Question about 1986 Volkswagen Wagon Camper

Open Question

Vw t25 automatic gearbox oil change - 1986 Volkswagen Wagon Camper

Posted by Anonymous on

Ad

6 Suggested Answers

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.
goodluck!

Posted on Jan 02, 2017

Ad
freetek
  • 5568 Answers

SOURCE: vw golf Mk3 VR6 gearbox/cooling system

I don't know where your leak is happening but I suspect the transmission fluid attacks rubber and may be leaking from the heater because of softened hoses.
I think the first move I would make is to buy a Haynes or Chilton service manual and spend some time researching how the transmission and cooling systems are related. The books are available at auto parts stores (or on line of course) and cost between $17-$30 US.  

Posted on Oct 13, 2008

Ad
jackiaria
  • 350 Answers

SOURCE: How to change the automatic gearbox oil - Seat - Cordoba - 1996

There will be a plug on the bottom of the transmission casing to let the old gearbox oil out.
On an automatic trans the filler is usually on top at the trans dipstick.
On a manuel trans there is a plug about half way up the trans casing.
Drain fully and put in correct type and amount according to your manual. Do not put any old trans fluid in use the type and quantity recommended by the manufacturer!
I find myself just going to a Quick Lube Shop and letting them do it for a few bucks more.. They get it right and it's faster than me doing it myself.

Hope this will FixYa!
jack
ae14157.jpg

Posted on Feb 07, 2009

  • 226 Answers

SOURCE: changing gears is getting difficult and even when

Check fluid levels first and also check where the shifter comes through the floor and attaches to the rod going to the tranny, make sure that pivot point is not rusted. There's a plastic to metal bushing underneath on the shifter points. If it's rusted, it makes it really hard to shift. If both check out fine, only then look at possible internal issue. (PS - some clicking is normal.)

Posted on Aug 21, 2009

drsinister69
  • 2317 Answers

SOURCE: how to change gearbox oil for vw polo 1998 mk3

There should be a 17mm allen plug at the bottom of the transmission. The filler plug is the same size allen plug on the end of the transmission, visible thru the driver side wheel well.

Posted on Apr 27, 2010

  • 4793 Answers

SOURCE: my 2000 vw passat 1.9 TDI manual grinding gears

as 2nd/3rd are the most used gears chances are the syncromesh on both these gears has gone,you need to strip g/box completly/or buy a recon box.

Posted on Apr 28, 2010

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

VW CABRIO CAR GOES THRU AND SHIFTS FINE WHEN YOU FIRST START OUT AFTER ABOUT 3-5 MINUTES GOING DOWN THE ROAD IT WILL COME OUT OF GEAR IN LIKE A NEAUTRAL POSTION I PUT SHIFTER IN NEAUTRAL AND THEN BACK IN...


Is it a full auto box or auto with manual selection. Full auto has only 1,2,D,R. If its full auto take it to a regular tyre/exhaust place and ask them to help.
The vw and audi auto gearboxes that also have selectable manual gears are only reliable when they have the correct clean oil in them.
The oil is special and expensive, and you must only use the oil from VW. If you havent changed the gearbox oil, get it done. Its much cheaper as a first step, compared to taking the gearbox apart to check for wear or damage.

Dec 19, 2013 | Volkswagen Cabrio Cars & Trucks

1 Answer

Vw t25 gearbox oil change


You will need a very large allen wrench (like 19mm or so) for the drain and fill plugs.
This is an uncommon size so if you do not want to invest in one just have a shop do it.
If you decide to go ahead, get GL-4 hydraulic oil and a pump. Remove fill plug first (to ensure you can before draining transmission!) on side of transmission, about mid-line.
Then remove drain plug (center bottom toward engine). Have catch pan ready.
Once it has all dripped out, replace drain plug and fill with pump through side plug until it starts to drip back out (car level).
Let it finish dripping out, replace plug and good to go!

Jan 20, 2013 | 1986 Volkswagen Wagon Camper

1 Answer

2010 Touran 1.4 how often change the oil for the gearbox and what type and quantity of oil


VW 1.4i with manual gearbox 5 speed transmission:
1. Oil type: VW G50 & G51, full synthetic oil SAE 75 W 90

2. Gearbox refill = 1,9 litres
3. Filling plug location: Side of transmission

Nov 07, 2012 | Volkswagen Cars & Trucks

1 Answer

How do I check the transmition oil level on jetta 2004?


