Question about GMC Sierra

1 Answer

My 92 GMC failed smog only in the HC area. CA emissions requires max118 at 15mph and mine was 123, max at 25mph is 98 and mine was 97. What could it be?

Posted by on

1 Answer

  • Level 1:

    An expert who has achieved level 1.

    Corporal:

    An expert that hasĀ over 10 points.

    Mayor:

    An expert whose answer gotĀ voted for 2 times.

  • Contributor
  • 4 Answers

Sounds dumb but here in maryland people with older vehicles have problems passing emissions test. sometimes fresh oil change can help also possibly vehicle is in need of a tune up including plugs wire cap rotor pcv valve and fuel filter. one other thing could be the catalyst converter might not be cleaning to its full potential. hope this helps

Posted on Jan 04, 2014

5 Suggested Answers

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.
goodluck!

Posted on Jan 02, 2017

  • 194 Answers

SOURCE: 1991 Honda Accord LX failed emission test on smog

not enough info. Typically, CO and HC together can be the result of poor fuel control or misfire, or worn components such as O2 sensor or catalytic converter, but without more data, repair recommendations are likely to waste money and not achieve success.

Posted on Sep 12, 2009

  • 834 Answers

SOURCE: failed smog check

How well does the vehicle run?

Assuming that the engine did pass the EGR function test on the emission test results, and the MIL (Malfunction Indicator Light) or check engine light is not on when the engine is running, and if you are not sure when the last time it was that the engine had a complete tune-up, with distributor cap, ignition rotor, spark plugs, spark plug wires, air and fuel filters, then a complete tune-up would certainly help, and if the engine oil and oil filter have not been changed in a while, then they should also be changed before an emission test because long used engine oil traps carbon and it will show up as higher CO on the emission test because the emission analyzer will be able detect the higher CO from the engine oil through the PCV valve.

However, it would seem from those HC readings that there is a vacuum leak, and carefully inspect all of the vacuum lines for any cracks or damage, (especially the vacuum line to the fuel pressure regulator) because cracks in the vacuum lines seem to like to hide underneath the lines.

The emission label under the hood should have the vacuum line routing diagram printed on it, and the vacuum lines should all be checked to be certain that they are all connected correctly.

Here is the firing order diagram for that vehicle to help assist you tune-up the vehicle.


e696e87.jpg

Posted on Jul 10, 2010

johnjnail
  • 1702 Answers

SOURCE: My 1990 chevy astro van

the smog test looks like the engine is miss firing, that could cause the timing to be out of whack also, try a old fashioned tune up, new spark plugs, wires, and filters also replace the PCV valve. any time you see the NO that high suspect a miss fire.

Posted on Feb 24, 2011

  • 158 Answers

SOURCE: My 1997 Honda Civic failed

Jose, I don't know if this will give you the answer you are looking for because there are many things to consider here. The exhaust gas recirculation valve (EGR) is one of the main things involved in reducing NO emissions. This valve is controled by the power control module. (PCM) This is your vehicles computer. The PCM monitors the vehicles speed and will command the EGR to open when the vehicle attains a certain speed, which is why the ASM test being done is recorded at two different speeds. At 25 MPH your vehicle failed the hydrocarbon (HC) emissions limit and this could be for a number of reasons. When is the last time you car was tuned up? Old spark plugs, wires, clogged air filters, oxygen sensors, leaking injectors (personal experience) or the PCV valve could be contributing to the results of the test. I guess that the easiest way to go is to tune up the engine replacing the spark plugs, wires, air filter and the PCV valve and don't forget to have the oil changed at the same time. Only then should have the vehicle retested and see what the results are. Should it fail again you may have to consider having the EGR or the catalytic converter replaced depending on what portion of the test fails. If the NO fails I would consider the EGR. If the HC fails then I would consider the catalytic converter. Good luck with this.

Posted on Apr 05, 2011

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

I rebuilt the TBI, Changed every sensor in the truck and replaced the heads. I still cannot pass the CA smog test


Check everything that is connected to a vacuum line, check the CAT and the injectors and last run a compression test.

Mar 13, 2014 | 1988 Chevrolet K2500

1 Answer

1985 Plymouth Voyager 2.6 L failed NOX emission test


1) please RUN the scanner and computer test from any repair shop you must get the exactly faulty in your emission system
2) However you can go to the www.automecanico.com+ www.autoelectronico.com this sites is in spanish, but you can translate with your web browser and I Higly recomend because has Powerful information update for any cars models, Try it and fix it.
God bless you

Jul 09, 2012 | 1985 Plymouth Voyager

2 Answers

My 1997 Honda Civic failed it's Emissions Test. See below the ASM Emission Test Results. What do you suggest I do to get the car to pass the smog test? ASM Emission Test Results: 15mph - RPM = 1587...


