Question about 2003 Saturn ION

1 Answer

Where is 2003 saturn ion thermostat?

Location of satur ion 2003 thermostat??

Posted by on

  • Anonymous Mar 16, 2014

    trying to locate the ignition module control unit in my 2003 saturn ion

×

1 Answer

  • Level 3:

    An expert who has achieved level 3 by getting 1000 points

    All-Star:

    An expert that got 10 achievements.

    MVP:

    An expert that got 5 achievements.

    President:

    An expert whose answer got voted for 500 times.

  • Master
  • 1,596 Answers

FACEING the ENGINE It is At TOP RIGHT SIDE Close to Master Cylinder takes About 1 hour to Replace Have Fun its a EASY One
Please Dont forget to RATE ME Thank You

  1. Drain the cooling system.
  2. Remove the bolts that secure the thermostat housing to the water pump feed pipe.
Remove the feed pipe
  1. Remove the thermostat and retaining sleeve, noting the orientation for installation.
Installation Procedure
Install the thermostat and retaining sleeve with the dimple placed into the housing slotImportant: Lubricate the O-ring with soapy water or coolant before installing the O-ring in the water pump.

  1. Install the feed pipe that connects the thermostat housing to the water pump.Notice: Refer to Fastener Notice in Service Precautions.

    1. Install the bolt that secures the water pump feed pipe.
      • Tighten the bolt to 10 Nm (18 inch lbs.) .
    1. Fill the cooling system.

Posted on Feb 09, 2009

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

2 Answers

Where's the fusebox located


INSIDE BY THE GAS PEDAL to the right behind the trim panel

Jun 03, 2015 | 2003 Saturn ION

1 Answer

Thermostat replacement


here are 12 steps to do this:

  1. www.ehow.com/how_4590726_change-thermostat-saturn-ion.html ‎

Mar 03, 2015 | 2003 Saturn ION

1 Answer

Where is the thermostat on my 2003 Saturn Ion Level 3? I have no steam or smell but my needle on the dash keeps creeping up to almost the red mark. When i drive and don't idle it goes back down. Hel


Sounds like your electric fan is not coming on. Do you have heat? if not it might be thermostat, if yes, listen for or look and see if your electric fan is coming on

Sep 12, 2014 | 2003 Saturn ION

1 Answer

Where is the starter located on a 2003 saturn ion


It is located about in the middle between the engine and the transmission. Also it is directly below the intake manifold. Hope this helps.

Jun 10, 2014 | 2003 Saturn ION

1 Answer

Where would the fuse or relay for fuel pump be located in my 2003 ion


Look in the interior fuse block. It is located on the drivers side of the center counsel, just to the right or where our right leg would be. You will need to remove the trim panel. The fuses will be labeled on the inside of the panel. Page 5-96 http://www.saturn.com/content/dam/saturn/northamerica/usa/nscwebsite/en/Home/Owners/Owner_Resources/Manuals/en/us/2004/ion/2004-saturn-ion-owners-manual.pdf#page325

Apr 06, 2013 | 2003 Saturn ION

2 Answers

Where is the battery located in a saturn ion


MIGHT BE IN TRUNK UNDER SPARE TIRE COVER G5 IS IN THE SAME PLACE,CAN'T HURT TO LOOK.

Jan 29, 2010 | 2003 Saturn ION

1 Answer

Over heats


a bad thermostat. or a bad water pump.

Apr 24, 2009 | 2003 Saturn ION

1 Answer

Oxygen sensor location on a 2003 Saturn Ion-1


One is front of the cat, and one after the cat of the exhaust.
The OBD Scanner should tell you which bank is producing the error.
Bank one is the front one.

Thanks for using FixYa - a FixYa rating is appreciated!!

Feb 21, 2009 | 2003 Saturn ION

3 Answers

2004 satur ion 2 wont start when below 20 degrees have to wait 30 minutes after trying to start then will start


It is a common problem on Saturn Ion... You have to replace the pass lock switch. The cost of the part is around $65.00 cdn. It is located behind the key switch.

Jul 29, 2008 | 2005 Saturn ION

Not finding what you are looking for?
2003 Saturn ION Logo

Related Topics:

2,048 people viewed this question

Ask a Question

Usually answered in minutes!

Top Saturn Experts

yadayada
yadayada

Level 3 Expert

61037 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

21949 Answers

Jeff Turcotte
Jeff Turcotte

Level 3 Expert

6812 Answers

Are you a Saturn Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...