Question about Volkswagen Sharan

Open Question

Sharan turbo egr valve location - Sharan Volkswagen Cars & Trucks

Posted by Anonymous on

Ad

6 Suggested Answers

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.
goodluck!

Posted on Jan 02, 2017

Ad
  • 345 Answers

SOURCE: 06 vw sharan 1.9tdi exhaust warning light on

check the air flow meter as well the two are linked,if you fit a new egr it will need to be programmed to your car,..when the egr is working you should get a drop in airflow,if you dont then the egr is stuck open...when it closes your airflow should go back up..

Posted on Dec 06, 2008

Ad
  • 3 Answers

SOURCE: 06 vw sharan 1.9tdi exhaust warning light on

can you tell me the resistances in ohms of the EGR valve

Posted on Feb 01, 2009

  • 398 Answers

SOURCE: egr valve location

The EGR Valve Location is typically housed on the intake manifold this schematic may help you
http://www.autozone.com/shopping/repairGuide.htm?pageId=0900c1528008822d

Posted on Mar 07, 2009

c17hydro
  • 2984 Answers

SOURCE: Location of EGR Valve

Found the info!!

This Dodge EGR valve is a certain kind of device that is mounted right on your intake manifold which controls the amount of exhaust gasses back into your engine.
On a 2005 Dakota with 4.7 liter engine (non-HO), the EGR valve is located near the intake manifold on the driver's side right up against the firewall. It's hard to spot as it sits lower than the intake manifold. To change it, remove the electrical connector. There's a red tab that needs to be pushed to one side and then you have to squeeze down on a tab to get it free. Using a 13 mm socket, remove the bolt that you can see. I had to use a 3 inch wobble extention and then a 8 inch extension with a deep well socket to reach it with my 3/8 inch ratchet. There's a second bolt that you can't see between the EGR valve and the firewall. With a little trial and error and a lot more luck, you can reach the hidden bolt with the 3 inch wobble extension and a 13 mm deep well socket. Attach the ratchet after the socket is on and remove. This one isn't easy and if there's any Dodge engineers reading this one, a couple of extra inches of clearance between the valve and the firewall wouldn't have killed you no matter what the cost accountants said. With both bolts removed, you should be able to pull out the metal pipe that connects the manifold to the EGR valve out of the manifold (Pull to the right) and then you can lift the valve out. For assembly, the metal pipe connecting the intake manifold the EGR valve has to be removed and reinstalled on the new valve. It's held on with 2 5/16th" bolts. You should put the rear bolt on tight, but leave the front bold loose for the reinstall as some adjustment is necessary to get it put back together and the rear is a pain to tighten when installed. Line up the bolts that attach the valve and get the rear 13 mm bolt (The one you couldn't see on disassembly) started. Do not start the other 13 mm bolt as you'll need to pivot the valve and pipe to the left in order to reinsert the pipe into the intake manifold. Once the pipe is in the intake manifold. Start the other 13 mm bolt and tighten both 13 mm bolts and then the 5/16" bolts holding the pipe onto the valve. Reinstall the electrical connection. Please don't forget to rate!!!!

Posted on Mar 14, 2009

ZJLimited
  • 17970 Answers

SOURCE: egr valve location on dodge ram 2005 4.7

The EGR, or exhaust gas recirculation valve, takes inert exhaust gasses drawn from the exhaust system and reintroduces them into the combustion chamber through the intake manifold. This process lowers the peak combustion temperature and helps combat the formation of Nitrous Oxide (NOx) in the exhaust.

f0255cf.jpg

  1. Separate the intake ducts from the air cleaner assembly by loosening the retaining clamps and pulling the ducts away from the housing.
  2. Disconnect the vacuum line from the air cleaner assembly.
  3. Remove the wing nut that secures the air cleaner housing lid to the base.
  4. Remove both the air cleaner hosing lid and base.
  5. Locate the EGR valve. Look at the front of intake manifold. The EGR valve will be bolted to the intake manifold just in front of the carburetor.
I hope help you with this. Good luck.

Posted on Sep 07, 2009

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

Where is the EGR valve on a renault meganic senic X reg


EGR is exhaust gas recirculation valve. Its works kind of turbo chargers sometimes egr takes some of still fuel rich exhaust gases and injects in intake back order to save some gas and cleaner exhaust gases for environment You should locate your exhaust manifold and fallow smaller size piping coming out of it one of that pipe goes Egr

Apr 26, 2014 | Cars & Trucks

1 Answer

How to remove vw sharan egr valve


06 sharan sprayed and cleaned egr whilst still on engine not much carburn checked pipes clear but thecar permites black smoke turbo kicks in when required but engine sounds as if the timing is out can you help does it need a new egr or turbo

May 19, 2012 | Volkswagen Sharan Cars & Trucks

1 Answer

Where do I find the turbo charger in the engine and locate the VW serial number so I can buy a direct replacement?


