Question about 1961 Volkswagen Beetle

Open Question

How to remov the noise cne on 1969 vw type 1 auto shift transmission

Posted by Anonymous on

Ad

4 Suggested Answers

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
Best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of.(from cars to computers, handyman, and even drones)
click here to download the app (for users in the US for now) and get all the help you need.
Goodluck!

Posted on Jan 02, 2017

Ad
  • 34 Answers

SOURCE: 2003 vw new beetle auto transmission will not

go to a trans shop and get them to change the filter in the trans ... this may be cheap at first!

Posted on Feb 27, 2010

Ad
  • 1 Answer

SOURCE: have a 2002 auto transmission

check your engine mounts. one is probly loose. ha december hope you found it already!

Posted on Feb 18, 2011

SOURCE: 2001 VW Beetle Manual Transmission Shifting Problem

It sounds like possible slave cylinder failed or clutch needs bleeding

Posted on Nov 30, 2012

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

New 1969 c4 auto transmission has park but no reverse or netural


Is it possible the transmission was not made for a Mustang ?
With the shifter on the floor, the linkage would be different than a car with the shifter on the column.
Have you contacted the company ?

Aug 25, 2012 | Ford Cars & Trucks

1 Answer

My 1967 VW Beetle loses power real bad going up hill why


Almost all 1967 VW beetles came with a 4 speed manual transmission. A few had a "semi-automatic" transmission which was basically a VW manual transmission with an electrically actuated clutch and a torque converter. For the semi-auto, there was no clutch pedal. Instead there was an electrical connector at the bottom of the stick shift. When the driver touched the shift and started to move it to shift gears, the contact would be made and the clutch engaged. This would confuse people if they were used to driving with their hand on the stick shift.

1. If the engine is racing when you go up the hill, then the clutch may be slipping. If you have the semi-auto, then the torque converter may be bad.

2. If the engine is not racing and you're just losing power, then there may not be enough gas getting to the engine. Check the fuel pump output as another answer suggests. The carb's float and needle valve may not be opening all the way, thereby not allowing enough fuel into the carb. Or, you may have a partially blocked main jet in the carb which is not letting enough fuel to flow into the engine.

Jan 06, 2011 | Volkswagen Beetle Cars & Trucks

1 Answer

Manual transmission, 4 cylinder, removing from vw ...


IF YOU REMOVE ALL SIDE MOUNT BOLTS AND TRANSMISSION MOUNT BOLTS REMOVE SHIFT AND RELAY SHAFT RODS IF EVERYTHING BEEN REMOVED AND DISCONNECTED TRY PRYING TRANSMISSION AWAY FROM ENGINE.DO IT EASY NOT HARD TRANSMISSION COULD BE CAUGHT ON SOMETHING.

May 16, 2010 | Cars & Trucks

1 Answer

I have a 2001 volkswagen golf 2ltr auto. When the car is driving in second it feels like it drops out of gear. I makes a clunk noise and the car loses power for about 1 second then engages again. This...


go to the vw dealer and tell the service advisor you want them to "reset basic settings on my transmission". i used to be a tech at a vw dealer and this fixes about 90% of all transmission shifting issues. they will charge you iether .5 or 1.0 hrs labor for this although it only takes about 5 minutes.

Feb 01, 2010 | 2001 Volkswagen Golf

1 Answer

2002 vw Cabrio\ transmission doesn't shift out of second.


Is it a auto tranny? Might be your fluid levels check those. Also could be your detent cable. If manual tranny and has a hydro clutch check those fluids. Just some stuff to check. I would hate to say change your transmission.

Jan 06, 2010 | Volkswagen Cabrio Cars & Trucks

1 Answer

The manual transmission seems noisy so I wanted to replace the fluids or at least add some Z-Max to try and quiet the noise. I cannot find the add and drain plugs anywhere. There must be a way to do this!


Condition: Some customers may comment on a grinding or rattle type noise coming from the transmission. The noise usually occurs with the transmission in first or second gear at low RPMs and can be intermittent.
Cause: This condition may be originated by the natural harmonics of the engine that leads to a vibration in the transmission.
Correction: There are two separate noises. Follow the diagnostic procedures listed below to determine which noise the vehicle has and perform the outlined repair. If you are comparing like vehicles, you must compare vehicles with the same motor and similar mileage.

Diagnosis for Noise #1
This is a very distinct noise that is usually much louder than the second noise that can be associated with this transmission. If the vehicle is not making any noise when trying to verify the condition, it can be induced by making several tight left hand circles with the vehicle at normal operating temperature.
Making a sharp right hand turn will usually stop the noise. While the noise is occurring, in order to
distinguish between the two noises, you can press lightly on the clutch pedal without releasing the clutch and the noise will NOT go away or change. As a second diagnostic aid, while the vehicle is making the noise, shift to third gear and the noise will stop. If the noise is determined to be this type, perform the repair for noise #1.

