Question about 2004 Lincoln LS
Save hours of searching online or wasting money on unnecessary repairs by talking to a 6YA Expert who can help you resolve this issue over the phone in a minute or two.
Best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
Here's a link to this great service
Posted on Jan 02, 2017
It is probably the (DCCV) Dual climate control valve. It is located RT front of engine with heater hoses and wires goin to it. I ordered one from Rockauto.com for about a $100.00 i think. It is pretty easy to change and I found out when mine went out that it was a very common problem with these cars. When mine quit it started the same as you are describing for a while then it only would blow hot air and it blew the a/c compressor fuse. The DCCV is a dual cylinder valve and i beleive that they get stuck open and short out. If you have any more questions or need more information let me know.
Posted on May 15, 2009
SOURCE: 2004 Lincoln LS A/C Valve
In order to charge, you must locate the low pressure valve to install the refrigerant. The low pressure valve is between the compressor and the evaporator. Do not charge on the High Pressure side, The high pressure valve is between the compressor and the condenser. To locate the low pressure valve, follow the line that comes from the compressor and routes toward the firewall. The valve will be somewhere on that line. Do not overcharge. The amount of pressure that is needed on the low pressure side will depend on the ambient outside temperature.
Posted on Jun 21, 2009
first find and unscrew the 5 screws 1 is in the door handel... then pull panel off sounds like its braking but its the clips holding it on try not to brake as many as possible...
Posted on Sep 27, 2009
If you have a 2004 lincoln ls,the PO420 is-- Catalyst System Efficiency Below Threshold. ( Bank 1) The list of possible causes are long. I have the same vehicle, and the Emissions Manual,which is several hundred dollars. Don't let anyone tell you it is a bad Converter. It may be, but it is only six years old. I would check for codes. The ignition coils (Coil-On-Plug) go bad on all Fords and a misfire, resulting overheating of exhaust system etc,will set all kinds of codes,and they may not be related, to the real issues. Lincoln is where one of everything goes,when it comes to the latest technology. Check that the O2 Sensors are screwed in tight. Later on you may need to have them checked out,if no ignition issues or malfunctioning coolant temp sensor issues. Use only 5-20 Oil. I use Mobil 1 synthetic. Hopefully your not using any,and ruining the converter. Make sure you have the system full of coolant,including the Degas container,the one where antifreeze mix goes. Remember GO5 Yellow antifreeze on ford products. Also bleed the hose next to the brake booster to let out air,in the coolant system. You can check for above normal fuel pressure. I would not go to a Dealer and spend more than necessary. Find a good shop that knows these vehicles. You can't fix every problem on all makes that come thru your doors today. Hope I give you a start on things to have checked. I would stand in the service bay by the car and have the tech prove what is wrong before I would authorize any part replacement.
Posted on Apr 07, 2010
In the grey folder with your owners manual,is a white card with the factory code,for the keyless entry keypad. It also, tells you, how to put in your own code
Posted on May 16, 2010
Tips for a great answer:
Sep 22, 2017 | Lincoln Cars & Trucks
Jun 20, 2017 | Lincoln Cars & Trucks
Jul 27, 2015 | Lincoln Cars & Trucks
Jan 05, 2015 | 2006 Lincoln LS
Sep 02, 2014 | 2004 Lincoln LS
May 03, 2014 | Cars & Trucks
Oct 02, 2010 | 2004 Lincoln LS
Oct 21, 2009 | 2000 Lincoln LS
May 04, 2009 | 2002 Lincoln LS
48 people viewed this question
Usually answered in minutes!