Question about Suzuki Grand Vitara

1 Answer

Fuel temp gauge

Where is the glow plug relay heat sensor in a 2002 suzuki grand vitara

Posted by on

  • 4 more comments 
  • Seamus Byrne
    Seamus Byrne Nov 24, 2013

    Hi Thanks The jeep is a 2002 suzuki grand vitara with the 2.0 hdi rhz engine and i have checked all glow plugs and replaced the glow plug relay but the glow plug light only comes on foa a second and it is not heating glow plugs is there a sensor faulty

  • _-__-___-_
    _-__-___-_ Nov 24, 2013

    i dont have the Diesel fsm pages. no HDI here. id try to get the HDI suppliement for you maker.... try a real FSM at your Suzuki dealer, or find out what PSA controls it uses and then get the docs from PSA.....

  • _-__-___-_
    _-__-___-_ Nov 24, 2013

    i dont have the Diesel fsm pages. no HDI here. id try to get the HDI suppliement for you maker.... try a real FSM at your Suzuki dealer, or find out what PSA controls it uses and then get the docs from PSA.....

  • _-__-___-_
    _-__-___-_ Nov 24, 2013

    wow key bounce and 2 posts , wild. ok first see the wiki on the PSA product line (no FSM from suz) and figure out what youh have and get the docs for it,, id not own any diesel , with no FSM. not me not ever. i consider the books , part of the new car costs.

  • _-__-___-_
    _-__-___-_ Nov 24, 2013

    dw10: http://en.wikipedia.org/wiki/PSA_EW/DW_e...

  • _-__-___-_
    _-__-___-_ Nov 24, 2013

    glow plug use large currents. make sure the power feed and grounds are perfect and clean.

×

Ad

1 Answer

  • Level 3:

    An expert who has achieved level 3 by getting 1000 points

    Superstar:

    An expert that got 20 achievements.

    All-Star:

    An expert that got 10 achievements.

    MVP:

    An expert that got 5 achievements.

  • Suzuki Master
  • 20,706 Answers

Diesel? state county,
they use diff, engine in diffr. countries.
in the USA the answer is the FSM. book.
or alldata.com DIY or at mitchells.

here off the wiki, see this about diesel?
. Since 2001, all diesel 1st Gen Vitaras are to be imported from Argentina, built by General Motors in Argentina, featuring 2.0-litre HDI engines from PSA

is this it? the PSA? (wild guessing)

Posted on Nov 24, 2013

Ad

6 Suggested Answers

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
Best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
New users get to try the service completely Free afterwhich it costs $6 per call and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.
Goodluck!

Posted on Jan 02, 2017

Ad
blueextc3221
  • 15935 Answers

SOURCE: where is the thermostat on a 2002 suzuki grand vitara?

grab the top radiator hose, follow it back to the engine. Where the hose connects, is the thermostat housing. The thermostat is inside. Remove 2 bolts, and you'll see it.

Thanks for using FixYa - A FixYa rating is appreciated!!

Posted on Jan 23, 2009

  • 1 Answer

SOURCE: Switch on 2001 Suzuki Grand Vitara

This is a electric heat boost for demisting in winter months, turn fan on to full, heater lever to full and air controll to full. Be warned uses lots of battery power

Posted on Mar 09, 2009

action t
  • 8 Answers

SOURCE: Grand vitara radiator over heating

make sure thermostat is in the right direction. put a new gasket. try a cleaner and fill radiator or have it rodded out along with maybe your heater core. drain and refill. put fresh oil in it now.

Posted on May 23, 2009

dmftrucker
  • 1922 Answers

SOURCE: The Glow plug warning light on - Grand Vitara

your power relay supplying the glow plugs may be stuck(welded contacts)on and need replace

Posted on Nov 06, 2009

Testimonial: "Many thanks for the suggestion. Unfortunately relay seems fine. I think it may be an engine management problem."

  • 510 Answers

SOURCE: central locking fob

Programming
When
Remote control buttons operated repeatedly while vehicle out of range and system becomes inoperative. System malfunction.
How
Ensure ignition switched OFF and all doors closed. Proceed as follows: Within 10 seconds, open driver's door and switch ignition ON. Within 10 seconds of switching ignition ON, switch ignition OFF. Within 20 seconds of switching ignition OFF, press and release driver's door contact switch 3 times. Within 10 seconds of releasing driver's door contact switch, switch ignition ON then OFF. Within 20 seconds of switching ignition OFF, press and hold both remote control buttons in turn for at least 5 seconds. The driver's door should lock and unlock once. Within 5 seconds of driver's door locking/unlocking, press remote control lock button Fig. 1 [1] or unlock button [2]. Programming procedure complete. Confirm programming has been successful by locking and unlocking vehicle.
NOTE: A maximum of 2 remote controls can be programmed.