Repair for Noise #1.. Replace the transmission fluid with Saturn Manual Transmission Lubricant, P/N 21018899. Overfill to a capacity of 2.4L (2.6 qts). A possible side effect of this repair may be a higher shift effort.
Solution #2 Capacity of 2.4L (2.6 qts). A possible side effect of this repair may be a higher shift effort.
1. Raise and support the vehicle. Refer to Lifting and Jacking the Vehicle in the General Information
sub-section of the appropriate Service Manual.
2. Place a suitable container under the transmission assembly.
3. Remove the drain plug located on the bottom of the transmission and completely drain the fluid.
4. Re-install the drain plug. Tighten the drain plug to 38N·m (28 lb ft).
5. Lower the vehicle.
6. Remove the fill plug located on the top/middle of transmission on the driver side, near the red
vent cap. If you use the check level plug on the side of the transmission, you will not be able to
overfill the transmission.
Important: Fill the transmission to the amount specified. Too much lubricant will cause the fluid
to leak from the vent. Not enough fluid will defeat the purpose of this bulletin.
7. Fill the transmission with 2.4L (2.6 qts) of Saturn Manual Transmission Lubricant P/N 21018899.
DO NOT USE THE RED VENT CAP TO FILL.
8. Re-install the fill plug. Tighten the fill plug to 38 N·m(28 lb ft).
Diagnosis for Noise #2
This noise, commonly referred to as gear rattle, can be induced by lugging the engine in any gear, but is
usually most noticeable in first or second gear. While the noise is occurring, if you press lightly on the clutch pedal without releasing the clutch, the noise will be reduced or eliminated.
Repair for Noise #2
Do not attempt to repair this noise. This is a characteristic of the vehicle and any vehicle equipped with a manual transmission can be made to make a similar noise. Driving at slightly higher engine RPM levels will reduce this noise.

Oct 03, 2009 | 2001 Saturn L-Series

1 Answer

How do i change my vw 2.5 trans fluid. and how much would it cost. Because my gears are getting ruff . i have 81000 miles. what should i do ..........please i need some help


Fluid - M/T: Service and Repair
Transmission Oil, Draining
Transmission oil, draining
To catch gear oil, use a clean container with 3.0 liter capacity with a scale.
^ Shift rod is secured.
66e891f.jpg - Drain gear oil by removing oil drain plug - arrow 1 - and then pivot pin - arrow 2 -.
- Install pivot pin - arrow 2 - with a new O-ring
- Screw in oil drain plug - arrow 1 -.
24c9af8.jpg - Now rotate bracket - A - back into initial position in direction of - arrow - so that shift rod moves freely again.






Fluid - M/T: Service and Repair
Transmission Oil, Filling
Transmission oil, filling 04A, 5 Speed M/T
Top off gear oil quantity in container to 1.7 liters.

6d27665.jpg - Remove switch for Back-Up Light Switch F4 - arrow -.
- Connect a standard hose (approximately 600 mm long, outer circumference 10 mm) with funnel.
- Insert hose into mounting hole of back-up light switch (2nd technician) and fill the transmission oil.
- Reinstall switch for Back-Up Light Switch F4 - arrow -.
- Check function of selector mechanism.
- Install complete air filter housing.
- Install noise insulation.

Oct 01, 2009 | 2006 Volkswagen Jetta

3 Answers

2000 vw Jetta TDI transmission fluid change


The dealer is correct. It is a sealed system, there are no drain plugs/bolts for the transmission fluid. The only way to remove the old fluid is to go to a VW dealer and let them use a special "vacuum" type machine that will **** out the old and put in new fluid. However, if you are not having issues with the transmission than there is no need to replace the fluid because it is supposed to last the lifetime of the vehicle on this VW.

May 22, 2009 | 2000 Volkswagen Jetta TDI

1 Answer

Truck wont shift automatic. stays in 3rd gear. can shift manually


either repair or replace the transmission...sounds like the sensor went out

Dec 14, 2008 | 2001 Dodge Dakota

1 Answer

Vw 2000 jetta tdi (a/t shifting problem)


Your right in as much as it shouldnt need complete over haul but a competent auto trans technician to clear the shift fault.It could be a solenoid or check valve that should be able to be repaired with out the transmission having to be removed.

Oct 26, 2008 | 2000 Volkswagen Jetta TDI

Not finding what you are looking for?
1961 Volkswagen Beetle Logo

Related Topics:

13 people viewed this question

Ask a Question

Usually answered in minutes!

Top Volkswagen Experts

Colin Stickland
Colin Stickland

Level 3 Expert

22219 Answers

yadayada
yadayada

Level 3 Expert

76682 Answers

Jeff Turcotte
Jeff Turcotte

Level 3 Expert

8531 Answers

Are you a Volkswagen Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...