My 2001 f-250 4x4 (gas) keeps blowing the gauge fuse. The owners manual says that fuse also controls the cruise cancel switch and the GEM module. When the fues does blow I still have dash lights but all gauges do not work. Is this a cluster problem or should I be looking some where else?
SOURCE: 2003 F350 Intrument Cluster
If everything keeps going like that then it sounds like its a problem with the onboard computer. The computer controls all the guages and would explain why they all fail at the same time.
SOURCE: after replacing the gem module does it has to be programed
You definitely have a wiring problem. Fuses are blowing because DC (direct current) power is being short circuited by touching a grounded surface area or a negative wire. If its affecting two interior car functions while on the same fuse circuit, then check where the wires from both functions could or would intersect. In your case the windows roll down and the interior lights come on....they could intersect somewhere near the front door jamb or farther forward towards the fuse panel.
SOURCE: Location of GEM Module on 1998 Ranger
i am almost sure it is in steering col area by firewall. but call any part store like auto zone and they can print it out and tell you if your ford dealer wont. but on the fords they usualy are all in the drivers steering area sometimes way up by fire wall
SOURCE: Instrument cluster not showing odometer and
It could be the voltage regulator for your instrument cluster is the problem.
http://schematicsdiagram.blogspot.com/2011/12/fuel-gauge-jumps-from-empty-to-full.html
--------------
•
Oldsmobile Temperature Gauge Lamp Switch?
-----------------
http://technoanswers.blogspot.in/2012/02/dodge-neon-gauges-not-working.html
------------
http://schematicsdiagram.blogspot.com/2011/12/temperature-gauge-went-up.html
------------
http://repairhelpcenter.blogspot.in/2012/02/how-to-replace-instrument-panel-and.html
-----------
http://technoanswers.blogspot.in/2012/02/how-to-remove-instrument-panel-on.html
-----------
If
all voltages checked ok, then most probably its faulty instrument cluster board
on which gauges are connected. Yes if cluster circuit board looks ok, then also
it can be faulty. Somewhere there is minute short or burn on board then such
problem arises.
Also
check the fuse box. One under hood and other under dash.
Inspect
each and every fuse and see if all are fine or not.
---------------
For
more troubleshooting on these cluster gauges I suggest you to refer the list of
help links mentioned below. Its step by step instructions will help you to
confirm the exact cause of problem in these conditions: ---------
Click
the link below: ------
2004 Toyota Tundra:
Oil Gauge and Temp Gauge Not Working?
http://howtobyme.blogspot.in/2012/05/2004-toyota-tundra-oil-gauge-and-temp.html
--------------
2005 Lexus SC430: Fuel Door, Dome light and Fuel Gauge Fuse
Location?
http://howtobyme.blogspot.in/2012/05/2005-lexus-sc430-fuel-door-will-not.html
----------
Toyota 4Runner:
Temperature Gauge Sensor
http://technoanswers.blogspot.in/2012/04/toyota-4runner-temperature-gauge-sensor.html
------------
Temperature gauge sits over half way mark?
http://schematicsdiagram.blogspot.in/2012/04/temperature-gauge-sits-over-half-way.html
---------------
Heater blows intermittently and temp gauge goes erratic?
http://technoanswers.blogspot.com/2012/01/heater-blows-intermittently-and-temp.html
----------
Temperature gauge does not move and no heat when heater is
ON?
http://technoanswers.blogspot.com/2012/01/temperature-gauge-does-not-move-and-no.html
-----------
2003 Pontiac
Grand Prix: Erratic Fuel Gauge?
http://technoanswers.blogspot.in/2012/06/2003-pontiac-grand-prix-erratic-fuel.html
-----------
Temperature gauge keeps fluctuating up and down close to
red?
http://technoanswers.blogspot.com/2012/01/temperature-gauge-keeps-fluctuating-up.html
-------------
Temperature gauge on the dash quit working on Pontiac Grand
Prix?
http://technoanswers.blogspot.com/2012/01/temperature-gauge-on-dash-quit-working.html
---------------
Fuel gauge jumps from empty to full?
http://schematicsdiagram.blogspot.com/2011/12/fuel-gauge-jumps-from-empty-to-full.html
--------------
Gas gauge stuck on empty on 2002 Mercedes Benz 240c?
http://repairhelpcenter.blogspot.in/2012/02/gas-gauge-stuck-on-empty-on-2002.html
---------------
• Oldsmobile
Temperature Gauge Lamp Switch?
-----------------
Fuel gauge drops to Empty?
http://technoanswers.blogspot.com/2012/01/fuel-gauge-drops-to-empty.html
----------------
Dodge neon gauges not working?
http://technoanswers.blogspot.in/2012/02/dodge-neon-gauges-not-working.html
------------
Temperature gauge went up?
http://schematicsdiagram.blogspot.com/2011/12/temperature-gauge-went-up.html
------------
Temperature gauge stays At cold on jaguar?
http://technoanswers.blogspot.in/2012/02/temperature-gauge-stays-at-cold-on.html
-----------
How to replace Instrument panel and dashboard on Toyota
car?
http://repairhelpcenter.blogspot.in/2012/02/how-to-replace-instrument-panel-and.html
-----------
How to remove instrument panel on Chevrolet car?
http://technoanswers.blogspot.in/2012/02/how-to-remove-instrument-panel-on.html
-----------
How to remove control panel on Buick regal?
http://howtobyme.blogspot.in/2012/02/how-to-remove-control-panel-on-buick.html
---------------
These
details will help.
Thanks.
225 views
Usually answered in minutes!
×