Question about 1995 Saab 900

1 Answer

Saab 93 convertible 1999, how do you refill hydraulic roof

How do you replenish the hydraulic system on the roof mechanism on a 1999 saab convertible 93 ?

Posted by on

1 Answer

  • Level 1:

    An expert who has achieved level 1.

    Corporal:

    An expert that hasĀ over 10 points.

    Mayor:

    An expert whose answer gotĀ voted for 2 times.

  • Contributor
  • 1 Answer

To check the oil level open the boot - at the very back remove the 4 plastic clips that hold the carpet in place. Slightly to the left of the center there are 2 holes - shine a light in the bottom and look through the top one to check the level.
To add oil - fold down the seat backrest. Remove the plastic trim - held on by 4 screws and 2 pop out plastic cllips. Undo the 8 large bolts that hold the cover in place - 2 on top and 3 on front and back.Then lift up the cover from the front edge. You will then be able to get to the resevoir - you will need a funnel to poor fluid in.

Posted on Jun 28, 2009

1 Suggested Answer

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.
goodluck!

Posted on Jan 02, 2017

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

1996 saab 900s and 1999 9-3 has same roof mechanism?


ive been told it can be done but the saab 900 roof is electronic and the early saab 9-3 roof is hydraulic. i was toying with the idea of getting mine converted when it was playing up(mine saab900) hope this helps

Oct 08, 2016 | Saab Cars & Trucks

1 Answer

My saab 93 convertible 1998.roof is not working proparely the motor is working but it seems that i have a problem with the hydraulic are at fault can you tell me how to top up the fluid for it thanks


there should be a alan key port on the drive motor/pump side that if you remove will allow you to put fluid into keep in mind that this is a closed system. The fluid should not need to be topped up unless there is a leak... good luck

Sep 10, 2009 | 1998 Saab 900

1 Answer

2001 saab 93 convertible top problem


If you lower the back seat you will see a plastic cover on the botom of the opening. Remove the cover (6 appolstry fasteners) to reveal a metal box. The box is not actually a box but a cover for the hydrolic pump. Remove the fscrews from the lid and lift. The resevouar is clear and easy to check against the two fill lines on the side.

Jul 06, 2009 | 2001 Saab 9-3

1 Answer

19886 saab 900 convertible roof not working.


Hi David:

First, check the fuses for the hydraulic motor; if they're blown, replace and monitor (why did they blow? Perhaps an overload, or ...) These fuses are located in the engine bay on top of the fender by the front right wheel housing.

Next check the voltage supply to the top switch, possibly a loose connection or broken wire.

Also check relays C (raising top) and D (lowering top) under the rear seat.

Lastly check for voltage at the pump, also under the rear seat, when the switch is actuated, and that the voltage polarity reverses when the switch is actuated the other way (up or down).

After that, it's a hydraulic/mechanical problem. Check the fluid level in the pump reservoir (use SAAB fluid to top up if low) Fluid level should be at the upper marker with top down, and at the lower marker with top up.

Check behind the rear seat side panels that the piston shaft is still properly attached to the roof mechanism bracket at one end, and the piston itself is still firmly attached to the body. Look for any leakage from the system.

If all tests out OK and looks good under the rear seat and behind the side panels, then there is the possibility that the piston seals have failed and the fluid is just circulating around without activating the piston. Pistons are available (http://www.convertibletopguys.com/cgi-local/displaycat.cgi?cat=584 - scroll down) but the entire system should be removed to avoid getting hydraulic fluid on the interior.

However, that fact that you can operate the hood using the bypass valve (manually) would indicate that the hydraulics are likely OK, and that it's probably an electrical or mechanical problem.

Good luck!

Saabreur

Jun 09, 2009 | 1998 Saab 900

3 Answers

93 convertible top wont go down


This happenrd to me the first few times after filling the tank. When the roof stops push the switch to up then back until movement stops then go back to down, eventually it will get rid of all the air in the system and the roof should start to work.

Apr 30, 2009 | 2001 Saab 9-3

1 Answer

Saab 93 convertible roof won't open


Your tonneau motor is probably bad, though reprogramming the limits may fix it. You will need the factory tool, unfortunately. There is a lot of information on this webpage. Be sure to read the information relating to updates on 1995 models.

Feb 22, 2009 | 1995 Saab 900

1 Answer

SAAB convertible roof wont open


I managed to sort the problem, turns out there's a shear pin. I found this pin sitting in the bag in the back (the one the roof folds into) Now i just have to replace that and hopefully it should work

Dec 07, 2008 | 1995 Saab 900

1 Answer

Saab 2004 9-3 Convertible


Had same problem, in the boot right hand side, behind the removable panel there is :
1 - a hydraulic reservoir which must be at correct level.
2 - a black box (stc) this controls the roof system,
switch ignition off then pull the 2 connectors off for 30sec then reconnect.
This worked and hope this resolves your problem

Sep 28, 2008 | 2007 Saab 9-3 Aero Convertible

Not finding what you are looking for?
1995 Saab 900 Logo

2,531 people viewed this question

Ask a Question

Usually answered in minutes!

Top Saab Experts

Colin Stickland
Colin Stickland

Level 3 Expert

22114 Answers

yadayada
yadayada

Level 3 Expert

75797 Answers

rgbypoet

Level 2 Expert

166 Answers

Are you a Saab Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...