Question about 2002 Hyundai Santa Fe

1 Answer

2002 hyundai santa fe

Customers car was driving down the street when they heard a "pop" and the car suddenly stalled. When I arrived, I noticed the fuel pump was not priming. I found that the fuel safety cut off switch had tripped. I reset it and the fuel pump started working but the car still would not start. I towed to my shop and it has codes for CMP sensor circuit failure. I noticed the CKP sensor was totally cooked and falling a part. So, I replaced both of them. The car also has a code for MAF sensor low voltage. I check for clogged air filter, cleaned the already impeccably clean MAF sensor.. no change. Also getting a code for Bank 1 catalytic below efficiency. and bank 1 sensor 2 beyond maximum threshold. I have yet to do anything about them because, except when COMPLETELY clogged.. I doubt that a cat would prevent a car from starting. I'm not sure where to go from here.. I am not familiar with any procedure on how to test the MAF, if there is a test. I checked wiring for wear/corrosion, none to be found. A friend of mine with a Tiburon had the same issue with his CKP, ended up having to replace the toothed wheel that the sensor reads along with the sensor.. I don't understand how a toothed wheel inside the crank case could ever become damaged/need to be replaced but, if it happens, it happens.

Posted by on

  • 1 more comment 
  • Nicolas Hardcastle
    Nicolas Hardcastle Apr 08, 2014

    So, I preplaced CKP, CMP sensors and bank 1 cat. No start. The coils are not producing any spark. Where do I go from here?

  • Nicolas Hardcastle
    Nicolas Hardcastle Apr 08, 2014

    I found something about "igntion failure sensor" but I can't find a picture of it on the 2.7ltr V6

  • Nicolas Hardcastle
    Nicolas Hardcastle Apr 08, 2014

    I measured the resistance of the coils.. my service manual says they should measure ~.6ohms on the primary winding.. I was reading 2.6-4ohms depending on the coil. the green wire connecting to the coils is getting battery voltage when the ignition is turned to the on position. so I replaced the coils. Still getting no spark.

×

Ad

1 Answer

  • Level 1:

    An expert who has achieved level 1.

    Hot-Shot:

    An expert who has answered 20 questions.

    Corporal:

    An expert that has over 10 points.

    Mayor:

    An expert whose answer got voted for 2 times.

  • Contributor
  • 59 Answers

Sounds like the immobilizer has cut out the system. Also it could be the computer box has failed. Need to take it to the agents to put on there machine (GDS) to maybe code the keys

Posted on May 11, 2014

Ad

3 Suggested Answers

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.
goodluck!

Posted on Jan 02, 2017

Ad
ghost4548
  • 776 Answers

SOURCE: 2002 Hyundai Sonata code reads P0430 what does this mean Catalyst System Efficiency Below Threshold (Bank 2)

That's a pretty RELIABLE code!... You have a bad CAT (Catalytic Converter). Trust it to be accurate. The conditions which set this code is when the Upstream O2 sensor's data/signal is compared to the Downstream sensor's data/signal... when they are nearly identical, that's when this code is set (unless you have an exhaust leak).. If there is an exhaust leak.. repair it, then retest/recheck.

Posted on May 31, 2009

jcampo1000
  • 165 Answers

SOURCE: what can cause a 2005

i would check ur fuses that supply voltage to ur o2 sensors, their in the fuse box and usually r labeled o2 sensr. sounds like the o2 sensrs dont have power

Posted on Apr 09, 2011

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

2 Answers

What would be wrong when my car has gas, but no spark?