Posted on Feb 06, 2010

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

2 Answers

Where is the location for the fuel pump sending unit for gas gauge relay or fuse for a 2007 Suzuki Grand Vitara


same as all of those from 1989 to now.
gas engines.
in the usa, on this usa forum ,btw, they sell this car world wide
with a range of engine types.
our gas engine has 2 sensors for fuel level
main and sub level, sensors yes complex.
did you scan the PCM first.? 21,22 is it. below
if yo scan it , it tells you which one is bad... for sure.

26396878-eilttwukrrxnzqvvfaeawxzf-2-0.jpg

Dec 13, 2016 | 2007 Suzuki Grand Vitara

1 Answer

I have a 2001 Suzuki Grand Vitara 2.5liter and it was running fine i jus replaced valve cover gaskets and spark plugs now vehicle won't start and has no compression how did i loose compression?


so, you removed all 6 cop coils and 6 spark plugs.
then blocked the throttle open, and pulled the fuel pump relay
then checked compression and all 6 are zero not 150psi +
really? the throttle must be blocked open or the engine will not get air supply to make compression.
i bet you did no read the gauge instructions nor FSM steps, same, so false reading. here.
or didnt use a long hose screw in gauge, and tried to use rubber tipped chevy engine gauge , useless here)
did you remove that CMP sensor on the rear of the left head?
if you messed it up , it will never run. right. IT IS TIMED !
mess with this?


25609827-xehzdwn5iwh3l3ng4yvsd5t5-1-0.jpg
questions, does it run for 3 seconds on test fuel? sprayed?
is the Check engine light glowing key on? if not you blew fuses.!!!
pull battery neg lug before starting work?
connect scan tool and crank 5 seconds, get P03xx errors. DTC, bingo
check static timing>? yes, it has that. and a freeze jumper to check timing if the CMP was violated, in any way.
if you need help, ask, I have the full FSM on this car. 2 volumes.

if test fuel fails. you lost spark or fiddled the CMP or its UNPLUGGED.
I bet compression is perfect. I DO ! (9 out of 10 do it wrong is why, DIY shade tree )

Mar 27, 2015 | 2001 Suzuki Grand Vitara

1 Answer

Diesel fault finding


weak battery , slow turns.
bad glow plugs.(or controls to them)
bad fuel or water in fuel. (or controls to them)
low compression

Jan 21, 2014 | 1999 Suzuki Grand Vitara

1 Answer

Glow plug relay diesel


they use diffr, diesels world wide
which one you got?
and try some commas please.
glow plugs too short, plugs are what?
my wild guess, the diesel is hard to start>? and what is the outdoor temperature, and is the fuel fresh? not 3 years old? or water contaminated?

start any engine post with
country (car was sold,which might not be now)
engine displacement. ?????????
and symptoms.
then ask a question.

Dec 14, 2013 | 2009 Suzuki Grand Vitara

1 Answer

Is there a sensor that sends a signal to the glow plug relay to say that the engine is cold and trigger the relay to heat the glow plugs in a 2002 suzuki grand vitara with the 2.0 hdi rhz code engine


It will work through the temperature sending unit for the engine. You may have one or two. Some companies dedicate one temp sensor for the glow plugs and some don't.

Nov 24, 2013 | Suzuki Grand Vitara Cars & Trucks

1 Answer

My suzuki grand has a hard starting in the morning or when the car sits for sometime


CHECK COOLANT TEMP SENSOR I.E.IF THE SENSOR IS READING 200 DEG. IN THE MORNING AND ITS ONLY 70 DEG
OUT SIDE IT WHOLD BE STARTING TO LEAN

Jul 13, 2012 | 1999 Suzuki Grand Vitara

1 Answer

When at a stop light the car idles fine when i go to take off it sputters and back fires. I changed the spark plugs, but it is still doing it. It idles fine otherwise.


Does not sound like ignition, but fuel.
Idle needs little fuel.
Could be a clogged filter, water in the gas, bad pump, vacuum building up in the tank, bad sensors, etc.
Start with a gauge on the fuel pressure.
If it is low, that will point to filter or pump. Filter is cheaper to try.
If not low, then check the sensors with ohmmeter from Harbor Freight for $3.
There are O2, water temp, MAS, air temp, etc.

Jan 21, 2011 | 2001 Suzuki Grand Vitara

1 Answer

The Glow plug warning light on - Grand Vitara


your power relay supplying the glow plugs may be stuck(welded contacts)on and need replace

Nov 06, 2009 | 2000 Suzuki Grand Vitara

Not finding what you are looking for?
Cars & Trucks Logo

Related Topics:

208 people viewed this question

Ask a Question

Usually answered in minutes!

Top Suzuki Experts

yadayada
yadayada

Level 3 Expert

76630 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

22219 Answers

Boyet Soriano
Boyet Soriano

Level 2 Expert

293 Answers

Are you a Suzuki Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...