2004 Volkswagen Jetta

THE 5 SPEED AUTOMATIC TRANSMISSION

At the bottom of the automatic gearbox (tiptronic) you will find one threaded plug on below surface, (follow red arrow in the picture below). This is for emptying.

tdisline_432.jpg



The oil level threaded plug is placed on the car front lateral automatic gearbox surface, (follow yellow arrow in the picture below).

tdisline_433.jpg

The filling oil plug is placed on the upper automatic gearbox surface, (follow green arrow in the picture below).

tdisline_434.jpg
Automatic Transmission Fluid (ATF) checking:
1. Requirements for check:
1.1. Vehicle standing on level surface.
1.2. Transmission must not be in fail-safe mode.
1.3. Shift lever in "P" position, parking brake applied.
1.4. Engine idling.
1.5. Air Conditioner and heater OFF.
1.6. ATF temperature must not exceed 104 Fahrenheit degree (40 Celsius degree) at start of test.
1.7. Automatic gearbox oil capacity: 2,5 liter. Only ATF with VW designation may be used. Do not use any lubricant additives.
1.8. Automatic Transmission Fluid ATF - part number: VW G 052 990 A2
1.9. An ATF level check when transmission oil temperature is too low results in overfilling, when too high results in underfilling.
2. CAUTION: Too much or too little ATF will affect the operation of the transmission. The ATF level must be checked at regular intervals.


Don't forget to rate my response. Thanks!

Oct 14, 2011 | 2004 Volkswagen Jetta

2 Answers

2001 v5 vw golf auto gearbox oil change


THE 5 SPEED AUTOMATIC TRANSMISSION

At the bottom of the automatic gearbox (tiptronic) you will find one threaded plug on below surface, (follow red arrow in the picture below). This is for emptying.

tdisline_432.jpg



The oil level threaded plug is placed on the car front lateral automatic gearbox surface, (follow yellow arrow in the picture below).

tdisline_433.jpg

The filling oil plug is placed on the upper automatic gearbox surface, (follow green arrow in the picture below).

tdisline_434.jpg
Automatic Transmission Fluid (ATF) checking:
1. Requirements for check:
1.1. Vehicle standing on level surface.
1.2. Transmission must not be in fail-safe mode.
1.3. Shift lever in "P" position, parking brake applied.
1.4. Engine idling.
1.5. Air Conditioner and heater OFF.
1.6. ATF temperature must not exceed 104 Fahrenheit degree (40 Celsius degree) at start of test.
1.7. Automatic gearbox oil capacity: 2,5 liter. Only ATF with VW designation may be used. Do not use any lubricant additives.
1.8. Automatic Transmission Fluid ATF - part number: VW G 052 990 A2
1.9. An ATF level check when transmission oil temperature is too low results in overfilling, when too high results in underfilling.
2. CAUTION: Too much or too little ATF will affect the operation of the transmission. The ATF level must be checked at regular intervals.


Don't forget to rate my response. Thanks!

Sep 26, 2011 | Cars & Trucks

1 Answer

Where to check and then add transmission fluid to 2001 jetta


THE 5 SPEED AUTOMATIC TRANSMISSION

At the bottom of the automatic gearbox (tiptronic) you will find one threaded plug on below surface, (follow red arrow in the picture below). This is for emptying.

tdisline_432.jpg



The oil level threaded plug is placed on the car front lateral automatic gearbox surface, (follow yellow arrow in the picture below).

tdisline_433.jpg

The filling oil plug is placed on the upper automatic gearbox surface, (follow green arrow in the picture below).

tdisline_434.jpg
Automatic Transmission Fluid (ATF) checking:
1. Requirements for check:
1.1. Vehicle standing on level surface.
1.2. Transmission must not be in fail-safe mode.
1.3. Shift lever in "P" position, parking brake applied.
1.4. Engine idling.
1.5. Air Conditioner and heater OFF.
1.6. ATF temperature must not exceed 104 Fahrenheit degree (40 Celsius degree) at start of test.
1.7. Automatic gearbox oil capacity: 2,5 liter. Only ATF with VW designation may be used. Do not use any lubricant additives.
1.8. Automatic Transmission Fluid ATF - part number: VW G 052 990 A2
1.9. An ATF level check when transmission oil temperature is too low results in overfilling, when too high results in underfilling.
2. CAUTION: Too much or too little ATF will affect the operation of the transmission. The ATF level must be checked at regular intervals.

Sep 18, 2011 | 2001 Volkswagen Jetta TDI

1 Answer

How can i add transmission fluid to my 2001 vw golf,,auto trans.


