The rear spoiler malfunction of 997

Question moved from spanish car maker 'Seat' (See-At).
Question edited for clarity. Guessing it is a Volvo, so moved it there. 'Year Make Model' in all question please.

Try, it just be aware of pinch points and get ready to move fast. Also have someone at the ignition key ready to cut power in case anything jams.

Videos that may help

https://www.google.com/search?q=2012+volvo+c70+convertible+top+reset

..

That would require a detailed procedure so its carried out properly
u can get a manual for help..
I keep getting those for vehicles too.. I know a lot of websites and which one is best for what type of vehicle.
and some are just useless, no customer relationship management..

From the GM 2005 Chevrolet Equinox Service Manual:

Remove Spoiler:
1. Open the liftgate
2. Remove the liftgate upper interior trim panel to expose the center bolt
3. Remove the spoiler to liftgate bolts (3)
4. Disconnect the stop lamp harness
5. Disconnect the rear washer hose
6. Lift the spoiler to disengage the locating retainers and remove the spoiler from the liftgate

Remove the high mounted stop lamp assembly:
1. Remove the spoiler to high mounted stop lamp screws
2. Disconnect the electrical connector
3. Disconnect the washer hose
4. Remove the stop lamp from the spoiler

Install the high mounted stop lamp assembly:
1. Position the stop lamp assembly to the spoiler
2. Connect the washer hose
3. Connect the electrical connector
4. Install the spoiler to high mounted stop lamp screws, tighten to 2 N-m (18 lb in)

Install Spoiler:
1. Position spoiler loosely over the liftgate
2. Connect the rear washer hose
3. Connect the stop lamp harness
4.Push down the spoiler to the liftgate to secure the locking tab retainers
5. Install the spoiler to liftgate bolts; tighten to 2 N-m (18 lb in)
6. Install the liftgate upper interior trim panel
7. Close liftgate

Start by checking remote switch. Test to see if there is power at the spoiler motor. If there is power getting to the motor check for bad ground. Finally remove the cable that drives the spoiler up and down and apply 12v dc to the motor. If the motor turns check to see if you can turn the cable without the motor and that the spoiler moves. I all power checks out and the spoiler won't move by turning the cable, the gearing that the cable attaches to is most likely damaged.

It probably needs lubrication. This is a known issue on the 997 Carrera. Mine made terrible noises while moving until I lubed it with some GP lithium grease I had laying around.

What you need to do is raise the spoiler via the switch to the full extent and place pieces of wood between the spoiler and body, then using a 'C' spanner to fit round the top of the rams and locate into the small hole (i found the multi purpose spanner that comes with pushbikes has just the right fitting) turn each ram 1/4 turn, but be careful because when it releases from the spoiler the ram will retract into its housing with great force taking the spanner with it and damaging the body. good luck!

my spolier for my 996 4s wont go down, does anyone know where the manual buton?

The rear spoiler is controlled by a Rear Spoiler Control Module. Fuse 35 (30A) and Fuse 5 (7.5A) located in the fuse panel behind left side of dash provide power to the control module. After ensuring that the fuses are good, I would toggle the Rear Spoiler Switch to see if the servo-motor works properly. It is located under the steering wheel underneath the flat part of the dash.

try lubricating the joints on the spoiler and lift mechanism. use a teflon based lube. or something similar so that it doesn't gum up the hinges


good luck
Jason

This is more than likely the rear spoiler. When exceeding 45 mph, the spoiler will deploy but is hard to hear due to the sound of the engine, when decelerating back to 10 mph (or less), the spoiler will return to its stored position. This sounds exactly like the experience you described, so I am guessing that this is the culprit.
There are a few ways to confirm:
1: Seated in the driver's seat, reach beneath the dashboard console, searching for a button/switch. This will be located at the bottom of the console (roughly, right above where your left shin/knee would be positioned when driving). If you find a switch, push it and see if it deploys the Spoiler. You will need to have the key and turned so that electricals may function.
2: Look above your rear window. You will likely see a black piece of plastic above it which would be the spoiler. Look at the gap between it and the window.. ...looking about 1 fit in from the side of the Spoiler, you will likely see the metal hinge that the moves the Spoiler up.
3: This is the most fun solution: drive the car over 45 with a friend driving behind you. Just to be safe, take it up to 50 or 60 and have them watch to see if it deploys. You will not be able to see it from within the beetle unless you lower the back seat and have somebody crawl all the way into the back (which would be terribly unsafe and uncomfortable).

Let us know if this is indeed the issue and have fun with your bug!