Question about Volkswagen Jetta

Open Question

How many fuses control glow plug circuit in volvo 850 tdi 1996

In the main fuse box just one 15 amp is present. It appears that a larger square shaped fuse is missing . Where do I find the relay? Cold starting in morning impossible. Glow plug light comes on ok and goes off ok before starting attempt.

Posted by Anonymous on

6 Suggested Answers

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.
goodluck!

Posted on Jan 02, 2017

alicantecoli
  • 22095 Answers

SOURCE: 2002 Jetta TDI has no power to glow plug buss at startup

replace the relay but check connections first as often connection get hot and corroded.failing which buy a push button switch use a relay and and some heavy wire to and from relay to the heaters and work them manually.you could try seperating the relay and cleaning the connections inside.

Posted on Nov 05, 2008

  • 2 Answers

SOURCE: Brake Lights 2003 VW TDI Golf not working???

This was a recall a couple of years ago, too.  I took it to the dealer and had it fixed for free.

Posted on Dec 04, 2008

  • 1 Answer

SOURCE: No glow plug light, car turns over but won't start, no CEL or codes

I don't have the solution but a possible help in diagnosing.  If you remove the water temperature sensor connector from the sensor, the glow plug light should stay on when you go to start the car.  Try leaving it on for 15 seconds and then start the car.  If it starts right away, it is your sensor.  If it doesn't, the good luck.  
The sensor is located on the right side of the engine near the top, at the back.  It is in the coolant fitting directly behind the hose from the rad, just left of the thermostat.  Be careful to disconnect the wires, and not remove the sensor, or you will loose a lot of coolant.  The sensor is held in by a separate plastic clip, and the harness just has a little built in clip on the side.  Hope you have small hands...

Posted on Jan 06, 2009

  • 21 Answers

SOURCE: 2004 jetta/diesel engine/hard start cold

Have you checked all of your vacuum hoses for leaks? Any vacuum leak, even intake manifold or throttle body gasket, will cause an engine stall right after starting. Likewise with a fuel pressure problem. If you aren't getting voltage, maybe whatever switch starts your glow plug cycle(either turning ignition on or opening driver door, depending on model) is defective, or any of the wiring of the circuit. It's a cheaper guess.

Posted on Feb 26, 2009

  • 119 Answers

SOURCE: volks wagen golf diesel tdi Nreg

Check the glow plug thermo sensor...found in the cylinder head.
Unlightly anything wrong with injector pump.
Good luck
John

