Question about 1994 Dodge Grand Caravan

2 Answers

94 dodge grand caravan no fuel in fuel rail

Replaced fuel pump, no fuel in filter or fuel rail relays good, old pump good
fires up with starting fluid, then dies immediately

Posted by on

  • 6 more comments 
  • ron abramowitz Apr 24, 2009

    I have not been able to find the connector for a scan tool on that van. I almost am forced to believe that there is no such connector.
    where would I find it.

  • Anonymous Mar 12, 2014

    we replace the fuel pump and it started off good, now it won't start again

  • Anonymous Mar 14, 2014

    1994 940 turbo starts and then dies i replace fuel pump relay and still starts but then dies.

  • Anonymous Mar 14, 2014

    1994 940 turbo starts and then dies i replace fuel pump relay and still starts but then dies.

  • Anonymous Mar 14, 2014

    Some times it starts smetimes it won't and you have to wait till next day to start it.It's only done this 2xs. Was told it was fuel pump. Is that right?

  • Anonymous Mar 19, 2014

    I have changed the relay and fuse

  • Anonymous Mar 27, 2014

    I need to find the location of the fuel filter on my Dodge D150. I have a rail mounted tank.

  • Anonymous Mar 28, 2014

    replaced fuel pump and filter

×

2 Answers

  • Level 3:

    An expert who has achieved level 3 by getting 1000 points

    All-Star:

    An expert that got 10 achievements.

    MVP:

    An expert that got 5 achievements.

    Vice President:

    An expert whose answer got voted for 100 times.

  • Master
  • 335 Answers

Dear Ron, you have replaced fuel pump and fuel filter. You have checked the fuel pump relay. Still no fuel in rail. Try bypassing fuel relay with jumper from batt to fuel pump. If o/k then check computer for ground to relay. This system uses a relay that is operated by the computer that supplies a ground for the relay to operate. The wire color is green,16 gage. If the ground is not available then "no fuel" Check this with a test light. Key on and crank apply test light to ground wire and other end of light to ground. You should hear relay click and get fuel. If this checks out you will need to replace computer or get creative with rewiring the relay so it works without computer input. Good luck Moe

Posted on Apr 24, 2009

  • Level 2:

    An expert who has achieved level 2 by getting 100 points

    MVP:

    An expert that got 5 achievements.

    Governor:

    An expert whose answer got voted for 20 times.

    Hot-Shot:

    An expert who has answered 20 questions.

  • Expert
  • 114 Answers

1. is there gas in the tank?
2.is the pump getting power? SEE #4
3.why did you replace the pump? 4.some dodges need a scan tool to run the fuel pump to get the fuel system primed after replacing the pump. If the computer senses the engine isnt running after a few seconds it shuts the fuel system down. Happened on my friends jeep that was a chrysler system. Took a while to figure it out. The snap on red brick scan tool worked for this. Any scan tool(not just a code reader) that can get to functional tests of the engine computer will work.
Sounds like no fuel is getting past the pump,so get a scan tool capable of doing this,take hose off of fuel filter stick the end of the hose in something to catch the fuel that will come out and activate the pump. If fuel comes out the pump is working and the filter is clogged, if pump sounds like it is runnin and no fuel comming out pump is bad.If all is quiet pump isnt getting power.

Posted on Apr 24, 2009

1 Suggested Answer

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.
goodluck!

Posted on Jan 02, 2017

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

Two new fuel pumps in my 1996 grandcaravan. Still no fuel presure at rail. New fuel filter also. The regulator is built into the pump and the van runs on either.


Are you getting at least 12 volts to the harness on the pump and also is it grounded good? Have you checked the fuse for the fuel pump and the fuel pump relay? Is the ASD relay coming on when you turn the switch to run position? Several more things to check to solve your no start condition.

Nov 07, 2014 | 1996 Dodge Grand Caravan

1 Answer

2001 dodge grand caravan no fuel at fuel rail


Is there a pump in the tank ?. I am not familiar with this car, but I had a similar problem with my Citroen Diesel, /Peugeot simila. and the low pressure pump in the Fuel tank had failed. In the car stated the tank is under the rear seat, and entry can be gained to the tank/pump from here

Jan 05, 2014 | Dodge Grand Caravan Cars & Trucks

1 Answer

Where is the fuel rail located on 3.3 dodge caravan


the fuel rail is located under the intake plenum

Apr 12, 2013 | 1994 Dodge Grand Caravan

3 Answers

200 dodge grand caravan 3.3 v6 check engine light is on and have replaced fuel filter still needs a massive amount of cranking to start and pumping the pedal only to barley start and run realy rough w/back...


When the check engine light comes one, that means there is a code waiting to be read. If you let a place like Autozone read it, that may help.
Pumping the pedal only works on carbs, and does absolutely no good on fuel injection.
To check the fuel system, the very first thing you always have to do is put a fuel gauge on the fuel rail.
You could have a vacuum leak, like a broken hose, bad PVC, loose gas tank cap, etc.
But backfiring is usually bad plug wires.
Pull the plugs and look for ones that are different and wet or sooty.

Sep 03, 2010 | 2000 Dodge Grand Caravan

1 Answer

Has spark but doesnt fire up


Possible cause would be no fuel to injectors. turn the key to the on position and listen for the fuel pump to come on and pressurize the fuel rail. If you do not hear the pump come on then look in the fuse/relay box for a blown fuse/relay. If you hear the fuel pump come on then turn the key off after the pump has completed running and disconnect the negative cable from the battery. Go to the fuel rail and there will be a round test port,remove the black plastic cap(like a valve stem cap on a tire) using a shop towel partly cover the port. Using a very small screw driver press down on the valve stem, if the fuel comes out at a high volume then the pump and filter is ok. If not then replace fuel filter, that is if you heard the pump come on in the first place. If you never heard the pump come on and the fuse/relay was ok then the pump will have to be replaced. hope this will help you.

May 14, 2010 | 1998 Dodge Grand Caravan

1 Answer

1992 Dodge Grand Caravan engine failure


There is not fuse for pump but a relay in the relay block. I do suggest jumping to see if pump turns on. Test voltage from ECM if needed. If voltage is to pump, then pump is shot. If not voltage, relay may be bad

Sep 11, 2009 | 1992 Dodge Grand Caravan

1 Answer

Dodge caravan turns over wont start all lights work


possible bad fuel pump. check fuel pump relay under hood. drivers side fuse panel. swap fuel pump relay with another identical relay to rule out possible bad relay. listen for whining sound back by fuel tank. the fuel pump is in the fuel tank. Another option....you can also check the pressure in the fuel rail, but be careful not to squirt gas in your eyes or face.

Aug 26, 2009 | 2000 Dodge Grand Caravan

2 Answers

2000 Dodge Grand Caravan is getting no fuel to the fuel rail. The fuse is good and the relay also appears to be good. I don't hear the pump come on when turning on the ignition. Since the pump is in a full...


You are right on track, The fact that you did not hear the fuel pump come on is a very good indication the fuel pump needs to be changed.

Good JOB !

Good Luck

Aug 16, 2009 | 2000 Dodge Grand Caravan

Not finding what you are looking for?
1994 Dodge Grand Caravan Logo

429 people viewed this question

Ask a Question

Usually answered in minutes!

Top Dodge Experts

yadayada
yadayada

Level 3 Expert

75066 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

22095 Answers

Jeff Turcotte
Jeff Turcotte

Level 3 Expert

7754 Answers

Are you a Dodge Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...