Question about 2004 Volvo S80

Open Question

How do you replace a headlight assembly on a 2004 S80

Posted by Anonymous on

3 Suggested Answers

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.
goodluck!

Posted on Jan 02, 2017

  • 60 Answers

SOURCE: I have to replace the ballast for the HID

You need to remove the front bumper. Five push clips along the hood line, remove the headlight wipers (if equipped), one T25 screw in the front of each fender well, then two 12mm bolts under the headlights (1 each side). Then there are 4 10mm bolts holding the headlight in.

Posted on Aug 27, 2009

dcramer531
  • 1654 Answers

SOURCE: I have a 2000 Volvo

I have used some clear silicone waterproof calk to fix issues like this in the past, just be carefull and go slow and wipe any excess of so it does not run or smear. Use as little as possible to fill the crack and seal the unit. You can get the small tubes with the funnel shaped dispenser tube in the hardware stores in the plumbing or calk dept. Just fill it in and let it set for several hours or overnight before getting it wet

Posted on Jul 26, 2011

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

How do I install the replacement wiper for headlights on my 2004 Volvo S80


Undo the nut & pull arm off then fit new arm, if replacing the motor you need to remove bumber

Dec 01, 2016 | 2004 Volvo S80

1 Answer

Where is the fuse for the low beam headlights?


There are 3 fuse boxes in a Volvo S80.

The fuses for the low beam headlights could be in either 3.

Refer to the website below, where it shows a 2012 Volvo S80, which should be similar to the 2008 model for dismantling the fuse box.
http://www.carcarekiosk.com/video/2010_Volvo_S80_T6_3.0L_6_Cyl._Turbo/fuse_interior/replace

Nov 22, 2015 | 2008 Volvo S80

1 Answer

I have a 2004 volvo s80 with HID headlights the left one blinks most of the time. What's wrong with it?


The ballast is going bad replace with after market only 30-40 on eBay 1000x cheaper than oem

Dec 11, 2013 | 2007 Volvo S80 V8 Sedan

1 Answer

Lights will not turn on


HEADLIGHTS NOT WORKING


It can be faulty headlight switch or issue with its wiring. Or its faulty head light fuse.


==========

To troubleshoot the issue i suggest you few help links with appropriate solution. So you can follow the test and confirm what exact problem is there in your case of headlights not working:-----

Click the link below: -----


All headlights not working?

http://repairhelpcenter.blogspot.com/2012/01/all-headlights-not-working.html

----------

Working of Headlight switch?
------------
Both headlight bulbs blow together?

------------
Car headlight bulbs don't last long?

---------------

2007 Dodge Caliber: Low Beam Headlight Not working

http://technoanswers.blogspot.in/2012/06/2007-dodge-caliber-low-beam-headlight.html

----------

2003 Toyota Camry: Headlights Work Intermittently?

http://technoanswers.blogspot.in/2012/04/2003-toyota-camry-headlights-work.html

----------

Chevy Tahoe: Low Beam Lamps are not working?

http://technoanswers.blogspot.in/2012/04/chevy-tahoe-low-beam-lamps-are-not.html

----------

2001 Chevrolet Tahoe: Headlights not coming ON?

http://technoanswers.blogspot.in/2012/04/2001-chevrolet-tahoe-headlights-not.html

--------

2004 Dodge Ram: High Beam Light is DIM?

http://technoanswers.blogspot.in/2012/04/2004-dodge-ram-high-beam-light-is-dim.html

----------

2001 Chevrolet Tahoe: Both Low Beam Lamps Not Working?

http://technoanswers.blogspot.in/2012/04/2001-chevrolet-tahoe-both-low-beam.html

------------

Low beam headlights Modification?

http://schematicsdiagram.blogspot.in/2012/04/low-beam-headlights-modification.html

---------
How to Replace a Headlight

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-headlight.html

------------
How to Replace a Headlight Bulb


http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-headlight-bulb.html

-----------
How to Replace a Headlight Switch

http://schematicsdiagram.blogspot.com/2011/07/how-to-replace-headlight-switch.html

----------
How to Replace a Headlight Assembly

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-headlight-assembly.html


How to Replace a Park Light Assembly

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-park-light-assembly.html

-----------

Low beam headlights Modification?

http://schematicsdiagram.blogspot.in/2012/04/low-beam-headlights-modification.html

----------

Headlight Assembly Removal On Honda Accord

http://technoanswers.blogspot.in/2012/06/headlight-assembly-removal-on-honda.html

---------------

Honda Headlight Assembly Removal
http://schematicsdiagram.blogspot.in/2012/06/honda-headlight-assembly-removal.html

-----------

How to Replace a Headlight Door

http://schematicsdiagram.blogspot.com/2011/08/how-to-replace-headlight-door.html

----------

How to replace HID headlight bulbs for lexus 400h?

http://schematicsdiagram.blogspot.com/2012/01/how-to-replace-hid-headlight-bulbs-for.html

----------------

These will help.

