Question about 1989 Toyota Corolla 2 Door

1 Answer

Diesel injection pump leaks

1989 Corolla diesel injection pump leaks

Posted by on

  • 2 more comments 
  • eric_lester Jun 28, 2009

    I realise that it will be the seals, but how hard is it to fix? and most diesels need to be "blead" after, do you know how to with this engine?

  • eric_lester Jun 29, 2009

    Many thanks, I am not a beginer, I have rebuild a small block 350 Chev, and an Isuzu 4JB1-T 2.8 Engine, but I do realise that this will be a challange.

    Your suggestion on the injector banjo sounds good. The Isuzu has a 3 step piming sequence

  • eric_lester Jun 29, 2009

    thanks George

  • eric_lester Jun 29, 2009

    thanks George

×

1 Answer

  • Level 2:

    An expert who has achieved level 2 by getting 100 points

    MVP:

    An expert that got 5 achievements.

    Sergeant:

    An expert that has over 500 points.

    Governor:

    An expert whose answer got voted for 20 times.

  • Expert
  • 167 Answers

All diesel cars built before 1996 have seals in them which are not suitable for the new low sulfur diesel fuels sold today.Only way to remedy the problem is to have new seals fitted.Can be a costly job.Get 3 quotes.
Hope this helps.

Posted on Jun 28, 2009

  • George Jun 29, 2009

    Unless you have the tools and the knowledge take it to a pro .Diesel injector pumps are very very hard to service for beginners .Not to mention the tools required.
    Hope this helps.
    Most modern stuff is self bleeding , But if you do need to bleed quickly just crack an injector banjo and bleed from there.
    Works most of the time.


  • George Jun 29, 2009

    Cool on the Chev .......Now if you were a Ford man there would be no hope for you !
    Have a go at the seals but be prepared for the worst , If you can take photos of it as you strip it , Mark anything that looks like it is timed and you might pull it off.
    Good luck and If you need a hand just send me a message.
    Regards
    George


×

1 Suggested Answer

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.
goodluck!

Posted on Jan 02, 2017

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

1989 Toyota Land Cruiser (BJ70)


Fit a new water pump ,the seal is leaking and stops when it warms up.

Nov 21, 2013 | 1989 Toyota Land Cruiser

1 Answer

Changing 1989 toyota corolla engine to fuel injectoin


Yes, and you need a computer, and a different fuel tank system, fuel lines, and emission components from the new engine's car.

Jul 14, 2010 | 1989 Toyota Corolla 2 Door

1 Answer

2001 BMW 530 DIESEL (E39)


LEAKS AT THE INJECTION PUMP CAN BE COMING FROM DIESEL INJECTION PUMP DRIVE GEAR INNER SEAL.LOOK FOR LEAKS AT FUEL SHUT OFF VALVE AND COLD START VALVE.

Jul 08, 2010 | 2001 BMW 5 Series

1 Answer

Diesel engine misfire


DIESEL ENGINE MISFIRE.POSSIBLE CAUSES IS INJECTION PUMP TIMING OFF.RESTRICTED FUEL LINES OR FUEL FILTER - AIR - IN THE FUEL SYSTEM.CHECK FUEL LINES FROM FUEL TANK TO INJECTION PUMP FOR CRACKS AND LEAKS.

Jun 18, 2010 | 2003 Volkswagen Passat

1 Answer

Diesel 1989 F-250 set too long and will roll over


You may have to bleed the fuel system. There may be a very small air leak in the fuel supply line and after a long time idle, the fuel seeps bac into the tank, leaving an air lock in the pipe. When you go to start, this air makes its way into your injection pump & needs to be bled out before the engine will start. Begin from your fuel filter bleed valve, next the injection pump using the primer pump to transfer the fuel. Next loosen off the injector pipes and crank the engine over until fuel sprays form all the joints. Tighten injector pipes and start. It may run a bit rough for to begin with, but will soon even out. If it doesn't start, repeat bleeding of injectors.

Mar 13, 2010 | 1989 Ford F 250

1 Answer

Got a 96 diesel rodeo fuel pump leaking diesel any major points in timing or any other hints i need to no before pulling it off and sealing it


probably a job that should be left to an experienced diesel mechanic. The injection pump will have to rebuilt to stop leaks, not something than can be done without taking it apart. Then all settings must be made while running injection pump on a test bench. I know it sounds expensive but some jobs are best left to a professional.

Feb 25, 2010 | 1996 Isuzu Rodeo

1 Answer

Where is the fuel supply pump located on a 1989 VW Golf diesel?


The fuel pump is the injection pump located next to the alternator and is run by the timing belt.

Dec 30, 2009 | 1989 Volkswagen Golf

1 Answer

Toyota Town ace Diesel turbo pump continuously


is it the primming pump? if so replace it if its the the injection pump it may have to be removed and send to a service centre for repair. to save time and money you can look for a junk town ace with engine intact and take the pump from that once its ok

Sep 27, 2009 | 1992 Toyota Corolla

1 Answer

406 12valve diesel pump on a 405 diesel. lots of black smoke. any suggestions , adjustments etc? Pleeease!


there is a regulator screw on the back of the inline injection pump[. the smoke is cause someone has already tampered with this. remember 12valves are all mechanical. no programmers. so dont even consider it bieng (CHIPPED).

Apr 05, 2009 | 1989 Peugeot 405

Not finding what you are looking for?
Cars & Trucks Logo

546 people viewed this question

Ask a Question

Usually answered in minutes!

Top Toyota Experts

yadayada
yadayada

Level 3 Expert

75797 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

22114 Answers

Jeff Turcotte
Jeff Turcotte

Level 3 Expert

8152 Answers

Are you a Toyota Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...