the bolts and also spray the hinges on the oppitse side of the straps. once the nuts are off drop the tank down. You will need to pull the screws off the tank filling tube so it will come down as well. drop the tank down far enough for you to get to the fuel tank sending unit. it will have philips screws holding it in place. Mark two spots with a felt tip pin, (Sharpe) white is better and mark two holes so you can line the it back up for the holes and the hoses. disconnect the fuel line and return line disconnect the battery of the car for safety then pull the wires off it can be a plug or it may have nuts on them. When you remove the nuts or screws out pull the pump out and you will have to angle the pump to get the float out. I recommend that you replace the pump and the sock on the end of the pump. Do not buy after market buy factory replacement only you only want to do this once. mark the new pump holes on the pump using the old pump as an example, will save a lot of time to get it to fit in and match and the lines will line up, tighten all screws up put the lines back on and the clamps and reinstall the tank in place. yo can use your knees to hold it in place till you get the clamps lined up and started. Screw the nuts down till tight and your set to go just hook up the battery again and your set to go.
SIde Note, Never let your car get below 1/4 of tank of fuel, the reason is gas is the coolant for the pump if it goes lower than that the pump will heat up and will burn out. Many people don't know this so I thought I would add this to your knowledge

Posted on Nov 20, 2009

Ad
ghost45
  • 1280 Answers

SOURCE: need diagram of 2002 saturn l100 rear brake shoe

Solution... go to Saturn Website.. .Hyundai's here.

Posted on Oct 18, 2009

  • 12 Answers

SOURCE: fuel pump will not come on, have replace with new

check fuel pump relay, fuse or a bad ground to the relay

Posted on Nov 15, 2009

  • 10865 Answers

SOURCE: I have a 2002 saturn sl it wont start and i'm

Hello. No, there is no access through the back seat. You have to remove the gas tank. You have to remove the exhaust pipes to get to the gas tank. The best way to get to it is to put the car on a lift. Once you remove the tank you will see it on top it is one piece connected to the fuel gauge and the entire thing is inserted on the top side. It is hard to get to because there is no access panel under the back seat.

Posted on Dec 23, 2009

chromapr
  • 267 Answers

SOURCE: 2002 saturn l100 A/C wont work

ok ac system has a pressure switch that stops the compressor when freon is too low. they actually say it is ok for mobile a/c systems to lose a half pound a year. most a/c systems run on under 2 pounds of freon. so after 3 or 4 years some systems will just quit working. you are at 8 to 9 years so i would recommend you find an independant shop that will top off your a/c and see if it works again. this should not cost more that 50 to 75 bucks. If you were here that is what i would charge. I am in columbus ohio just to let you know. hope this helps and thanks for using fixya

Posted on May 06, 2010

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

Saturn L100 want stay started


Ignition module , anti-theft system killing it , fuel pump , fuel pressure regulator , are a few thing's that can cause this problem . Suggest you take it to a qualified repair shop that has the tools and the knowledge to diagnose this condition .

Jan 02, 2017 | Saturn L-Series Cars & Trucks

1 Answer

Where is the fuel relay switch on a 2002 saturn L series


You have a fuse / relay box under your hood. My 2002 L100 special edition, 4 cylinder, is located near the battery. You have a relay and a fuse in series. A fuel pump operations check, section 4-3 of the Haynes Saturn L-series 2000 to 2004 manual, you can hear a soft whirring sound for 1 to 2 seconds when you turn the ignition to the ON position. I can confirm mine makes this sound when I do this. Good luck with the fix.

Note, I had a crack in my fuel pump, but I took it to an ex-Saturn dealer 4 or 5 years ago because I did not want to mess with it at the time. They had the part and fixed it in 4 hours, but it also cost me $1000 to replace the fuel pump and install a new fuel filter.

Mar 23, 2014 | 2001 Saturn L-Series

2 Answers

2002 Saturn L100 with a P0300 code


Here's a link to the P0300 code and possible causes.Sounds like clogged fuel injectors. https://www.autocodes.com/p0300_saturn.html

Aug 05, 2017 | Cars & Trucks

1 Answer

P0410 code for 2002 Saturn L100. What is a secondary air injection system?


secondary air injection pump go on youtube they have vedeos on how to troubleshoot and repair

Oct 21, 2013 | Cars & Trucks

1 Answer

2002 saturn L100 no power to fuel pump fuse and relay good?


Well the relay gets power from the pump fuse located in the fuse box under the hood. It looks like the fuse gets power from the battery.
Are any other circuits dead with the key on ? Do you see any fuseable links around the battery that might have failed ?

Jun 24, 2012 | Saturn L-Series Cars & Trucks

2 Answers

Do i have to drop the tank to change the fuel pump in a 2002 saturn L100.


yes you do,make sure all the lines and electrical connections are disconnected before you drop the tank all the way.change the fuel filter at the same time.

May 09, 2011 | Saturn L-Series Cars & Trucks

1 Answer

I need to relpace a fuel pump on my Saturn L100, where is it ?


The fuel pump is in the top of the fuel tank. The part if bought at an auto parts store is a little over $300. I had mine replaced about a year ago. The fuel tank needs to be lowered or dropped for replacing the fuel pump. I had fuel leaking because of a crack in the fuel pump assembly. I did not think I had the tools or the time to safely replace this, so I took it to what used to be a Saturn dealer (they still had Saturn mechanics). They took 4 hours to replace it and charged me $1000.

Dec 10, 2010 | 2002 Saturn Sl

Not finding what you are looking for?
2002 Saturn L-Series Logo

Related Topics:

873 people viewed this question

Ask a Question

Usually answered in minutes!

Top Saturn Experts

yadayada
yadayada

Level 3 Expert

76630 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

22219 Answers

Jeff Turcotte
Jeff Turcotte

Level 3 Expert

8514 Answers

Are you a Saturn Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...