Question about 2002 Volkswagen Passat

2 Answers

Waste gate jammed on torbo on 2002 passat

Hi i was driving recently and here a pop and black smoke came from under my passat i got out and looked and under the car one of the turbo pipes had blown open the toewin company said toubo building up to much possible waste gate jammed or turbo fault i want to fix it mysaelf but need a diagram of the vw turbo and waste gate

Posted by on

Ad

2 Answers

  • Level 3:

    An expert who has achieved level 3 by getting 1000 points

    Superstar:

    An expert that got 20 achievements.

    All-Star:

    An expert that got 10 achievements.

    MVP:

    An expert that got 5 achievements.

  • Master
  • 3,600 Answers

Go to alldata.diy.com pay $20.00 to get detailed info on the trubo, most likey the hose is wore out the rubber hose and will have to be replaced the waste gate keeps from over boosting the engine so if the hose is worn the clamps won't hold it any more. remove the hoses on the turbo wiggle the turbo shaft back and forth and end to end there should be no play in the shaft if there is you need a turbo kit and can buy one to rebuild it, look up bell turbos in oregon on the net and get his number he can tell you the cost of the kit and how to rebuild. If you have excessive oil on the rubber hose then you have a blown oil seal and it will need to be replaced. you are lucky at this pont and the kit will come with what you need to fix the waste gate as well, but dought the gate is the problem.

Posted on May 24, 2009

Ad
  • Level 2:

    An expert who has achieved level 2 by getting 100 points

    MVP:

    An expert that got 5 achievements.

    Governor:

    An expert whose answer got voted for 20 times.

    Hot-Shot:

    An expert who has answered 20 questions.

  • Expert
  • 88 Answers

Lokk its simple put hose back right eay lot of pressure there pull off intake tube kep motor aT BOUT 3GRAND SPRAY ORIELY CARB CLEANER IN IT HALF CAN through throttle body will clean out let me know if any prob hey vote for me ok

Posted on May 24, 2009

Ad

1 Suggested Answer

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
Best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
New users get 2 Free calls (no credit card required) and instant help on almost anything you can think of (from cars to computers, appliances, handyman, and even pets).
click here to download the app (for users in the US for now) and get all the help you need.
Goodluck!

Posted on Jan 02, 2017

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

2006 KJ Cherokee 2.8lt turbo diesel manual. When I accelerate engine surges then flat spot then surges again as it accelerates there is also a lot of black smoke coming out of the exhaust pipe


There is a waste gate on a turbo and that gate dumps the excess pressure in the manifold. There is a sensor that determines when the gate opens and closes. You need to run a diagnostic scan and see what the waste gate and sensors are doing.

Jan 28, 2017 | Cars & Trucks

1 Answer

Nissan navara black smoking and turbo not pulling


turbo is screwed or waste gate is stuck open

Feb 28, 2014 | Nissan Cars & Trucks

1 Answer

Black smoke in the exhaust and in high rpm white on passat 1.9tdi


this case , you have to check turbo charger , when high RPM white smoke means lubricate oil goes to engine so give white smoke . on low rpm trubo close coming black smoke means no enough air gose to engine so this need to replace turbo . some type of turbo can be clean the wase gate ( which open with diafam beside turbo) make sure it's moving when accilerate. check vacum is ok . then clean wase gate > only some type have wings inside )if no replace turbo

Jul 30, 2011 | Volkswagen Passat Cars & Trucks

1 Answer

My sun roof will not close. it get within once inch of being closed then opens back up. i have a 2002 volkswagon passat


Try manually moving the deflector that pops up as the roof is opened. Something may be jamming it and preventing it from retracting.

Jun 01, 2011 | 2002 Volkswagen Passat

1 Answer

My 2004 passat TDI is giving me an exhaust leak sound noise.


This vehicle certainly does have a waste gate and they do have problems. However the waste gate diverts exhaust internally so you would not hear any unusual noise if it was being problematical. Also if the expected boost from the turbo did not match the actual boost there would be a check engine code and light on. If the hoses between the Turbo & the intake have a leak there may be a similar loss in power depending on the extent of the leak. It would be best to scan the engine computer to see if there are any Codes.

Dec 31, 2009 | 2004 Volkswagen Passat

3 Answers

I have a 2002 vw passat. it has white smoke!!


Does the smoke occur all the time? If it is present just after start up and then goes away, it could be no problem at all. There is always some condensation in the exhaust at start up. It is more noticeable in cold weather.

However, if it is there constantly, and you are losing coolant, it could mean there is a headgasket problem. Watch your coolant level and watch your temperature gauge. If the coolant starts disappearing, and the car starts overheating, stop it immediately and get it to an auto repair shop. Driving a car with a bad headgasket can cause major engine damage.

Oct 20, 2009 | 2002 Volkswagen Passat

1 Answer

Citroen dispatch with thick black exhaust smoke.


Try blanking off the EGR valve where it mounts on the exhaust manifild, they dont do much usefull but are unreliable and leak ehaist gasses into the inlet, also they take pressure off the torbo leading to over fuelling.

Aug 03, 2009 | 2006 Peugeot 604

1 Answer

Turbocharger hose and black smoke


Blace smoke is fuel to much of it are you talking about the vaccume line thea goes from the turbo to a tee then the wast gate and a sensor under the air box thenthen up to the bottom of the air box?

Dec 11, 2008 | 1992 Mitsubishi Eclipse

Not finding what you are looking for?
2002 Volkswagen Passat Logo

536 people viewed this question

Ask a Question

Usually answered in minutes!

Top Volkswagen Experts

Colin Stickland
Colin Stickland

Level 3 Expert

22219 Answers

yadayada
yadayada

Level 3 Expert

76649 Answers

Jeff Turcotte
Jeff Turcotte

Level 3 Expert

8518 Answers

Are you a Volkswagen Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...