Question about Cars & Trucks

2 Answers

Engine Diagrams I need an engine diagram of a 1997 Suzuki Cultus Crescent 1.5lt showing where the thermostat housing is located

Posted by on

Ad

2 Answers

  • Level 2:

    An expert who has achieved level 2 by getting 100 points

    MVP:

    An expert that got 5 achievements.

    Cheetah:

    An expert who has answered 20 or more questions within one hour.

    Night Owl:

    An expert who has answered 10 or more questions between 12 midnight and 6am on the same day.

  • Expert
  • 74 Answers

Hello. Here a non-photo diagram. Hope this helps!!!

The thermostat is located on the side of the water pump, the water pump is located just above the a/c compressor, the thermostat is fed coolant from the radiators lower radiator hose.
Thermostat :
1. drain coolant and tighten drain plug ( easier method : remove radiator cap, get big drain pan, place drain pan under lower radiator hose to radiator connection, remove clamp, slowly remove hose, allow coolant to drain into pan, now is a good time to remove radiator hose and clamp from thermostat housing )
2. remove thermostat cover / cap ( easiest to get at this when front of car is supported by jack stands and right hand side lower cover is removed ).
3. thermostat cap is held on by 3 bolts / remove thermostat.

You will notice that the thermostat's air bleed hole is pointing up and lines up with notch in water pump housing,,

ATTENTION :failure to install new thermostat in the correct location will cause engine to overheat.

1. install new thermostat to water pump, make sure air bleed hole lines up with notch, install and tighten bolts, install a new lower radiator hose, fill cooling system.

thermostat # 17670-77E00
lower radiator hose #17854-65G20
hose clamp #09401-36403
upper radiator hose # 17852-65G20

Suzuki factory manual

Posted on Oct 21, 2013

Ad
  • Level 2:

    An expert who has achieved level 2 by getting 100 points

    MVP:

    An expert that got 5 achievements.

    Night Owl:

    An expert who has answered 10 or more questions between 12 midnight and 6am on the same day.

    Hot-Shot:

    An expert who has answered 20 questions.

  • Expert
  • 68 Answers

Just follow the upper radiator hose toward the engine should be on the cylinder hear or the lower intake manifold

Posted on Oct 21, 2013

Ad

6 Suggested Answers

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
Best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
New users get 2 Free calls (no credit card required) and instant help on almost anything you can think of (from cars to computers, appliances, handyman, and even pets).
click here to download the app (for users in the US for now) and get all the help you need.
Goodluck!

Posted on Jan 02, 2017

bbtoast
  • 319 Answers

SOURCE: engine 3.1

Hi

Please try this link that should get you started in locating the parts you have listed.

From that page, you will find links to other info about your vehicle!

Good luck!

Brian

Posted on Sep 06, 2008

LT1Rob
  • 55 Answers

SOURCE: want to see a diagram of the engine to show

Follow the upper radiator hose and it will lead you to the thermostat. b0fbcf8.jpg142a369.jpg

Posted on Mar 10, 2009

Davaith
  • 56 Answers

SOURCE: warning light on & frequent loss of excelleration power

Check your Mass Air flow sensor. It might be dirty or the connections might be lose.
It looks something like this http://thumbs300.1aauto.com/EAF/1AEAF00001.jpg
now if your vehicle has something similar but with a flapper/door. then check if it is dirty or not opening.
If your vehicle doesnt have any of these then It could be a Manifold Absolute Pressure sensor. Go to autozone and check on what it is then we can have a better idea of what is going on. Thanks

Posted on Apr 25, 2009

  • 86 Answers

SOURCE: I have a 1997 Lexus ES 300. I need to replace the

yup just follow the hose. remove hose from water neck and remove 2 bolts. let me know how it worked for you.richie

Posted on Jun 29, 2009

BCAS1298
  • 3092 Answers

SOURCE: Where is the thermostat located

Could not fine cooling system diagram, but if you follow the upper radiator hose from radiator to engine, where it connects to engine, on that housing, thermostat will be under it, remove small bolt's the thermostat will be under it.

Posted on Aug 23, 2010

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

2 Answers

Where can we find diagnostic socket?


OBD2 connector location in Suzuki Grand Vitara (1997 - 2005)

www.outilsobdfacile.com/...plug-connector-obd/Suzuki-grand-vitara-2
Easily find where your OBD2 port / connector is located in Suzuki Grand Vitara (1997 - 2005) ... OBD connector location for Suzuki Grand Vitara (1997 - 2005).

Suzuki Engines Diagnostic Connectors

codes.rennacs.com/Petrol-Engine/Japanese-Korean/Suzuki-Engines.php
Suzuki Engines - diagnostic connector locations, with detailed diagrams, text, and pictures of where to find the diagnostic connector in the vehicle.

