Question about 2004 Jaguar X-Type

3 Answers

Black smoke on hard exceleration.serviced may

Posted by on

  • yadayada
    yadayada May 11, 2010

    any trouble codes in memory?

×

3 Answers

  • Level 3:

    An expert who has achieved level 3 by getting 1000 points

    Superstar:

    An expert that got 20 achievements.

    All-Star:

    An expert that got 10 achievements.

    MVP:

    An expert that got 5 achievements.

  • Jaguar Master
  • 2,359 Answers

Check for

vacuum leaks on intake manifold,

the air tube between the air filter.

intake manifold vacuum hose.

===
clean throttle plate with Berryman carburator cleaner

SEE sample picture HERE
===

Also remove carbon built up behind the EGR valve and the EGR passage tube.

===

Vacuum leak WILL offset the intended 14.7 to 1 air fuel ratio.

More un-metered air (leaks) will lean out the fuel mixture.

Use small amount of Berryman carb clearer at potential air leak area will help you identify trouble spot.

At idle,just spray and listen for the RPM surge.

The in-rush of carb clearer will increase the RPM on the motor.

Record the problem spot(s) and address it later.

===

EGR carbon built up require 2+ hours to clean from start to finish.

You will need a new EGR base gasket before your start.

Locate and remove the EGR valve after the vehicle is cool down.

Carefully record the connector and vacuum line (for older vehicle) location by drawing an easily to follow diagram.

Remove the EGR valve.

Inspect the location of the carbon built-up inside the valve and the EGR passage tube.

SOAK these areas with WD-40 spary.

You will need a small screwdriver,cloth hanger and lot of newspaper and time to get this cleaning done right.

RE-SOAK the carbon and let it sit for over-night will also help.

One the last round,pass a shop vacuum of the EGR valve and the passage pipe.

Install the new EGR gasket and connectors.

Allow the vehicle to warm up outdoor to burn up any remaining WD-40.


Take it for a test drive.


Please rate my answer if it's useful to you.


Cheers,

Mustgo

Posted on Dec 19, 2009

  • Level 1:

    An expert who has achieved level 1.

    Governor:

    An expert whose answer got voted for 20 times.

    Corporal:

    An expert that has over 10 points.

    Mayor:

    An expert whose answer got voted for 2 times.

  • Contributor
  • 10 Answers

Check for split induction hose onto egr valve, and check egr clean.

Posted on Sep 16, 2009

  • Level 1:

    An expert who has achieved level 1.

    Corporal:

    An expert that has over 10 points.

    Problem Solver:

    An expert who has answered 5 questions.

  • Contributor
  • 5 Answers

Too much oil maybe

Posted on Sep 10, 2009

1 Suggested Answer

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.
goodluck!

Posted on Jan 02, 2017

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

My Ford escort 1999 white smoke comes out when you excelerate I know it's not the gasket what can I do I think it is this part but not sure the name of the part


Howdy anon,

The thingamabobbie... (can't think of it either).
((I don't believe there is such a part but I'd love to be WRONG)).

Black smoke is usually over-fueling, blue is oil burning and of course your BASIC WHITE is water.

WATER is a by-product of combustion... so it is perfectly normal to see white smoke during the warm-up... often with water actually dripping out of the tail pipe.

However, once the ENGINE comes up to operating temperature... the exhaust becomes quite hot... No more water should be visible (unless the weather is horribly cold).

Go to rockauto.com...Very easy to use on-line catalog. The parts are wonderfully laid out by systems... perhaps you can find your part there... or go to BBBind.com for the TECHNICAL SERVICE BULLITINS for your specific car...

Hope this helps.

RockAuto Parts Catalog

bbbind.com
BBB Industries Premium Alternators Starters Power Steering Products

May 09, 2016 | Ford Cars & Trucks

1 Answer

Hi , I have a 2005 Toyota Hilux 3.0 D4D when I startup the motor there is no smoke when I excelerate still nothing but as soon as I get to 3000rpm the motor starts to rev up and down and blue smoke co


I have a 2012 dodge ram 1500, I am wanting to raise it 2 inches with a leveling kit, I will need to readjust the fog lams and headlights, I know how to do the headlamps but need to know how to do the fogs lamps?
Thanks

Mar 02, 2014 | 2006 Toyota Hilux 3.0

1 Answer

Black smoke coming from exhaust on exceleration


ur vehicle must hav some miles--usually thats worn rings or valve guides and a rebuild is needed--but 1st try some sae 40 or 50 wt oil--thickeners are sold at parts place----------is tuneup to date-new plug wires and distributer cap etc--bad spark causes soot

Sep 20, 2011 | Jaguar X-Type Cars & Trucks

1 Answer

I have a jaguar x type 05 plate. it has started jerking when i have low revs and lots of black smoke coming out of exhaust when i excelerate...any ideas?


I have the same problem I was inform by my jaguar dealer that it was the egr valve costs about £63.00 plus fitting

Jul 19, 2010 | 2005 Jaguar X-Type

2 Answers

1998 E-Class: poor mpg.plenty.black smoke in puff fashion.delay ...


Unfortunately you have to bring the vehicle to the Dealer. Why? German Auto makers keep their codes to themselves. They can scann the vehicle for codes and do the repair accordingly. Any repair shop will do the repair and pay threw the nose and so will you for the meaning of that code. Your burning rich. Thats what the black smoke is for But why is the question?
My experience with the *E* class with this situation has been defective air flow sensor and fuel pressure regulator once it was the ECU. Good luck

May 07, 2010 | 1998 Mercedes-Benz E-Class

2 Answers

Ford Ranger 2.5 on a53 plate. EML comes on


my ford ranger run rought when i rare it up it blows some black smoke

Oct 12, 2009 | 2003 Ford Ranger Regular Cab

1 Answer

Blue smoke comming out of exaust upon exceleration


well blue smoke is a sighn that you are burning oil either valve seal or rings are wore out or cound also be a leaky head gasket

Aug 17, 2009 | 2002 Hyundai Accent

Not finding what you are looking for?
2004 Jaguar X-Type Logo

271 people viewed this question

Ask a Question

Usually answered in minutes!

Top Jaguar Experts

Colin Stickland
Colin Stickland

Level 3 Expert

22095 Answers

yadayada
yadayada

Level 3 Expert

75005 Answers

SPEEDY CAR WORK SHOP...

Level 2 Expert

489 Answers

Are you a Jaguar Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...