2001 Sante Fe Won't Start, Cranks But No Spark. - Hyundai Forums ...

www.hyundai-forums.com/...santa-fe/112601-2001-sante-fe-won-t-start-...
Jul 23, 2010 - 10 posts - ‎3 authors I have a 2001 Hyundai Sante Fe that died on me while driving down my street. ... Thecar has many other unrelated problems and I am not sure I want to ... may be causing my two cylinder no spark and alleged fuel problem? 2006 Santa Fe 2.4 Engine swap-no spark
10 posts
Sep 24, 2012
No Start 2.4L Engine 2004 Manual
10 posts
Nov 26, 2011
Good Crank/Have Fuel pressure/NO IGNITION
10 posts
Oct 9, 2011
Car Cranks But Will Not Start
10 posts
Jan 16, 2008
More results from www.hyundai-forums.com

Engine cranks but won't start.What should I do. - YouTube

? 9:37
https://www.youtube.com/watch?v=jsQcLya1YLQ
Jan 24, 2014 - Uploaded by jimthecarguy
No Start Cranks Ok No Injection Pulse 2002 Hyundai Accent Easy Step By Step ... and car cut off, but would not restart. it sounds like it is starving for fuel. ... hi nice video man . i have no sparkno fuel .u think its the main? it was ...

Nov 26, 2015 | 2001 Hyundai Santa Fe

5 Answers

2009 Hyunda Santa Fe stalls while driving


I had a similar problem with my Santa Fe. It occurred intermittently but after I turned the steering wheel to the left. After much screwing around by the dealer and trying to baffle me with BS we heard about a strange solution. I am not a mechanic but the problem somehow related to a spring in the Airbag on the steering wheel. Changed the spring and "Stone the flame'n crows" problem solved. Never had a problem since.

Jul 27, 2012 | 2003 Hyundai Santa Fe

1 Answer

2003 Hyundai Santa Fe feels like its going to stall


more than sure,o2 senser+catl conv,nothing else.

Feb 19, 2012 | 2003 Hyundai Santa Fe

1 Answer

I have a 2002 hyundai santa fe. I want to change the oil filter on it but not the oil itself. I was told that to change the oil filter on this car you have to have a complete oil change. Is this true? I...


neither have i to be honest ,i change oil filter every third oil change on my regular customers cars with a oil change every 6000km or so ,never a problem and i have often changed a filter on some cars without changing teh oil where the metal cannister has started leaking

Jan 19, 2011 | 2002 Hyundai Santa Fe

1 Answer

My 2002 hyundai santa fe just stops,when im driving with my foot on the gas it stalls and loses all power then if i wait 5-10 min it starts back up


more than likely the crank sensor is the fix. once the engine cools down the sensor also cools .
if you could take it out right away and shoot freon on it and put it back in it would start wright up.

Dec 24, 2010 | 2002 Hyundai Santa Fe

1 Answer

My car stopped driving all of a sudden i heard a little pop sound and then no drive reverse. i had it towed in and the mechanic just said he thinks it the syb frame eroded. does that have anything to do...


what the hell is a 'syb frame'? besides a little 'pop' sound, what else happened? Solution?.. Take it to a competent technician (Hyundai Technician).. .they you'll know what the problem 'ACTUALLY' is and what's needed to fix it (guaranteed repair).

Sep 10, 2009 | 2001 Hyundai Santa Fe

1 Answer

How do I replace fog lights on my 2002 Hyundai Santa Fe?


Look up into the bumper and see if you can access the fog light. The bulb should just twist out of the back. If not, the assembly should either pop forward or back to come out. I've heard though, that many santa fe's require the removal of the entire front bumper fascia just to get to the bulbs in which case you'd have to remove your headlights to get to the screws holding the bumper fascia on

Sep 09, 2009 | 2002 Hyundai Santa Fe

2 Answers

2002 hyundai santa fe transmission will not engage


You might have lost your lower gears, I would have someone look at it to see if your gears are gone or if its just a faulty sensor.

Jun 15, 2009 | 2002 Hyundai Santa Fe

1 Answer

2003 santa fe 2.4l stalled going down street will not restart


was the engine lite on before it quit? maybe there is a code in the system that will direct to the cause area. my first guess with those symptoms would be a crank position sensor.

Dec 05, 2008 | 2003 Hyundai Santa Fe

Not finding what you are looking for?
2002 Hyundai Santa Fe Logo

111 people viewed this question

Ask a Question

Usually answered in minutes!

Top Hyundai Experts

yadayada
yadayada

Level 3 Expert

76164 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

22156 Answers

Jeff Turcotte
Jeff Turcotte

Level 3 Expert

8273 Answers

Are you a Hyundai Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...