First time remove the engine cover

tdisline_573.jpg

Then you will see the engine

tdisline_574.jpg
A - Airflow ducting
B - Integrated EGR/ASV valve
C - Crankcase vent tube (CCV)
D - Timing Belt cover
E - VNT actuator - part of turbocharger
F - Engine Oil Fill cap
G -Turbocharger control unit
H - Alternator
I - N75 / turbocharger boost pressure control valve
J - Mass Air Meter
K - Fuel Filter
L - Power steering fluid reservoir
M - Screen Washer Fluid
N - Coolant Expansion Tank
O - ABS stuff
P - Ducting to Intercooler
Q - part of CCV piping connector
R - N75 / Turbo Pressure Control solenoid
S - vacuum reservoir ball
T - FLex couplling for Exhaust system
U - Hot side of Turbo: flex pipe
V - Air throttle actuator
W - Pipe for EGR


tdisline_576.jpg
Yellow arrow shows the turbocharger

The VW serial number is located on the front of the turbocharger

tdisline_577.jpg
tdisline_578.jpg

May 24, 2011 | 2001 Volkswagen Passat

2 Answers

Hi there well done for a great job right my vw sharan 2001 tdi curently is not heating and the water from the engine is not hot when you touch on the pipes they are just warm however the heater gage...


First time you might check the thermostat operating.


Heed of antifreeze coolant temperature!!!


The thermostat location for 2001 VW Sharan 1.9 TDI is on back of the alternator at the bottom side of the bracket.

IMPORTANT NOTE: It is NOT necessary to replace the alternator if you want to change the thermostat !!!

Thermostat checking:
1. Cold engine. Start up the engine and watch of the water temp indicator. After first value 60 Celsius Degree you still warm up the engine until the lifter (pointer) reach 80 C deg. (second mark after 60 C deg.). At this time you let engine running at idle speed and check with your hand the thermostat plastic housing and hose temperature in bottom left side of the engine. Heed of alternator driving belt and ventilator fan !!!
2. If the thermostat is good the hose must be cold until the water temp indicator reach almost 90 C deg.
3. The thermostat opening temperature is 87 C deg.
4. If the hose is already warm the thermostat is out of order.

Thermostat location, Part number: 044121113, in german - "Kuehlregle" (Price around $25):
tdisline_211.jpg


Important note: Always replace the thermostat seal, position 7 in the above picture.


Please do rate my response. Thanks!


Feb 02, 2011 | Volkswagen Touareg Cars & Trucks

1 Answer

On TDI turbo charger intermittent


The N75 valve located on the bulkhead is a common problem on these cars. The N75 valve controls the turbo variable guide vanes. It is located on the bulkhead next to the egr valve controller. These 2 components are the same part, so try interchanging them to see if the problem disapears. Good luck

May 12, 2010 | 2003 Volkswagen Passat

1 Answer

Engine has no power under 3000 rpm


have a look at the EGR valve if its stuck open you loos all the turbo boost till the EGR valve closes
it could also be the turbo gate valve (wast gate) sticking open so the turbo cant cut in till its screeming then the gate shuts and the old girl picks up her skirts and go's,,, you may get away with just blanking off the EGR valves to try them out but the turbo is a different mater,,,

Dec 06, 2009 | 1992 Toyota Pickup

2 Answers

Peugeot Expert EGR Valve


EGR is located at the back right hand side of the engine follow the silver pipe from inlet manifold , back and where it joins at the back of the lump , thats the egr!!

2x 8 mm bolts hold it in place + 5 mm allen screw if present secures a braket for wiring

Jun 15, 2009 | 2006 Peugeot 604

1 Answer

06 vw sharan 1.9tdi exhaust warning light on


check the air flow meter as well the two are linked,if you fit a new egr it will need to be programmed to your car,..when the egr is working you should get a drop in airflow,if you dont then the egr is stuck open...when it closes your airflow should go back up..

Dec 04, 2008 | 2006 Volkswagen Touareg

1 Answer

06 vw sharan 1.9tdi exhaust warning light on


can you tell me the resistances in ohms of the EGR valve

Dec 04, 2008 | 2005 Volkswagen Microbus

3 Answers

Sharan


Check all the small pipes that supply boost pressure to the waste gate valve. I had a similar problem with a 2.5 TDI Transporter in Australia. I had a pipe worn right through.

Cheers, Dennis

Nov 17, 2008 | 2001 Volkswagen Eurovan

Not finding what you are looking for?
Cars & Trucks Logo

Related Topics:

28 people viewed this question

Ask a Question

Usually answered in minutes!

Top Volkswagen Experts

Colin Stickland
Colin Stickland

Level 3 Expert

22156 Answers

yadayada
yadayada

Level 3 Expert

76164 Answers

Jeff Turcotte
Jeff Turcotte

Level 3 Expert

8273 Answers

Are you a Volkswagen Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...