Question about Cars & Trucks

Open Question

Astra h steering rack leak

Fluid leaking from steering rack can i replace seal

Posted by Anonymous on

6 Suggested Answers

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.
goodluck!

Posted on Jan 02, 2017

mnabi01
  • 94 Answers

SOURCE: RACK AND PINON DODGE RAM 1500 2005

if you have a leak from the back of the rack your sector shaft seal is defective. to replace it you need to remove the rack and do it on the bench.remove the locking nut and pull the seal from inside.if you are a rooky replace the rack with a rebuild one. good luck.

Posted on Jan 27, 2009

  • 54 Answers

SOURCE: 99 windstar leaking power steering fluid

all the boot does is keep dirt from getting to the lip seal if its leaking youl atleast need to replace seal and boot i think on that model youl need a specialty inner tie rod tool to remove before you can get the seal out. if it was me i believe id replace the whole rack if you plan on keeping the rig long hope this helps please rate me thanks

Posted on Mar 22, 2009

  • 1 Answer

SOURCE: Rear Main Seal leak on 1996 toyota camry, 6 cyl sedan automomatic

Rear main crank seals are very difficult and time consuming to replace. The seal doesn't cost that much - it is the labor/tiime it takes because --- you've got to take the whole car apart --- that is both
front CV joints have to come out -- then the tranny has to come out - I have a 1996 Camry and it has an irritating rear main seal at 147,000 miles and I have not had it fixed because the shops tell me it will cost around $650 to $800 for them to do it --- $1200 is pretty excessive for that job!

Your power rack and steering is not so hard -- most shops in this area would charge $650 max for that job including the price of the new rack and pinion. Pretty easy job -- half the cost is labor - the other is for parts.

Any more questions --- reply to manuel.conde@motivaent.com

Posted on Apr 29, 2009

  • 20 Answers

SOURCE: 2001 jetta Power steering fluid leak

A power steering system has a rack,fluid tank with hose to pump,pump,high pressure in hose and a low pressure return hose to tank. I f you say theres no leak at the rack that only leaves those other conponents. I would check the pump its self and the high pressure hose where it leaves the pump. It may also be leaking at the tank, where the hose leaves to the pump because it is only fastend down with clips and they can come loose or the hose can split. hope this helps

Posted on Jun 03, 2009

  • 2926 Answers

SOURCE: severe leak in rack and pinion-dumping steering fluid

Have you ruled out a leaking hose or hose connection? If so, to replace a rack system on most cars is an expensive repair. The labor rate can be from 70-125 an hour depending on the shops rate, then this is calculated to the over-all time they say will take to complete the job, usually 2.5 hours possibly a little longer and the rack system is about $185.00 -200.00 dollars.

Posted on Feb 03, 2010

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

Rack and pinion leaking steering fluid what should i do


is it a hose or the seals? if it is a hose the only thing to do is replace the hose. if it is the seal you can fill it with brake fluid and it might soften the seals and make them stop leaking if not you will have to replace the Whole rack. I have used brake fluid to stop leaks on many cars and trucks on the power steering and the transmissions and have never had a problem

Jan 24, 2013 | Cars & Trucks

1 Answer

Is it possible for power steering fluid to get into the engine and mix with the oil? I am loosing fluid and there are no visible leaks, the engine oil and filter was recently changed and now has turne


No, the power steering is entirely a separate and sealed system, wholly external to the engine. The power steering pump pushes the fluid through a high pressure hose into the rack and pinion-the steering gear mounted below and behind the engine-and holds pressure within the rack that enables power assisted steering. At the same end where the power steering fluid hose enters the gear will be a fitting for a return line back to the fluid reservoir. These two hoses are usually routed close together at least part of the way, some may even be held together with brackets. Leaks could develop at the pump, the fluid reservoir, or the two hoses to and from the rack and pinion, or the seals inside the rack and pinion may have failed. You should be able to find the leak-it will only leak to the outside-to check the rack and pinion for leaks, right where your tie rods come out of the gear and go to the wheels for steering, will be a small rubber boot encasing the tie rod and the end of the rack assembly-on both ends is a boot and a tie rod-peel back the rubber boot from the gear ass\'y, it should be dry. If a lot of fluid, the seals in the rack and pinion are gone. It will have to be replaced.
Hopefully you will find a leaking hose or fractured reservoir, but keep looking, air flow may be blowing the leaking fluid back and under the car. Good luck, hope it\'s not the rack and pinion.