Thanks.

Nov 28, 2012 | 1986 GMC K1500

2 Answers

How do you remove the headlights off a Pontiac grand am 2004


Lighting Headlight, Side Marker, Park & Turn Signal Assembly Removal & Installation To Remove:
  1. Open the hood.
  2. Remove the front air deflector.
  3. Apply light pressure to the headlight lens to hold the headlight in place while disconnecting the retainers.
  4. Lift up the headlight retainers to release the housing.
  5. Remove the headlight assembly, pulling straight forward from the headlight mounting panel. NOTE: Note the location and position of the adjuster retainers and locator tab.
  6. Disconnect the wiring harness from the headlight assembly.
  7. Rotate the bulb(s)/socket(s) as needed counterclockwise to release.
  8. Remove the bulb(s)/socket(s) from the headlight assembly.
To Install:
  1. Install the replacement bulb(s)/socket(s) to the headlight assembly rotating clockwise until fully seated.
  2. Connect the wiring harness to the headlight assembly.
  3. Position the headlight assembly to the mounting panel.
  4. Apply light pressure to the headlight assembly lens to hold the assembly in place while installing the retainers.
  5. Align the headlight assembly retainers and slide them over the assembly mounting tabs
  6. Install the front air deflector.
  7. Close the hood.
prev.gif next.gif

Feb 02, 2011 | 2004 Pontiac Grand Am

2 Answers

Trying to change headlight bulb


Hello,

The 2004 grand prix pontiac houses 2 headlight bulbs per headlight assembly. The low beam headlight are located at the fender of the car and the high beam on the grill side of the assembly.

To replace the headlight bulb of Your pontiac grand prix, 2004 model. It is qiute technical and moderately easy to fix. There is no solution that cannot be done the DIY way, as long as You get the proper guide and You are technically able to do such works.
  1. Park the Grand Prix on a flat surface, apply the parking brake and ensure both the engine and headlight switches are off.
  2. Open the hood and approach the headlight assembly with the faulty headlight bulb.
  3. Locate the headlight assembly retaining clip. It's behind the headlight assembly on top on the fender side. Lift the clip upward halfway to release the headlight assembly.
  4. Pull the assembly out being careful not to scratch the paint on the fender or the lens of the assembly.
  5. Reach behind the assembly and disconnect the wire connection and plug from the headlight bulb socket.
  6. Turn the socket of the bulb counterclockwise 1/4-turn to remove the composite bulb from the assembly. Discard the bulb.
  7. Install the replacement bulb into the assembly (handling the plastic socket part only oil in skin will damage the glass bulb of halogen bulbs because of the intense heat they burn at), but ensure the tabs of the socket end of the bulb are aligned with the notches in the assembly before turning it clockwise and locking the bulb into place.
  8. Plug the wire connection back into the socket of the bulb before replacing the assembly back into place and pushing down on the retaining clip. Test the headlight bulb for operation before closing the hood.
Hope this was helpful. Thank You for using FixYa!!!

Jan 15, 2011 | 2004 Pontiac Grand Prix

1 Answer

2004 Audi A4 headlight replacement


you have to loosen the whole headlight assembly to open the covers behind the lights to actually get to the bulbs. 4 screws, 2 are on the top of the assembly(phillips screws) the other two are hex and attach the bottom of the assembly to the car. somewhat difficult to see but look behind the assembly and down into the compartment and loosen the screws(they don't fully come out) just enough to pull the assembly out. open the black cover behind he low bean and there is the bulb

Jan 21, 2010 | 2004 Audi A4

1 Answer

Replacing headlight assembly --or cover--for Kia Optima-2004



1. Open hood. Disconnect negative battery cable.
2. Remove five bolts attaching headlight and combination light assembly to vehicle. deb10ad.jpg 3. Pull headlight and combination light assembly forward clear of vehicle. 4. Rotate back cover counterclockwise to disengage from light assembly. 5. Pull socket with bulb straight out of headlight and combination light assembly. Regards, Jeep Brainy

Jun 22, 2009 | 2004 Kia Optima

1 Answer

Headlight Assembly Replacement


We have the same probleme but no answer

Aug 02, 2008 | 2004 Volvo S80

1 Answer

Front nose assembly of 2000 Volvo S-80


There was a special cap available from Volvo to address this problem. It replaces the existing cover that accesses the bulb. I can't remember if it applies to the 2000 S80, but I would check with the dealer first before replacing the headlamp assembly.

Bret
RepairPal.com

Jul 05, 2008 | 2000 Volvo S80

Not finding what you are looking for?
2004 Volvo S80 Logo

Related Topics:

59 people viewed this question

Ask a Question

Usually answered in minutes!

Top Volvo Experts

yadayada
yadayada

Level 3 Expert

75066 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

22095 Answers

Jeff Turcotte
Jeff Turcotte

Level 3 Expert

7754 Answers

Are you a Volvo Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...