Jose, I don't know if this will give you the answer you are looking for because there are many things to consider here. The exhaust gas recirculation valve (EGR) is one of the main things involved in reducing NO emissions. This valve is controled by the power control module. (PCM) This is your vehicles computer. The PCM monitors the vehicles speed and will command the EGR to open when the vehicle attains a certain speed, which is why the ASM test being done is recorded at two different speeds. At 25 MPH your vehicle failed the hydrocarbon (HC) emissions limit and this could be for a number of reasons. When is the last time you car was tuned up? Old spark plugs, wires, clogged air filters, oxygen sensors, leaking injectors (personal experience) or the PCV valve could be contributing to the results of the test. I guess that the easiest way to go is to tune up the engine replacing the spark plugs, wires, air filter and the PCV valve and don't forget to have the oil changed at the same time. Only then should have the vehicle retested and see what the results are. Should it fail again you may have to consider having the EGR or the catalytic converter replaced depending on what portion of the test fails. If the NO fails I would consider the EGR. If the HC fails then I would consider the catalytic converter. Good luck with this.

Apr 05, 2011 | 1997 Honda Civic

1 Answer

My 1990 chevy astro van didn't pass smog. Paperwork says it failed the following; Ignition timing: 99 ATDC. Also, ASM Emission Test Results; 15mph HC (PPM) max is 122 measured 127, 25mph max is 102...


the smog test looks like the engine is miss firing, that could cause the timing to be out of whack also, try a old fashioned tune up, new spark plugs, wires, and filters also replace the PCV valve. any time you see the NO that high suspect a miss fire.

Feb 24, 2011 | Chevrolet Astro Cars & Trucks

2 Answers

Need 92 toyota paseo to pass CA smog test ! What causes too high HC in smog test????


High HC means moisture in the system. Try driving it longer then take it to the smog shop. Otherwise it could be hard like a head gasket or easy such as a PCV not functioning. Any ways you should always drive it about 20 miles before smog check, longer when the weather is cold.

Nov 30, 2010 | Toyota Paseo Cars & Trucks

1 Answer

Failed smog check


How well does the vehicle run?

Assuming that the engine did pass the EGR function test on the emission test results, and the MIL (Malfunction Indicator Light) or check engine light is not on when the engine is running, and if you are not sure when the last time it was that the engine had a complete tune-up, with distributor cap, ignition rotor, spark plugs, spark plug wires, air and fuel filters, then a complete tune-up would certainly help, and if the engine oil and oil filter have not been changed in a while, then they should also be changed before an emission test because long used engine oil traps carbon and it will show up as higher CO on the emission test because the emission analyzer will be able detect the higher CO from the engine oil through the PCV valve.

However, it would seem from those HC readings that there is a vacuum leak, and carefully inspect all of the vacuum lines for any cracks or damage, (especially the vacuum line to the fuel pressure regulator) because cracks in the vacuum lines seem to like to hide underneath the lines.

The emission label under the hood should have the vacuum line routing diagram printed on it, and the vacuum lines should all be checked to be certain that they are all connected correctly.

Here is the firing order diagram for that vehicle to help assist you tune-up the vehicle.


e696e87.jpg

Jul 09, 2010 | 1997 Honda Civic

1 Answer

MY CADILLAC DEVILLE 1997 DONT PASS SMOG IT FAILED THE HC (PPM) THE MAX WAS 47 THE AVE WAS 9 ND THE MEAS WAS 140 AT 15MPH AND AT 25MPH THE MAX WAS 31 AND THE AVE WAS 7 AND THE MEAS WAS 127.. CAN YOU TELL ME...


i'd start with a complete tune up. plugs, wires, pcv valve, gas and air filter. what engine code are you getting? normally vehicles 1996 and newer get a obd (computer) emissions test not an asm (tail pipe) test. and perhaps a new catylitic converter and oxygen sensors

Apr 17, 2010 | 1997 Cadillac DeVille

1 Answer

Failed smog


We had to have the calatic converter replaced. We did this after doing an oil change, air filter change, and new spark plugs and still hadn't passed smog. After changing the calatic converter it passed smog with scores of 25.

Mar 17, 2009 | 1992 Mazda Protege

1 Answer

1991 Honda Accord LX failed emission test on smog test. High CO and HC on 25mph


not enough info. Typically, CO and HC together can be the result of poor fuel control or misfire, or worn components such as O2 sensor or catalytic converter, but without more data, repair recommendations are likely to waste money and not achieve success.

Mar 07, 2009 | 1991 Honda Accord

1 Answer

Failed Smog Test Close to CA-HC Limits


You can try some over the counter solutions per say. Some of the mechanics in a bottle. They sell some products This will probably be the cheapest router. If this doesn't work then you need repairs.

Pass your emissions test.

Jan 03, 2009 | 1992 Honda Accord

Not finding what you are looking for?
Cars & Trucks Logo

Related Topics:

117 people viewed this question

Ask a Question

Usually answered in minutes!

Top GMC Experts

yadayada
yadayada

Level 3 Expert

75051 Answers

Freddy

Level 3 Expert

1311 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

22095 Answers

Are you a GMC Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...