Oct 14, 2015 | 1999 Suzuki Vitara

1 Answer

Timing marks 2001 5.5 Susuki engine


clean clear , anon, double post, and still no car named,
nor real engine.

one of these?, sorry cant guess that or the engines.... ever.-
Here are some of Suzuki's most famous car models:
  • Suzuki XL7
  • Suzuki Kizashi
  • Suzuki Escudo
  • Suzuki SX4
  • Suzuki Wagon R
  • Suzuki Alto
  • Suzuki Cervo
  • Suzuki Cappuccino
  • Suzuki Fronte
  • Suzuki Grand Vitara
  • Suzuki Ignis
Here are some of Suzuki's list of current models:
  • Suzuki Ertiga
  • Suzuki Every
  • Suzuki Kizashi
  • Suzuki SX4
  • Suzuki Swift
  • Suzuki Splash
  • Suzuki Solio
  • Suzuki Wagon R
  • Suzuki Palette
  • Suzuki MR Wagon
  • Suzuki Lapin
  • Suzuki Alto
  • Suzuki Landy
  • Suzuki APV
  • Suzuki Jimny
  • Suzuki Escudo
  • Suzuki Carry
  • Suzuki Equator
Here are some of Suzuki's list of former models:
  • Suzuki XL7
  • Suzuki X-90
  • Suzuki Twin
  • Suzuki Mighty Boy
  • Suzuki Kei
  • Suzuki Ignis
  • Suzuki Fronte
  • Suzuki Esteem/Cultus Crescent
  • Suzuki Cultus
  • Suzuki Cervo
  • Suzuki Cappuccino
  • Suzuki Aerio/Liana

Sep 09, 2014 | Suzuki Cars & Trucks

1 Answer

How do you change a thermostat on a 1997 Caddilac deville w/ Northstar engine? Also, Where is it??? Please help!


Check this diagram location...

zjlimited_664.gif

Fig. Thermostat installation - 4.6L Engine

4.6L Engine

  1. Drain the coolant to a level below the thermostat housing.
  2. On some vehicles, access is easier if the front-end beauty panel and the air cleaner are removed.
  3. Remove the 2 bolts securing the thermostat housing to the intake manifold.
  4. Remove the thermostat housing.
  5. Remove the thermostat and O-ring from the housing.
To install:
  1. Install the thermostat and new O-ring to the housing.
  2. Install the thermostat housing to the intake manifold. Tighten the thermostat housing bolts to 18 ft. lbs. (25 Nm).
  3. Refill the cooling system using a 50/50 mixture of water and ethylene glycol antifreeze.
  4. Install the air cleaner and beauty panel, if removed.
  5. Start the engine and check for coolant leaks. Allow the engine to come to normal operating temperature. Recheck for coolant leaks.
Hope this helps.

Sep 02, 2011 | 1997 Cadillac DeVille

1 Answer

Need diagram that shows location of thermostat ?


there are no diagrams for the location of the thermostat, just follow the top radiator hose to the motor and there will be a metal housing that the hose is clamped to thats the thermostat housing.

Dec 26, 2010 | GMC Sierra 1500 Cars & Trucks

1 Answer

Where is the thermostat?


Check this location diagrams...

zjlimited_70.jpg

Fig. Exploded view of the thermostat (3) showing the thermostat housing (1,2) location on the engine block (4)-3.7L & 4.7L engines


zjlimited_71.jpg

Fig. Exploded view of the thermostat housing (2) and mounting bolts (1), lower radiator hose (4) and hose clamp (3)-5.7L engine

I hope this helps (remember to comment and rate this answer).

Nov 16, 2010 | 2006 Jeep Commander

1 Answer

Diagram of Fuse Box of 1997 Suzuki Margalla


suzuki margalla 1300 cc is based on suspension of 1000 cc cultus that does not support margalla typically rear suspension how can i fix this problem

Oct 10, 2010 | 1997 Suzuki Swift

2 Answers

I can't find the thermostat on my 2001 Dodge Caravan. Can someone help?


Hello jhenry246, my name is JShreader. Thank you for choosing fixya.com

The Thermostat is located behind the Thermostat Housing on almost all Vehicles. There are 3 different Engine types they used in this Caravan this particular year. I have uploaded you pictures showing the locations of the Thermostat and Housings for each Engine in .pdf format. You can download them by clicking HERE. The engine cooling thermostats are a wax pellet driven, reverse poppet choke type. If you follow the Upper Radiator Hose up to the side of the Engine, it connects to the Thermostat Housing.
bf20eb5.jpg
79612ae.jpg
You must drain the Cooling System before you remove it. I went ahead and made you up the replacement procedures for replacing this Thermostat. You can download it by clicking HERE.

I hope this helps you. If you have any more questions or need any more diagrams, please don't hesitate to ask...Thanks again, JShreader!

Mar 31, 2009 | 2001 Dodge Grand Caravan

1 Answer

Need the engine location of the thermostat


Hello teeschar6, my name is JShreader. Thank you for choosing fixya.com.

If you follow the Lower Radiator Hose up to the side of the Engine, it connects to the Thermostat Housing. You have to remove this Housing to get the Thermostat out. Drain the Coolant. Remove the Hose. Remove the Bolts securing the Housing to the Engine. Remove the Thermostat. Be sure you take note to which direction the Pin on the Thermostat is facing. You want to put the new one in the exact same way. I uploaded a .pdf showing you a picture of it, and how to remove it. You can download it by clicking HERE. I hope this helps you. If you have any more questions or need any more diagrams, please don't hesitate to ask...Thanks again, JShreader!

Mar 31, 2009 | 1991 Honda Accord

Not finding what you are looking for?
Cars & Trucks Logo

Related Topics:

442 people viewed this question

Ask a Question

Usually answered in minutes!

Top Cars & Trucks Experts

yadayada
yadayada

Level 3 Expert

76630 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

22219 Answers

Randy Ohler

Level 3 Expert

14585 Answers

Are you a Car and Truck Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...