Question about 1999 Mitsubishi Montero Sport

1 Answer

I NEED TO REBUILD SMALL BLOCK IN 2002 MONTERO SPORT 3.5 NEED REBUILD INSTRUCTIONS AND DIAGRAMS

My 2002 3.5 oil lite came on and then stop running. The engine overheated, made some small bottom end noises and so I stop driving. Took off oil pan and oil suction screen was 90% clogged. The clog was the result of pep boys pouring radiator sealer in oil fill tube. Although pep boys changed the oil four times my Montero Sport had the problems mentioned above six months later. I have taken the top manifoilds and other parts in order to tune up engine. I have also clean suction screen. Should I put the top end back together and see if the clean suction of oil has solved the problem or go ahead and tear into the short block to see if there was any other damage?

Posted by Anonymous on

Ad

1 Answer

  • Level 3:

    An expert who has achieved level 3 by getting 1000 points

    All-Star:

    An expert that got 10 achievements.

    MVP:

    An expert that got 5 achievements.

    Genius:

    An expert who has answered 1,000 questions.

  • Mitsubishi Master
  • 2,460 Answers

You should check the big end and crank main bearings for damage.

Posted on Apr 04, 2017

Ad

6 Suggested Answers

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
Best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
New users get 2 Free calls (no credit card required) and instant help on almost anything you can think of (from cars to computers, appliances, handyman, and even pets).
click here to download the app (for users in the US for now) and get all the help you need.
Goodluck!

Posted on Jan 02, 2017

Ad
  • 11 Answers

SOURCE: Clicking in Mitsubishi Montero Sport

from what you are discribing the chances are your tappets at the top of your engine are tapping i will advice you tou get them changed the longer you leave them you will get more problems with your engine

Posted on Sep 11, 2008

  • 6 Answers

SOURCE: Oil Light flickering when coming to a stop

clean and or replace the terminal and sender for the oil pressure. they corrode pretty badly

Posted on Dec 22, 2008

  • 1986 Answers

SOURCE: Gear Neutral light blinking while the gear is on

I believe it means that your transmission fluid is either getting too hot, or there's not enough fluid

Posted on Oct 08, 2009

  • 173 Answers

SOURCE: how to change the timing belt of the 6G74 3.5 v6

Hello... This is a very involved procedure... To complex to list it here. If you go to www.autozone.com they list the procedure with diagrams.

Good Luck...

Drumbe

Posted on Feb 04, 2010

c17hydro
  • 2984 Answers

SOURCE: i need a timing belt diagram for a 2002 mitsubushi

Please don't forget to rate....thanks-


56af9d5.gif
Timing belt alignment marks—3.0L and 3.5L engines

Posted on Feb 27, 2010

Testimonial: "Thanks for the diagram any easy to change this belt?"

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

2001 montero sport xls sport horn on my alarm how do i stop it i pulled the fuse but it is still goint


You need to determine if it's the horn or the alarm. My Montero (not Sport) had 3 horns. All 3 of which go off w/ the Alarm, but only one is connected to the horn on the steering wheel. I could not make mine go off w/o pulling the relay under the hood.

My spring was bad in the steering wheel. I was able to bypass the wire using instructions that I actually found on a Mitsubishi Forum. Link below:

http://mitsubishiforum.com/forum/mitsubishi-montero-montero-sport-14/horn-wouldnt-stop-2003-montero-limited-how-i-fixed-37779/

or

http://www.pajero.guru/how-to-fix-pajero-stuck-horn-problem-step-by-step-guide/

Sep 19, 2016 | 2001 Mitsubishi Montero Sport XLS

2 Answers

The oil warning lite came on and now there is knocking in the engine what should I do first?


You ran it out of oil! Dont Drive it or run it! Get at Least 2 qts of oil and put it in the engine. See if the knocking goes away when you start it. IF IT DOES NOT, YOU NEED A COMPLETE ENGINE OVERHAUL or a new engine

Sep 06, 2013 | 2002 Mitsubishi Montero Sport

1 Answer

I have suction where i put oil in, when i remove the cap the car trys to stall what do I do? 2002 montero sport limited


You don't add oil with the car running

You broke the vacuum for the crankcase evacuation
(PCV System)

If you have idle problems then they have to be diagnosed

Dec 06, 2012 | 2002 Mitsubishi Montero Sport

1 Answer

I have a 98 mitsubishi montero sport that has a small oil leak. i need to know how to fix it


It all depends where it is leaking. You may have a bad seal. If so, you will have to take off the block to get to your valves. Like I said, it just depends where the oil comes from. Make sure all your bolts are tight. They loose up after time.

Feb 23, 2011 | 1998 Mitsubishi Montero Sport

1 Answer

My 2002 Montero Sport continues to run hot


Make sure there is no air in the cooling system,and that the cooling fan is working,coming on,and going off on it`s own.if it is not ,replace the coolant sensor.

Jul 31, 2010 | 2002 Mitsubishi Montero Sport

1 Answer

What is the best kind of oil to use in a 2002 Montero Sport?


I would recommend 10w30,but the main thing is to keep changing you oil every 3000 miles and keeping up with the oil level

Apr 14, 2010 | 2002 Mitsubishi Montero Sport

1 Answer

I need a timing belt diagram for a 2002 mitsubushi montero sport 3.5L


Please don't forget to rate....thanks-


56af9d5.gif
Timing belt alignment marks—3.0L and 3.5L engines

Feb 27, 2010 | 2002 Mitsubishi Montero Sport

2 Answers

Where is the timing mark in the crankshaft of a 2000 montero sport


Click on the following free direct Link. It has the Timing: Belt and Mark Diagrams for your 2000 Mitsubishi Montero Sport. Plus additional Instructional and Directional Diagrams.

Let me know if this helped, or if you have additional information or questions. Feel Free to contact me at FixYa.com!

http://www.2carpros.com/car_repair_information/year/2000/make/mitsubishi/model/montero_sport/2000_mitsubishi_montero_sport_timing_belt_diagram_marks.htm

Dec 13, 2009 | 2000 Mitsubishi Montero Sport

3 Answers

Lifter sound in the morning


check your oil for low level or you probably
need valve adjustment

Apr 04, 2009 | 1998 Mitsubishi Montero Sport

Not finding what you are looking for?
1999 Mitsubishi Montero Sport Logo

Related Topics:

26 people viewed this question

Ask a Question

Usually answered in minutes!

Top Mitsubishi Experts

yadayada
yadayada

Level 3 Expert

76630 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

22219 Answers

Jeff Turcotte
Jeff Turcotte

Level 3 Expert

8516 Answers

Are you a Mitsubishi Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...