Question about 1992 Daihatsu Charade

2 Answers

Need to change a WATER PUMP on my DAIHATSU CHARADE GLXI 1994

Having difficulty in locating and removing the water pump from my Daihatsu Charade GLXI 1994 (M reg) 5 door hatchback,
Chassis No; JDAG200S000511881, can you help,

Posted by on

2 Answers

  • Level 1:

    An expert who has achieved level 1.

    Corporal:

    An expert that hasĀ over 10 points.

    Mayor:

    An expert whose answer gotĀ voted for 2 times.

  • Contributor
  • 1 Answer

The location of the pump is on the left hand side of the engine when standing at the front of the car.
You will see (if you have aircon) two belts.
If you stand to the side of the car to look at the belts.
From memory the inner one (closest to the engine) drives the aircon compressor.
The outer one drives the water pump, you will see the pump belt wheel towards the back of the engine.

Getting into the pump is a bit tricky.
I basically unbolted the engine mount from the body which then allowed me to jack up the engine as I needed it to give me space to unbolt everything until the 3 water pump bolts can be seen.
Just make sure you know which bolts go back where.
From memory there were about 20 bolts to undo before I got to the water pump.

Aircon compressor bracket bolt I only loosened them from the engine not fully removed, the same with the alternator I only removed the adjusting bolt to remove the belt.

Oh I just thought of something to do before you remove the tension on the belts... loosen slightly the 4 small bolts that are on the wheel that bolts onto the water pump.

I think the only size sockets and spanners I used were 10, 12, 14 & 17.

It took me around 2 hours to get it all undone, and close to the same to put it all back together with the new pump.

It was kinda straight forward as you can see what you need to unbolt because you know what bit you need to get into.

I hope this helps a little, I am not sure if it is clear in the way I have written it. But feel free to ask any questions.



Posted on Mar 11, 2009

  • Level 1:

    An expert who has achieved level 1.

  • Contributor
  • 1 Answer

Daihatsu manuals hi my name is craig just wounding if or how hard it would be to take my .993 Lt out of my 1993 daihatsu & place a 1.5 Lt in it around the same time it was made in 1993

Posted on May 19, 2013

1 Suggested Answer

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.
goodluck!

Posted on Jan 02, 2017

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

Why does my 1990 Daihatsu charade want to cut out and stall when giving throttle unless it's in high rpms it doesn't want to go we've replaced the fuel pump and filter could it be the injectors?


Daihatsu Charade low idle problems Questions & Answers ...

www.fixya.com > ... > low idle problems > Cars & Trucks > Daihatsu
Daihatsu Charade cars & trucks low idle problems questions and answers. ... but idles unevenly with foot on accelerator. does not want to accelerate. please . ... problem daihatsu cherade 1991. when the airconditioner is on the car stalls when changing down to a lower . ... 1990 daihatsu applause 101a 1.6lt 5spd manual.

Daihatsu Charade car keeps cutting out when stop ... - Fixya

www.fixya.com > ... > Cars & Trucks > Daihatsu
Daihatsu Charade cars & trucks car keeps cutting out when stop questions and answers. ... 1997 Daihatsu Charade CS G203 1.5i manual stalling when warm ... gear) while accelerating or when coming to a stop and you take it out of gear and ... 1990daihatsu applause 101a 1.6lt 5spd manual car starts normaly. when auto ...

Nov 17, 2015 | Daihatsu Cars & Trucks

2 Answers

Where is the thermostat located on a daihatsu charade 1993 hc model


it's in the water inlet/housing near the distributor on the top left rear of the engine.

Jul 18, 2010 | 1992 Daihatsu Charade

1 Answer

Is there any manuals online that would guide me through replacing a water pump on a Daihatsu charade 1989?


Hi:
A good online manual is available. Just go to:
http://www.alldatadiy.com/

The subscription is about $27, but very worth the investment.
They have always helped me.
You can go to their site and browse around, to see what I mean.
Hope you get your water pump fixed...

Jan 27, 2010 | 1989 Daihatsu Charade

2 Answers

1992 Daihatsu Charade water pump?


Good luck with trying to replace this pump man, I just replaced mine put everything back together and four days of work later the dang thing wont turn over now. lol. as far as the diagram you can find on in google images or at daiclub.com that is where I found mine, and it was free both ways!! Good luck Merry Christmas

Oct 16, 2009 | 1992 Daihatsu Charade

1 Answer

Removing thermostat from Daihatsu Charade


Thermostat is in the cooling water output from engine hose.See figure
f118311.gif

Aug 16, 2008 | 1992 Daihatsu Charade

1 Answer

My Daihatsu Charades water pump melancholy


Just put a car jack under the sump with a piece of wood between the jack and the sump. Take up the weight of the engine and then release the engine mount if required. Make sure to put some chocks (e.g. brick) behind and in front of the wheels to stop the car rolling.

Jul 26, 2008 | 1992 Daihatsu Charade

1 Answer

How do I remove the water pump in a daihatsu G200 charade with a 1.3 litre .


If you have to sak you need to get a workshop manual. The engine hasn't changed since the late 80's, so a general Gregorys for Charade should be adequate.

Jul 26, 2008 | 1992 Daihatsu Charade

Not finding what you are looking for?
1992 Daihatsu Charade Logo

1,508 people viewed this question

Ask a Question

Usually answered in minutes!

Top Daihatsu Experts

Colin Stickland
Colin Stickland

Level 3 Expert

21981 Answers

yadayada
yadayada

Level 3 Expert

63585 Answers

Donald DCruz
Donald DCruz

Level 3 Expert

17129 Answers

Are you a Daihatsu Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...