Question about 1989 Ford Aerostar Cargo

1 Answer

93 Aerostar 3.0 Not Starting

My 1993 Ford Aerostar, with a 3.0 L, stopped like it was running out of gas. Fuel Pump works, get a good spark, only code is 565 for the Fuel Canister Purge. Its had this code for a year and still running.

Posted by on

  • stnii Jul 14, 2009

    Have not done one but that is the next on the list to check when I can get to it.

  • Thomas May 11, 2010

    Compression check?

×

Ad

1 Answer

  • Level 2:

    An expert who has achieved level 2 by getting 100 points

    MVP:

    An expert that gotĀ 5 achievements.

    Governor:

    An expert whose answer gotĀ voted for 20 times.

    Hot-Shot:

    An expert who has answered 20 questions.

  • Expert
  • 122 Answers

First check for fuel pressure to your injectors clean the canister & check you intake cause you need three items to start spark'fuel & air if thats all good then you need to retime the fireing order & make sure your getting spark in all plugs & not just one

Posted on Jun 04, 2009

Ad

1 Suggested Answer

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya Mechanic can help you resolve that issue over the phone in a minute or two.
Best thing about this new service is that you are never placed on hold and get to talk to real repair professionals here in the US.
click here to Talk to a Mechanic (only for users in the US for now) and get all the help you need.
Goodluck!

Posted on Jan 02, 2017

Ad

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

92 ford aerostar good fuel pressure, plenty of spark, spins like crazy good battery , air intake good but fuel pump runs non stop and engine want start. acts like no run signal being enabled. is there a...


There is a fuel pressure regulator on the fuel rail. It could be bad. To check this pull off the vacuum line and turn the ignition on without trying to start the car. If fuel comes out of the vacuum hose fitting the fuel pressure regulator is bad. Another possibility is a bad fuel pump. Check your fuel preasure. If low or non exisitant replace fuel pump only after checking fuel pressure regulator. Good luck.

Sep 23, 2011 | 1992 Ford Aerostar Extended

1 Answer

I got a 93 ford areostar. i just replaced the front caliper and rotor. i started it up went to push the gas and it dies. empty tank. i went o put gas in the tank and it has spark and fuel delivery but it...


  1. sound like a bad vacume leak start there first if not fuel pump check put your head bye the back tire and have some on turn the key to the on pos listen for humming sound if no humming a bad pump
sec check for spark pull a spark plug wire off and with a screw driver against the metal turn the key and look for spark try that

Jan 27, 2011 | 1993 Ford Aerostar Extended

1 Answer

How to change afuel pump on a 1993 Aerostar ford van


put the van up on ramps in the rear, unbolt gas tanks straps, hopefully u take gas out before, take clamps off filler neck and pull big and small hose off let tank down slow and disconnect wiring plug and fuel lines to pump then pull tank out from under van. very carefully unscrew big washer that holds pump in, put in new pump and reassemble the way you took it out, good luck, remember be gentle with fuel lines and wiring

Jan 05, 2011 | 1993 Ford Aerostar Extended

1 Answer

Location of fuel pump wiring harness for a 1993 ford aerostar


Fuel pump is most likely in the gas tank. Wiring harness would be attached to it.

Jun 18, 2010 | 1993 Ford Aerostar Extended

2 Answers

Does the 1993 ford aerostar van have a fuel pump or fuel injectors


it has both a fuel pump in the gas tank and the injectors in the engine...i own a 1993 forrd aerostar and replace the fuel filter, and fuel pump thats how I know...

Nov 24, 2009 | 1993 Ford Aerostar Extended

1 Answer

93 ford aerostar 4.o engine head bolt torque


step one is 22 ft lbs.
step two is 52 ft lbs
step #3 is turn an additional 90 degrees. sart in the middle and work your way out going top tobottom, good luck.

Nov 03, 2009 | 1993 Ford Aerostar Extended

1 Answer

1989 ford aerostar will not start when engine is warm.


AM temp 55 car started but stalled out after starting. Attempted to restart and did not hear fuel pump. Tried again and then fuel pump kicked in. Checking fuel pump inertial switch and fuel pump electrical supply.

Apr 19, 2009 | 1989 Ford Aerostar Cargo

1 Answer

93 Trooper cranks, but won't turn over


have someone kick at the gas tank while you are turning key if it starts it is fuel pump

Aug 05, 2008 | 1993 Isuzu Trooper

1 Answer

'93 Aerostar-stalls while driving/scary-stalls in 'drive' at stops


Wow!!! Now that's a headfull of problems....
This could be a great many things...
Check these before you sell. I have a '93 Aerostar and can't live without it.
1. Check idle speed
2. Fuel filter may be clogged or water in the fuel system.
3. Choke improperly adjusted or sticking.
4. Distributor components damp or damaged.
5. Faulty emissions components.
6. Faulty or incorrectly gapped spark plugs/ Also check wires.
7. Vacuum leak at the carburetor/fuel injection unit or vacuum hoses.
8. On 1986 models, stalling during idle or deceleration may be caused by sludge in the throttlebody. (2.3 litre engine)
9. On 1986 & 1987 models with a 2.3 litre engine,hesitation or stalling during acceleration may be caused by carbon build-up on the intake valves.....I hope this helps!! Adios

May 23, 2008 | 1993 Ford Aerostar Extended

Not finding what you are looking for?
Cars & Trucks Logo

338 people viewed this question

Ask a Question

Usually answered in minutes!

Top Ford Experts

yadayada
yadayada

Level 3 Expert

77202 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

22265 Answers

fordexpert

Level 3 Expert

5581 Answers

Are you a Ford Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...