Jan 24, 2013 | Honda Cars & Trucks

2 Answers

The steering is hard to move and the steering warning light is on. Please let me know what to do I need to urgently resolve it.


The servo unit on the steering has failed . Look inside the engine bay for oil leaks - if none are present then the entire steering rack will have to be replaced - the internal seals have failed.

Jul 13, 2011 | 2002 Volkswagen Golf

1 Answer

Have a Lincoln Cont. 1999 that eats power steering , does not leak out any where, but smells like its being burnt. Where does it go and how to fix ?


there has to be a leak if you are continually topping up the steering fluid.check the power steering lines closely for leak it may just be a pinhole leak.if this has rack&pinion steering check the bellows(rubber boots on either side of the rack)the fluid could be leaking into the boots past the inner seals.if it is then the rack will have to be replaced and an alignment done.check the power steering pump for any leaks as well.if it has conventional steering check the steering box seals for leaks and the hoses as well.

Apr 27, 2011 | 1997 Lincoln Continental

1 Answer

I refill and it leaks out even if engine off. have to refill by 25 miles. cant find the leak but puddles are under car around pump area. cant figure if it is hose or pump. looked at picture of powercraft...


Well don't know exactly what vehicle you are working on but it is very possible that if is a car then the inner seals on the rack-n-pinion are worn out causing the fluid to leak out. If it is the rack seals leaking then you will need to replace the rack-n-pinion. Good luck.

Apr 16, 2011 | Chevrolet Impala Cars & Trucks

3 Answers

I went to drive my car to work this morning and lost the power steering feels like it locked up the leak of power steering fluidf is leaking from the rack and pinion not pump


Hi and welcome to FixYa!

If that's the case then the oil seals of the rack and pinion should be replaced. If the seals are worn out it tends to leak and can definitely feel a loss of power. If it still leaks even after the replacement then the rack and pinion should be replaced.

There are instances that after oil seal replacement it still leaks it's because that the rack and pinion has severe damage.

Hope this helps and thank you for using FixYa! Have a good one!

Jan 24, 2011 | 1997 Dodge Intrepid

3 Answers

There is power steering fluid dripping from the passenger side boot covering the rod that connects to the wheel. Could a simple replacement of the boot be the fix, or is there a problem with the main unit...


No, the boot only keeps dust out of the inner tie rod joint--it is not intended to hold back fluid. The rack will have to be rebuilt with new seals. Sorry. :o(

Dec 05, 2010 | 1998 Toyota Sienna

1 Answer

Poer steering fluid is leaking. Fan runs slow


Check power steering rack. on the camarys its alittle more common than most cars. poke a hole in the boot and watch for a leak. Nothggn should come out of there. If you have fluid coming from the boots then your internal seals are leaking on the rack. a small hole will not hurt the rack if nothing comes out.

Also check your power steering pump shaft. sometimes the seal will leak
.
I think your over heating problem may be a different problem all together.

Hopefull that helps.
Michael

Apr 29, 2009 | 1992 Toyota Camry V6

1 Answer

Power Steering Fluid Leak, boiling fluid.


Look at the steering rack on the side of the car that you think the leak is, look for the steering rack boot or gaiter, it looks like a black circular accordian type thing.
If this is bulging and leaking fluid the seal in the end of the rack is gone, this is one of the most common faults of leaking fluid and at the rate you are losing fluid, the leak is on the pressurised side of the system after the pump (the seal at the end of the rack)

Aug 11, 2008 | 1996 Audi A4

Not finding what you are looking for?
Cars & Trucks Logo

Related Topics:

117 people viewed this question

Ask a Question

Usually answered in minutes!

Top Cars & Trucks Experts

yadayada
yadayada

Level 3 Expert

75051 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

22095 Answers

Randy Ohler

Level 3 Expert

14585 Answers

Are you a Car and Truck Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...