Question about 2004 Ford F150

1 Answer

My 2004 F150 leaking power steering fluid from around the rack and pinion dust boot.

Posted by on

Ad

1 Answer

  • Level 1:

    An expert who has achieved level 1.

    MVP:

    An expert that got 5 achievements.

    Governor:

    An expert whose answer got voted for 20 times.

    Hot-Shot:

    An expert who has answered 20 questions.

  • Contributor
  • 22 Answers

You need a rack and pinion

Posted on Jan 31, 2010

Ad

1 Suggested Answer

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi there,
Save hours of searching online or wasting money on unnecessary repairs by talking to a 6YA Expert who can help you resolve this issue over the phone in a minute or two.

Best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.

Here's a link to this great service

Good luck!

Posted on Jan 02, 2017

Ad

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

I keep bursting rack & pinion boots, does that mean my power steering pump is bad


no, if you have power steering fluid leaking into the boot it means your power steering piston/rod/cylinder has leaking seals.
replace the cylinder (what you attached the boots to) or rebuild the packing.

Jan 03, 2015 | Chrysler Pacifica Cars & Trucks

1 Answer

Hydraulic fluid


The tie rod boot might have liquified grease in it.
(If your engine is leaking oil underneath, motor oil might be in that boot.)
Grease is made of oil & soap, and these two can and do separate over time, and with heat.
I looked up your car, and it has no hydraulic fluid connected with the steering.
The rack & pinion is electric, and the only wear will be sloppy joints due to its being worn out, or electric motor failure.
I applaud your attention to good car maintenance..

Nov 14, 2017 | Saturn Ion Cars & Trucks

1 Answer

Is it possible for power steering fluid to get into the engine and mix with the oil? I am loosing fluid and there are no visible leaks, the engine oil and filter was recently changed and now has turne


No, the power steering is entirely a separate and sealed system, wholly external to the engine. The power steering pump pushes the fluid through a high pressure hose into the rack and pinion-the steering gear mounted below and behind the engine-and holds pressure within the rack that enables power assisted steering. At the same end where the power steering fluid hose enters the gear will be a fitting for a return line back to the fluid reservoir. These two hoses are usually routed close together at least part of the way, some may even be held together with brackets. Leaks could develop at the pump, the fluid reservoir, or the two hoses to and from the rack and pinion, or the seals inside the rack and pinion may have failed. You should be able to find the leak-it will only leak to the outside-to check the rack and pinion for leaks, right where your tie rods come out of the gear and go to the wheels for steering, will be a small rubber boot encasing the tie rod and the end of the rack assembly-on both ends is a boot and a tie rod-peel back the rubber boot from the gear ass\'y, it should be dry. If a lot of fluid, the seals in the rack and pinion are gone. It will have to be replaced.
Hopefully you will find a leaking hose or fractured reservoir, but keep looking, air flow may be blowing the leaking fluid back and under the car. Good luck, hope it\'s not the rack and pinion.

Jan 24, 2013 | Honda Cars & Trucks

1 Answer

Rack and pinion? have play in wheel no sign of leaks new power steering pump installed


Hi Gunny, If your vehicle is fitted with rack and pinion steering also check the rack ends for play. The rack ends are the rods which the tie rod ends screw onto. The other end fits onto the rack of the rack and pinion. To work on those you will need to remove the rubber boots and loosen the locking washer, they can then be loosened with a wrench. If they are worn the play will be evident in the steering. When replacing them also replace the rubber boots. If the boots are worn and road grime and dust enters, you will see leakage from the rack and pinion in the near future. I always thought the Dakota was fitted with a steering box? Regards John

Jun 24, 2012 | 1990 Dodge Dakota

2 Answers

What are bellows boots on a honda


the bellows are the the plastic tubes that protect the inner tie rod end/rack from dirt and water. If there is fluid coming out of the bellows than the rack is leaking. The normal repair is to replace the rack with either a remanufactured or new rack and pinion.

I’m happy to assist further over the phone at https://www.6ya.com/expert/jeremy_d728a59f986299fa

Dec 29, 2011 | 1998 Honda Accord

2 Answers

The steering is hard to move and the steering warning light is on. Please let me know what to do I need to urgently resolve it.


The servo unit on the steering has failed . Look inside the engine bay for oil leaks - if none are present then the entire steering rack will have to be replaced - the internal seals have failed.

Jul 13, 2011 | 2002 Volkswagen Golf

3 Answers

There is power steering fluid dripping from the passenger side boot covering the rod that connects to the wheel. Could a simple replacement of the boot be the fix, or is there a problem with the main unit...


No, the boot only keeps dust out of the inner tie rod joint--it is not intended to hold back fluid. The rack will have to be rebuilt with new seals. Sorry. :o(

Dec 05, 2010 | 1998 Toyota Sienna

1 Answer

I have a major power steering leak i cant track and its not coming from the pump


What can commonly happen is the seals inside the rack and pinion and allows the fluid to fill the bellow boot(accordion boot). Take a small pick and poke the boot on the steering linkage. If fluid pours out, replace the rack and pinion unit and then have it aligned. If you need further instructions, feel free to let me know.

Oct 10, 2010 | 2004 Kia Sorento

1 Answer

Power steering fluid completly leaked out while driving


sounds like either a high pressure hose or low pressure return line that leaked the fluid. Or the rack and pinion system. Check for oil around the different components by filling it up with the power steering fluid at the pump.

Aug 01, 2010 | 2004 Volvo XC90

Not finding what you are looking for?
2004 Ford F150 Logo

606 people viewed this question

Ask a Question

Usually answered in minutes!

Top Ford Experts

yadayada
yadayada

Level 3 Expert

80339 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

22326 Answers

fordexpert

Level 3 Expert

5687 Answers

Are you a Ford Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...