Question about 1999 Plymouth Voyager

1 Answer

Radiator fan will not kick on 1999 voyager flex fuel ,i already replaced coolant sensor

Posted by on

1 Answer

  • Level 3:

    An expert who has achieved level 3 by getting 1000 points

    All-Star:

    An expert that got 10 achievements.

    MVP:

    An expert that got 5 achievements.

    Vice President:

    An expert whose answer got voted for 100 times.

  • Master
  • 534 Answers

Check you replaced the correct fan control sensor switch (not the temperature gauge sender),
Check fan fuse,
Check fan control relay operation,
Check fan will run if power applied directly to it.

Posted on Sep 07, 2009

1 Suggested Answer

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.
goodluck!

Posted on Jan 02, 2017

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

My 1999 Chevy cavalier started over heating and I


Probably a faulty coolant temperature sensor.

Sep 17, 2014 | 1999 Chevrolet Cavalier

2 Answers

Hi! I own a 2001 chrysler voyager 2.5 crd and need to know where the coolant temp sensor is located exactly?


Which one. There is one for the engine management system and one for the radiator fans.

Jul 30, 2014 | 2001 Chrysler Voyager

1 Answer

Why would my 2001 voyager be over heating changed fans and fans wont kick on


Hi Tina-
In general, assuming you have the proper levels of coolant in the system, the next item to check is the thermostat. It is held in a metal housing bolted to the top of the engine block at the end of the upper radiator hose. This controls the temperature of the coolant in your cooling system. Not operating correctly, it would not allow the hot water in your engine to properly flow to the radiator to be cooled and cause overheating.
If your fan is not coming on at all, it may be that the temperature sensor they are connected to is faulty. The sensor turns on the fans once the coolant reaches a certain temperature. If the sensor is bad, the fans will not turn on regardless of the coolant temperature.
Lastly, if the water pump itself is bad (not circulating the coolant), this will cause overheating. Usually, a bad water pump will begin to show itself as a puddle underneath your car-since bad seals or bearing will cause it to fail this way-but I have also seen where poor maintenance of the coolant itself (not being flushed and changed at required intervals) have allowed deposits in the system to wear the blades inside the pump and reduced its effectiveness.
Hope this helps!

Apr 01, 2014 | 2001 Chrysler Voyager

1 Answer

MY MECHANIC REPLACED THE RADIATOR ONN 1999 VOYAGER,HE COULD NOT GET FAN TO WORK SO HE HOT WIRED IT TO THE BATTERY,HE GOT A SENSOR BUT CANT FIGURE OUT WHERE IT GOES- HELP!


HACK! the radiator relay is probably bad, located down near radiator left lower corner,bolted to frame,have to get at it from underneath. Be sure fuse #24 (40 amp) is good. A scanner should activate the fan if the relay is good, if not its probably bad, Make sure the fan does not pull more than 20 amps when running, if it does, that could have burned up the relay.

Sep 14, 2011 | 1999 Plymouth Grand Voyager

1 Answer

2004 vw jetta is over heating. already checked thermostat and sensors. any suggestions? 2.0 engine


Is the fan kicking on? Radiator fan! When engine gets hot, radiator fan should kick on under the hood.
If it does, then there is a blockage in the radiator preventing it from circulating the coolant to dump the heat. Get a Rad flush.

If the fan does not kick on, then check the fan fuse and relays, usually found in an electrical distribution box under the hood. Consult your owners manual for its location and specific fuses / relays.
Possible bad fan too.. but disconnect the fan at the plug in the wiring, and test supply wire for voltage, when engine is above normal temperture.

Jun 30, 2011 | 2004 Volkswagen Jetta

2 Answers

Radiator fan not working


CHECK FUSE AND RELAY.IF ALL IS GOOD.HOT WIRE COOLING FAN USING JUMPER WIRES.USING CAR BATTERY.IF FAN RUNS.ITS GOOD.IF FAN DONT RUN.REPLACE FAN ELECTRIC MOTOR.ALSO SCAN IT. TO MAKE SURE COOLANT TEMPERATURE SENSOR IS NOT OPEN.MAKE SURE ENGINE COOLANT TEMPERATURE SENSOR AND COOLANT TEMPERATURE READS SAME ON SCANNER IF NOT REPLACE THE COOLANT TEMPERATURE SENSOR. SEE IF COOLANT TEMPERATURE IS BAD THE COOLING FAN OR FANS WONT RUN.

Sep 07, 2009 | 1997 Plymouth Voyager

2 Answers

1992 plymouth grand voyager


yes, the engine gets hot and has a shut off to protect it from overheating to badly. Repair the fan and see if the problem is corrected. If not please let me know. Thanks

May 28, 2009 | 1992 Plymouth Grand Voyager

1 Answer

1997 plymouth voyager radiator fans


I don't believe your particular vehicle's cooling system needs to be bled during coolant filling, but check the coolant level first. It seems that the coolant level is too low for the sensors to be able to sense the temperature, or the sensors are disconnected. Look for a connector on the intake manifold, near the coolant outlet. Ensure it is properly connected.

Aug 16, 2008 | 1997 Plymouth Voyager

Not finding what you are looking for?
1999 Plymouth Voyager Logo

308 people viewed this question

Ask a Question

Usually answered in minutes!

Top Plymouth Experts

yadayada
yadayada

Level 3 Expert

74896 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

22095 Answers

Jeff Turcotte
Jeff Turcotte

Level 3 Expert

7689 Answers

Are you a Plymouth Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...