Question about 2002 Suzuki Grand Vitara

1 Answer

2000 Grand Vitara V6 4x4

Vibration and leaking oil from the seal for the front driveline output shaft off the T case. Any idea what it could be? How to figure out what I need to fix?

Posted by on

1 Answer

  • Level 3:

    An expert who has achieved level 3 by getting 1000 points

    Superstar:

    An expert that got 20 achievements.

    All-Star:

    An expert that got 10 achievements.

    MVP:

    An expert that got 5 achievements.

  • Suzuki Master
  • 20,706 Answers

Bad seal
clogged vent.
bearing bad , there will kill any seal./
old post

Posted on Feb 09, 2015

6 Suggested Answers

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.
goodluck!

Posted on Jan 02, 2017

  • 373 Answers

SOURCE: front axle how to remove half shaft

Hi.. The step to remove the front Axles of you Vitara.
Raise and support Vehicle . Remove front wheel,
Drain Diff,fluid,
Remove Locking Hub if is equipaded,
Remove Circle clip from axle shaft
On right side of Vehicle, Remove the Stabilizer Little ball joint nut. Remove castle nut Front Tie rod end,
Remove mounting bolts from brake calipper,
Remove Calipper from steering knuckle and wire a side.
Remove Stud Nut from steering knuckle,
Support Lower suspension arm with a jack,
Remove lower strut bracket bolt ,
Lower jack and disconnect Knuckle from lower suspension crontrol arm,
Pull Outler joint from Hub.
Use Large screwdriver or Prybar To pry Right inner joint from differential, The axle will go out making a little froce with the prybar,
To remove the left side,
Remove mounting bolt from inner joint flange,
Pull out axle from hub.

To reinstall just reverse the prosses.

I hope this help on your job...
Thank you for use fixya....


Posted on Aug 19, 2008

  • 2 Answers

SOURCE: Suzuki Grand Vitara Oil Filter Replacement Disaster

Four or six cylinder engine and behind or front of the oil filter? Looked under my GV 2007 2.7 V6 and can not locate a shiny metal box next to the oil filter. Only thing that was shiny was the exhaust manifold and oil sump which are quite hard to break or puncture. If it was the oil sump you will have to remove it and get it welded as a bog will not hold on heated engine parts.

Posted on Nov 02, 2008

  • 84 Answers

SOURCE: LEAKING OIL FROM T-CASE SHAFT TO TRANSMISSION

Have you tried the dealer, they should have this seal, if not let us know the measurements and we can help

Posted on Dec 23, 2008

  • 15 Answers

SOURCE: Oil leak from crank shaft by harmonic balancer on

remove balancer and replace crank seal

Posted on Mar 09, 2009

boysor2933
  • 293 Answers

SOURCE: 1999 Suzuki Grand Vitara Vibrate/shake at 55-70 mph

Lift the back of your car.With a stable rest and with the two hind wheels hanging, run your car up to the speed where you experienced vibration. have someone take care of the throttle and shifting while you observe the transmission shaft. You may have an imbalanced shaft.

Posted on May 29, 2009

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

I have an oil leak at the end of the front driveline


when u say drive line do you mean the drive shaft for front axle and what side transfercase side or axle side and how bad a oil leak as it's normal for a slight wet look to be around the transfercase side shaft exit as this is all a "Wet" system and will seep a bit as things get lubed by oil in use , now if it leaves a puddle on ground thats too much and you should have it ck'd by a trusted mechanic (don't allow transfer case to go "dry") that would be expensive to fix then

please read my tip'sN tricks for dealing with 4wd drive seals after use could save you lots of bucks

Nov 06, 2013 | 2005 Ford Explorer Sport Trac

1 Answer

Transfer case


There is a gasket on the mating faces, this would appear to have failed. get it replaced before your fluid is gone. It could be a failed transfer box, but I can't be sure from your description. Get it looked at by a professional.

Apr 30, 2013 | 2000 Suzuki Grand Vitara

2 Answers

Need to replace the transfer case seal


I will only guess

You most likely will have to remove the
transfer case, unless it is on the back
output shaft & you can get to it

You already knew that

You won't have to strip it clean,
if that is your question.

Just remove the yoke & whatever ,
to do the seal.

Apr 26, 2011 | 1994 Jeep Grand Cherokee

1 Answer

Leak coming from transfer case. It leaks right were the rear drive live goes into the transfer case. Replaced the seal once. Was leak free for about a week, and now it is worse than before. Possible...


the trans case is not under a pressure, the fluid is a free flow oiler that gets slung around by chain and gears. are you sure it was the right seal ? DIdnt damage it on install !!? did you over fill the case ? Check rear spline on case and make sure it is not sloppy movement back and forth, up and down. if it is then seal is getting pushed all over and oil seaps past. but you would have a vibration while driving that you would notice. is ther a groove on rear slip yoke that is riding on seal groove. after reading your question again, are you talking about the drive shaft going into the transfercase or the main trans/ transfercase mating area? What is a rear drive live? rear driveline!! as in driveshaft?

Jan 11, 2011 | 1995 GMC Sierra C1500

1 Answer

What causes the transfer case to leak wher the driveline goes into it


the drive shaft seal needs to be replaced in the transfer case

May 21, 2010 | 1994 Jeep Grand Cherokee

2 Answers

2001 Grand Vitara - leaking oil-needs to be resealed, what parts do I need to purchase?


There is more than one seal on a car. But, having said that, the first place I would look would be at the rear main seal area - where the crankshaft leaves the engine. This you won't be able to see directly, and you want to be very sure that it IS leaking before you start because the gearbox and transfer assembly has to come out first. Or you could remove the engine! There are at least 3 other oil seals and a number of gaskets and hoses that could also be the source of your problem. You have to describe where the oil is leaking from.

Oct 09, 2009 | 2001 Suzuki Grand Vitara

1 Answer

Oil leaking out the front of the lower fan belt


If the lower fan belt pulley you are referring to is the vibration damper or harmonic balancer, then that is the pulley that is attached to the engine crankshaft, and that pulley is what turns all the other pulleys on the engine. There is a seal on the shaft behind the pulley -the front main seal. This is what may be leaking oil, and if that is the case , the seal needs to be replaced.
If it is the front main seal, and you are going to tackle the repair, you need to get a Repair Manual for your vehicle and follow the directions for the fix.

Jul 09, 2009 | 1990 Mazda B-Series

1 Answer

Oil leaking from what looks like the harmonic balancer bearing


You need to pull the harmonic balancer and replace the seal... if i remember right it's a one peice press fit seal

Robert

Jan 16, 2009 | 1999 Suzuki Vitara

2 Answers

Loosing oil on the output shaft of the transfer case, I changed the seal two times it's still leaking.


You may have pressure build up in the tranfer case and its going out the weakest spot which is the seals.Who changed the seals?Your transfer case may have a blocked breather if fitted

Oct 20, 2008 | 2004 Jeep Grand Cherokee

Not finding what you are looking for?
2002 Suzuki Grand Vitara Logo

154 people viewed this question

Ask a Question

Usually answered in minutes!

Top Suzuki Experts

yadayada
yadayada

Level 3 Expert

75005 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

22095 Answers

Boyet Soriano
Boyet Soriano

Level 2 Expert

293 Answers

Are you a Suzuki Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...