Can it be easily fixed with out stripping gearbox
Check the linkage! Make sure that everything is tight and that when you put the shifter in first gear, that the linkage is actually fully engaging first gear. It may need some adjustment. Good luck! Bill
No. The synchro hub is worn and where one is worn so may the others be. Try a yard or small ads or ebay if you can't find a local specialist. The cost of genuine toy parts may make an exchange box a better bet.
SOURCE: hilux leaking gear oil
There is a plug on the side of the gear box. Pull plug out. You should be able to stick your finger into the hole and touch the gear oil. If not, check on your owner manual and see what type of oil goes back into the gear box. Fill it up until it start coming out of the plug hole.put plug back in, & back to riding.
Are when you go to the oil change shop???? Get them to show you where it is at, and get them to top it off for you.???
SOURCE: my 1991 hilux surf seems to be stuck in 4WD..
i had this and i had to stop disengage then keep starting to move off then stopping and just trying it over a few times back in and out of four wheel drive worked for me hope it does for you
SOURCE: Gear stick seems loose when in 5th gear on Toyota Hilux Surf
you can replace the bush on the bottom of the gear stick accessable through the top of gearbox it may tighten it up a bit
SOURCE: Hi both rear windows in my toyota hilux surf which
The only way would be to remove the door pannels and find whats wrong, disconnet electric motors if it is equipped they had both mechanical and electrical so which do you have? Do you just want to get them up or fix them? If it's electric check your fuses first, that should be the first thing you do. If it's mechanical you will have to remove the window crank and the arm rest and lock button by turning it counter clockwise if round if a long square lock knob cover will lift over it. once it is off check the slide rails to see if they have come apart if they have it can be fixed but you will have to take it to a welding shop to get it spot welded. If the Gears that operate are stripped you will have to replace them, if the rollers have come out at the bottom rail you will have to replace the rollers or insatll them back in the rail. Let me know what you have and I will give you some information for this problem.
SOURCE: leaking gearbox toyota hilux 4wd can,t find out
Check if the filler and drain plug is tightened, aswell as the reverse and 4wd(light indicator) switches on the gearbox is not leaking through the section where the wiring enters the switch, check the tail end of the g/box rhere the the drive/prop. shaft enters the g/box, a oil seal is located there and on the transfer case driveshaft driving the front wheels.
Regards
Phillip
302 views
Usually answered in minutes!
×