Question about 1993 Ford Aerostar Extended

1 Answer

How to get to the thermostat on a ford aerostar 93 awd van?? where is it located??

Posted by on


1 Answer

  • Level 3:

    An expert who has achieved level 3 by getting 1000 points


    An expert that got 20 achievements.


    An expert that got 10 achievements.


    An expert that got 5 achievements.

  • Ford Master
  • 17,970 Answers

1993 Ford Aerostar 4WD 4.0L MFI 6 Cyl Repair Guide

1. Drain the cooling system with the engine cold.

CAUTION When draining coolant, keep in mind that cats and dogs are attracted by ethylene glycol antifreeze, and are quite likely to drink any that is left in an uncovered container or in puddles on the ground. This will prove fatal in sufficient quantity. Always drain the coolant into a sealable container. Coolant should be reused unless it is contaminated or several years old.

2. Remove the retaining bolts for the thermostat housing. Lift the housing clear and remove the thermostat. It may be easier to clean the gasket mating surfaces with the heater and radiator hoses removed from the thermostat housing.

Exploded view of the thermostat housing on the 2.3L engine

how to get to the thermostat on a ford aerostar 93 - 8ea7635.gif

Exploded view of the water outlet housing and thermostat-make sure that the thermostat is correctly positioned as shown


Exploded view of the thermostat housing ahow to get to the thermostat on a ford aerostar 93 - c7032fb.jpgat-3.0L engine



I hope help you whit this (rated this help) Good luck.

Posted on Sep 15, 2009

  • Michelle Ziemkowski Aug 18, 2013

    Diagrams help greatly !!! Thank you !!!



1 Suggested Answer

  • 2 Answers


Hi there,
Save hours of searching online or wasting money on unnecessary repairs by talking to a 6YA Expert who can help you resolve this issue over the phone in a minute or two.

Best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.

Here's a link to this great service

Good luck!

Posted on Jan 02, 2017


Add Your Answer

Uploading: 0%


Complete. Click "Add" to insert your video. Add



Related Questions:

1 Answer

Replace thermostat where is it located located

Sign up at (its free). It gives very simplistic videos on where the part is and how to change them...I have replaced my Alternater, radiator, water pump, started, fuel pump, and fuel filter on my 95 ford aerostar cargo van using their videos.

Jan 07, 2014 | 1995 Oldsmobile Cutlass Supreme

1 Answer

Where is the thermastate on my 97 ford areostar van?

No the cooling system would not have any affect on the battery.
If the engine is not warming up, the thermostat is in the water outlet where the upper radiator hose connects to the intake.

Jan 23, 2013 | 1997 Ford Aerostar Extended

1 Answer

Were is the fuse box for a 93 aerostar

Fuses and their location (under instrument panel on
driver’s side)...


Foe details about description and positions check the Aerostar Owners Manual.

Hope helps (remember comment and rated this).

Jun 24, 2010 | 1994 Ford Aerostar Extended

1 Answer

1996 ford aerostar van is leaking small amount of antifreeze heater is taking longer to heat could it be the thermometer if so where is it located

I assume you mean the thermostat.

Look for a large hose running backward from the radiator. Where this hose reaches the engine, it will be attached to a metal piece. The thermostat should be inside this. There are usually two bolts holding this part to the engine.

Oct 10, 2009 | 1996 Ford Aerostar Extended

1 Answer

How to replace turn signal switch 93 aerostar van xlt

Take a screwdriver and loosen the screws that hold on the steering column wrap. Separate it, and pull it off. You should see the turn signal switch screws. Replace it and put the column cover back on.


Sep 08, 2009 | 1993 Ford Aerostar Extended

1 Answer

1993 Ford AWD Aerostar Van. When the engine is

Sounds like the front calipers are not fully retracting properly. Check the front caliper operation while a friend pumps the brake pedal, the rubber lines could also be cracked and allowing air into the lines. Check brake fluid level.

Aug 29, 2009 | 1993 Ford Aerostar Extended

1 Answer


try these websites or and you should be able to get diagrams and pictures showing you how to repair your car

May 22, 2009 | 1992 Ford Aerostar Extended

1 Answer

Thermostat on 93 fore minivan areostar where is it located and how do you remove it.

try to see if they have your car listed for diagrams pictures and step by step instructions if your car is not listed then try your local library they have all the car manuals and even copy them for you

Mar 21, 2009 | 1988 Ford Aerostar

Not finding what you are looking for?
1993 Ford Aerostar Extended Logo

4,086 people viewed this question

Ask a Question

Usually answered in minutes!

Top Ford Experts


Level 3 Expert

85020 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

22484 Answers

gerry bissi

Level 3 Expert

4387 Answers

Are you a Ford Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides