It takes a long time to fill the gas tsnk.
It has to be slowly pour in if not it comes back out.
I remove the tank to see if there is any restriction on the lines'
did not find any. which line removes the air when fueling?
how do I check if the valve for the air is working properly?
An expert who has achieved level 2 by getting 100 points
An expert that got 5 achievements.
An expert who has answered 200 questions.
An expert whose answer got voted for 20 times.
Re: filling the gas tank 2000 chevy impala
Make sure that the little hose is clear of any restrictions and you can blow through it this will be the vent tube for the fuel tank. there is also a check ball that may be lodged in the tank and it is located in the tank right where the fill tube connects to the tank. you should be able to disconnect the tube and move it around with your finger. thanks and keep me updated or if you run into a problem
- If you need clarification, ask it in the comment box above.
- Better answers use proper spelling and grammar.
- Provide details, support with references or personal experience.
Tell us some more! Your answer needs to include more details to help people.You can't post answers that contain an email address.Please enter a valid email address.The email address entered is already associated to an account.Login to postPlease use English characters only.
Tip: The max point reward for answering a question is 15.
no two cars are the same, fill the tank drive till the light comes on fill the tank , take note of amount. check drivers manual for total fuel amount subtract refill amount , that how much fuel was left in the tank as much as 10 Lt. some times. to save time the drivers manual often states this amount.
What happens if you fill from a portable gas can? No spills on the ground other than from the fill location? Do you have a "locking cover"? Air needs to come out of the tank, It is possible something has gotten into the fill neck of the tank preventing fuel from going into the tank. The portable gas can may reveal that kind of problem. Has anyone tried to work on the fuel system, perhaps the emission system? If so take it back. It almost sounds like the vacuum pump is "discharging" into the tank. So the correct "plumbing" connections have been compromised. or the pump is running backwards, so the electrical connections have been compromised. Is the car just back from collision repair? Take it back.
There are two pipes that go from the fill port to the tank. One big one to let the fuel in and one small one to let the air out. If air cannot get out, fuel cannot get in. When fuel stops going in the fuel pump assumes the tank is full and shuts off. The small one is plugged somewhere, hopefully one of the small rubber hoses. A work-around is to fill the tank slow enough that the pump does not shut off.
As far as I know, the only charcoal filter is in the recirculation/evap system and it's up front where fuel lines enter carb/injector system. Cuts down emissions by recirculating/recycling fumes back to tank. There is a screen at the bottom of the fill spout into the tank to prevent gas theft by siphoning. Might check that screen for rocks etc that some nimwit might have dumped in there. Try to find someone with one of those little cameras with light they use to check cylinders through the spark plug holes. Run it down your fill spout a look around. Or else pay the really overpriced charges for the dealership to take out the tank and clean it.
There should be an air vent coming from the top of the gas tank back to the top of the fuel tank. Possibly kinked or pinched, try pulling the fuel nozzle about half way out and filling the tank on the lowest setting the fuel pump will let you.
Please take a moment and rate my answer...........Thanks
There's a rubber hose like a radiator hose from the gas tank to where you fill your tank (the fill pipe) and a clamp on each end. Sometimes they do loosen up from vibration and bouncing up and down on bumpy roads.
I have a 2005 Hyundai Accent, It is not possible to fill the tank if you are letting the petrol pump run at full speed.Trying to fill up quickly it will only build up pressure and cut off. Next time you fill up just pull the petrol pump handle half way, it will take longer to fill but you wont get the blow back. Modern petrol pumps are getting quicker all the time.Hope this helps you.
Take your rig.. drive it to a gas station.. fill the tank up with gas.. also fill 2 jugs of gasoline at the same time... put the jugs in the back of it.. now drive as far as you can until the rig runs out of gas.. then, take the two jugs of gas.. pour it all over the rig, inside and out.. now light it a-blaze, then walk to your nearest car dealer and buy a new car..