THE 5 SPEED AUTOMATIC TRANSMISSION

At the bottom of the automatic gearbox (tiptronic) you will find one threaded plug on below surface, (follow red arrow in the picture below). This is for emptying.

tdisline_432.jpg



The oil level threaded plug is placed on the car front lateral automatic gearbox surface, (follow yellow arrow in the picture below).

tdisline_433.jpg

The filling oil plug is placed on the upper automatic gearbox surface, (follow green arrow in the picture below).

tdisline_434.jpg
Automatic Transmission Fluid (ATF) checking:
1. Requirements for check:
1.1. Vehicle standing on level surface.
1.2. Transmission must not be in fail-safe mode.
1.3. Shift lever in "P" position, parking brake applied.
1.4. Engine idling.
1.5. Air Conditioner and heater OFF.
1.6. ATF temperature must not exceed 104 Fahrenheit degree (40 Celsius degree) at start of test.
1.7. Automatic gearbox oil capacity: 2,5 liter. Only ATF with VW designation may be used. Do not use any lubricant additives.
1.8. Automatic Transmission Fluid ATF - part number: VW G 052 990 A2
1.9. An ATF level check when transmission oil temperature is too low results in overfilling, when too high results in underfilling.
2. CAUTION: Too much or too little ATF will affect the operation of the transmission. The ATF level must be checked at regular intervals.

Sep 12, 2011 | 2001 Volkswagen Golf

2 Answers

My 2006 vw jetta needs transmission fluid. The manual says I have to take it into a vw dealership however, the closest one is two hours away. Can I add the fluid myself and how?


1. Check and add transmission fluid on a 2006 VW Jetta with manual gearbox:

tdisline_575.jpg
tdisline_579.jpg

2. Check and add transmission fluid on a 2006 VW Jetta with automatic gearbox:

tdisline_580.jpg
tdisline_581.jpg

May 26, 2011 | 2006 Volkswagen Jetta

2 Answers

How to check auto trans oil, 2003 jetta tdi


THE 5 SPEED AUTOMATIC TRANSMISSION

At the bottom of the automatic gearbox (tiptronic) you will find one threaded plug on below surface, (follow red arrow in the picture below). This is for emptying.

tdisline_432.jpg



The oil level threaded plug is placed on the car front lateral automatic gearbox surface, (follow yellow arrow in the picture below).

tdisline_433.jpg

The filling oil plug is placed on the upper automatic gearbox surface, (follow green arrow in the picture below).

tdisline_434.jpg
Automatic Transmission Fluid (ATF) checking:
1. Requirements for check:
1.1. Vehicle standing on level surface.
1.2. Transmission must not be in fail-safe mode.
1.3. Shift lever in "P" position, parking brake applied.
1.4. Engine idling.
1.5. Air Conditioner and heater OFF.
1.6. ATF temperature must not exceed 104 Fahrenheit degree (40 Celsius degree) at start of test.
1.7. Automatic gearbox oil capacity: 2,5 liter. Only ATF with VW designation may be used. Do not use any lubricant additives.
1.8. Automatic Transmission Fluid ATF - part number: VW G 052 990 A2
1.9. An ATF level check when transmission oil temperature is too low results in overfilling, when too high results in underfilling.
2. CAUTION: Too much or too little ATF will affect the operation of the transmission. The ATF level must be checked at regular intervals.

Apr 10, 2011 | 2003 Volkswagen Jetta TDI

1 Answer

Checking automatic transmission fluid levels


THE 5 SPEED AUTOMATIC TRANSMISSION

At the bottom of the automatic gearbox (tiptronic) you will find one threaded plug on below surface, (follow red arrow in the picture below). This is for emptying.

tdisline_324.jpg

The oil level threaded plug is placed on the car front lateral automatic gearbox surface, (follow yellow arrow in the picture below).

tdisline_325.jpg

The filling oil plug is placed on the upper automatic gearbox surface, (follow green arrow in the picture below).

tdisline_326.jpg

Automatic Transmission Fluid (ATF) checking:
1. Requirements for check:
1.1. Vehicle standing on level surface.
1.2. Transmission must not be in fail-safe mode.
1.3. Shift lever in "P" position, parking brake applied.
1.4. Engine idling.
1.5. Air Conditioner and heater OFF.
1.6. ATF temperature must not exceed 104 Fahrenheit degree (40 Celsius degree) at start of test.
1.7. Automatic gearbox oil capacity: 2,5 liter. Only ATF with VW designation may be used. Do not use any lubricant additives.
1.8. Automatic Transmission Fluid ATF - part number: VW G 052 990 A2
1.9. An ATF level check when transmission oil temperature is too low results in overfilling, when too high results in underfilling.
2. CAUTION: Too much or too little ATF will affect the operation of the transmission. The ATF level must be checked at regular intervals.


Please do rate my response. Thanks!

Mar 06, 2011 | 2001 Volkswagen Jetta TDI

Not finding what you are looking for?
1986 Volkswagen Wagon Camper Logo

Related Topics:

199 people viewed this question

Ask a Question

Usually answered in minutes!

Top Volkswagen Experts

Colin Stickland
Colin Stickland

Level 3 Expert

22156 Answers

yadayada
yadayada

Level 3 Expert

76132 Answers

Jeff Turcotte
Jeff Turcotte

Level 3 Expert

8273 Answers

Are you a Volkswagen Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...