Question about 2001 Mazda Protege

Open Question

Directions for changing Air Conditioner Compressor

Posted by on

Ad

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

To replace the condense of A5 VW Golf 4 cylinder air conditioner and change oil in pump


To change the condensor undo the lines and mounts and remove.Replacing is opposite proceedure. Replace the air dryer/ receiver at the same time. There should be no need to change the compressor oil as it moves trhrough the system with the gas and there is no sump as such.

Mar 16, 2013 | Cars & Trucks

1 Answer

I have a 1993 Chevy S-10 4.3L automatic. The heat won't shut off. It pours out regardless of the position of the climate controls. Coolant level and condition good. AC would work but. Thanks.


#46-12-03: AIR CONDITIONER BLOWS WARM AIR (REPLACE A/C DELAY RELAY) - (Apr 7, 1994) 999999995.gif REVISION: 04/14/94
THIS BULLETIN IS BEING REVISED TO CORRECT THE TRANSMISSION LISTED IN THE MODELS. ----------------------------------------------------------------------
SUBJECT: AIR CONDITIONER BLOWS WARM AIR (REPLACE A/C DELAY RELAY)
MODELS: 1994 CHEVROLET AND GMC TRUCK S/T PICKUP WITH 4.3 ENGINE (VIN Z - RPO LB4), 4L60E TRANSMISSION (M30) AND AIR CONDITIONER/MANUAL CONTROLS (C60); OR 4.3 ENGINE (VIN W - RPO L35) AND A/C (C60)
BUILT BEFORE THE FOLLOWING VIN BREAKPOINTS:
PLANT DIVISION VIN LINDEN GMC RK501034 SHREVEPORT GMC R8501199 SHREVEPORT CHEVROLET R8105893 LINDEN CHEVROLET RK103097
CONDITION:
SOME OWNERS MAY EXPERIENCE A CONDITION WHERE THE AIR CONDITIONER IS TURNED ON AND DELIVERS ONLY WARM AIR.
CAUSE:
THE AIR CONDITIONER COMPRESSOR MAY DELAY LONGER THAN THE "ORIGINAL DESIGN" INTENDED 12 SECONDS, OR MAY NOT ENGAGE, DUE TO THE POSSIBLE MALFUNCTION OF THE COMPRESSOR DELAY RELAY.
CORRECTION:
TRUCKS BUILT BEFORE THE VIN BREAKPOINTS LISTED ABOVE MAY NEED A NEW AIR CONDITIONER DELAY RELAY. REPLACE ONLY WITH 15990540 AIR CONDITIONER COMPRESSOR DELAY RELAY. SPECIFIED PROCEDURE IN SERVICE MANUAL NATP 9429, PAGE 1B-59. TEST AIR CONDITIONER OPERATION FOR DELIVERY OF COOL AIR.
NOTE:TO TEST FOR PROPER OPERATION, PUT THE A/C CONTROL ON THE "OFF" POSITION, START THE ENGINE, THEN PLACE THE A/C CONTROL IN THE "ON" POSITION. THIS SEQUENCE WILL PROVIDE IMMEDIATE ENGAGEMENT OF THE AIR CONDITIONER COMPRESSOR. WHEN THE ENGINE IS STARTED WITH THE A/C CONTROL ALREADY "ON", THERE WILL BE A NORMAL 15.0 SECOND DELAY FOR THE AIR CONDITIONER TO ENGAGE.
SERVICE PARTS INFORMATION:
P/N DESCRIPTION QTY
15990540 A/C COMPRESSOR DELAY RELAY 1
PARTS ARE CURRENTLY AVAILABLE FROM GMSPO.

Jul 29, 2011 | 1994 Chevrolet S-10 Blazer

1 Answer

Problem with heating and air conditioning. The driver's side is blowing hot air and the passenger side is blowing cold air


Air Conditioner blows warm air
  1. Air conditioner system is discharged. Have the system evacuated, charged and leak tested by an MVAC certified technician, utilizing approved recovery/recycling equipment. Repair as necessary.
  2. Air conditioner compressor clutch not engaging. Check compressor clutch wiring, electrical connections and compressor clutch, and repair or replace as necessary.

Jun 01, 2011 | 2004 Buick Century

1 Answer

Air Conditioner compressor runs all the time causing overheating. The Heater Air conditioner Knob on the console turns but doesn't change anything. When I unplugged the Compressor The engine still...


Remove the belt and check if your A/C pulley turns freely. If it doesn't you need to have it repaired. If it does, you have other problems, thermostat, radiator, fluid, etc. Good luck.

Jun 04, 2010 | 2001 Chevrolet Blazer

1 Answer

What do I have to do to change the a/c compressor are there any special procedures or can I take the old one off put the new one on and then charge the system with coolant I have a 1996 oldsmobile delta...


if old compressor fail your air condition has to be discharge at dealership or a garage that does ac repair.then the ac lines has to be flushed out before putting on new one. because old one when it fails clutch lock up or compressor fail.small metal particles get in line.stop up orifice tube.you will have to replace orifice tube the accumalator .you will need vacuum pump to pump down air conditioner .to get moisture out of system.you will need a manifold gauge set for air conditioner.ac tools are expensive.it would be cheaper to buy compressor - accumulator - orifice tube. take it to a good air conditioner mechanics.let him put parts on and pump down system.then charge it up.because buying tools to get ac going .is going to cost $475.00 thats the vacuum pump price.you can buy a cheaper vacuum pump that works from air from a regular air compressor you pump tires up with.manifold gauge set causes from $100.00 up to $300.00 for a good set.another thing you have to be familiar with working on air conditioners you put too much R-134 in system you will damage compressor or get seriously hurt.

Jul 05, 2009 | 1996 Oldsmobile 88

1 Answer

Air Conditioner Problem


I would use a multimeter and check if the voltage changes at the blower motor, as you turn up the blower speed on the controls. If it goes up, you need a blower motor. If not, the a/c amplifier.

Jan 19, 2009 | 1997 Lexus LS 400

1 Answer

Air conditioner compressor clutch went out twice


The air conditioner turns on even when you don't use it. Like anytime you have your defrost on, it helps dry the air inside of your vehcile. So by letting the leak continue the clutch turns on then off on then off over and over instead of just kicking in and staying on. Yes, if you don not fix the problem it will continue. I wish I had better news for you.

Stan

Dec 26, 2008 | 1996 Chevrolet Express

1 Answer

AIR DOES NOT WORK DO I JUST NEED FREEON


If the air conditioner blow warm air,

1. Open the hood and check the fan belt first, sometime the fan belt broke caused the compressor stop to work, if the fan belt is good, check the compressor see if the center part turns, if turns, that means the compressor is o.k.

2. If both work fine, check the air conditioner small window see if there is bubble, if you see some bubbles in the small round window, that’s means your air conditioner lack
R-22 Freon.

3. before you fill up the Freon, check the leaking, if leaks, fix it and then fill up the Freon, the best way is to ask some professional auto air conditioner repair shop to help you.


Hope this can help you.

Jun 12, 2008 | 1996 Chrysler Cirrus

Not finding what you are looking for?
2001 Mazda Protege Logo

Related Topics:

30 people viewed this question

Ask a Question

Usually answered in minutes!

Top Mazda Experts

yadayada
yadayada

Level 3 Expert

76132 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

22156 Answers

Jeff Turcotte
Jeff Turcotte

Level 3 Expert

8273 Answers

Are you a Mazda Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...