Posted on Feb 27, 2009

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

How to find fuse boxs


FUSE PANEL LOCATION
The fuse panel is located in the engine compartment. A label on the inside of the cover lists the fuse amperage and circuits protected.
volvo 850 fuses fuse panel layout service repair manual
FUSE PANEL IDENTIFICATION
Fig. 1: Fuse Panel Identification
Courtesy of Volvo Cars of North America.
WARNING: Always disconnect battery ground cable before servicing "high-current fuses. It is recommended that "high-current" fuses be replaced by a qualified technician.
* 1 - 15 Amp
Fuel Injection, Distributor Ignition, Automatic Gearbox
* 2 - 15 Amp
Fuel Pump, Alarm System
* 3 - 10 Amp
Courtesy Lights, Oil Level Sensor
* 4 - Not Used (1993-95)
* 4 - 10 Amp (1996)
Electronic Start Inhibitor (Immobilizer)
* 5 - 30 Amp
ECC Blower (Speed 4)
* 6 - 25 Amp
Central Locking System, Alarm
* 7 - 15 Amp
Audio System (Amplifier)
* 8 - 25 Amp (1993-95)
Power Antenna, Trailer Connector
* 8 - 40 Amp (1996)
Electronic Start Inhibitor (Immobilizer)
* 9 - 30 Amp
ABS, Traction Control System
* 10 - Not Used (1993-95)
* 10 - 15 Amp (1996)
Heated Rear Seat (If Equipped)
* 11 - 30 Amp
Heated Rear Window & Side Mirrors
* 12 - 10 Amp
Brake Lights
* 13 - 15 Amp
Hazard Flashers, Headlight Flashers, Alarm
* 14 - 30 Amp
ABS, Traction Control System
* 15 - 10 Amp (1993-95)
Audio System, Courtesy Lights, Door Open Light, Trunk Light, Glove Box Light, Remote Control Central Locking System,
Oil Level Sensor, Seat Belt Reminder
* 15 - 10 Amp (1996)
Audio System, Courtesy Lights, Door Open Light, Trunk Light, Glove Box Light, Remote Control Central Locking System,
Oil Level Sensor, Seat Belt Reminder, Data Link Connector
* 16 - 30 Amp (1993-95) Accessories
* 16 - 30 Amp (1996)
Power Antenna, Trailer Connector, Accessories
* 17 - 10 Amp
Key Reminder
* 18 - 25 Amp (1993-95)
Heated Front Seats, Power Mirrors
* 18 - 15 Amp (1996) Front Fog Lamps
* 19 - 15 Amp
Left High Beam Headlight
* 20 - 15 Amp
Right High Beam Headlight, High Beam Indicator
* 21 - 15 Amp
Left Low Beam Headlight
* 22 - 15 Amp
Right Low Beam Headlight
* 23 - 10 Amp
Left Parking Light, License Light
* 24 - 10 Amp
Right Parking Light, Bulb Failure Warning Sensor
* 25 - 10 Amp
Rear Fog Lamps, Fog Lamp Indicator
* 26 - Not Used (1993-95)
* 26 - 25 Amp (1996)
Heated Front Seats, Power Mirrors
* 27 - 15 Amp
Back-Up Lights, Turn Signals
* 28 - 10 Amp
Cruise Control, Heated Rear Window, Seat Belt Reminder Light, Shiftlock, Bulb Failure Warning Sensor, Heated Rear Seat
* 29 - 15 Amp
ABS, Traction Control System
* 30 - 10 Amp
Cigarette Lighter
* 31 - 25 Amp
ECC, ECC Blower (Speeds 1-3)
* 32 - 10 Amp
Audio System, Remote Controlled Central Locking System
* 33 - 15 Amp (1993-95)
Power Seats, OBD Test Socket, Tailgate Washer/Wipe (Wagon)
* 33 - 15 Amp (1996)
Power Seats, Tailgate Washer/Wipe (Wagon)
* 34 - 25 Amp
Windshield Wiper/Washer, Horn, Headlight Washer/Wiper
* 35 - 10 Amp
Instrument Lights, Sun Roof, Traction Control System
* 36 - Not Used
* 37 - Circuit Breaker
Power Windows, Power Sun Roof
* 38 - Not Used
* 39 - Circuit Breaker
Drivers Power Seat
* 40 - Circuit Breaker
Passengers Power Seat
RELAY PANEL LOCATION
The relay panel is located at the left corner of the instrument panel.
i copied this off a volvo site Hope this helps

Oct 10, 2016 | Volvo 850 Cars & Trucks

1 Answer

1996 Volvo 850. No electrical power.


You may have a bad positive battery cable, with a digital volt meter you can test and see if you are getting 12 volts through the entire cable or at least to the cable junction block, in or by fuse relay center, then check cable from there to starter. you should also check the main, battery, power, fuses and relays, usually in the under hood relay center(fuse box)
Car Repair Maintenance How to Check if Relay Is Bad

Jan 18, 2016 | 1996 Volvo 850

1 Answer

My Rodeo blows the no. 8 'ENGINE BACK.L' fuse when the ignition is turned on. It is a 15 amp fuse & associated with the glow plugs.


Does the fuse control the relay for the glow plugs because I would think a 15a fuse would be too small for the glow plug circuit itself...

Oct 27, 2014 | Cars & Trucks

1 Answer

I have a 2000 jetta TDI 1.9L. The glow plug light is flashing off and on and the car is running terribly. Code is reading P0380/glow plug monitor circuit. what do I need to do to fix the problem?


the code is for the Glo-plugs circuit A --malfunction=== causes wiring--glow plug relay--fuse-- glow plugs---ECM. Check the relay and the fuse

Oct 31, 2013 | 2000 Volkswagen Jetta TDI

1 Answer

Driver and passenger side heated seat not operational on Volvo 850 GLE 1996


check under the seats, sometimes the plugs come undone. check the fuses, if not, then the likely culprit is a broken circuit

Sep 09, 2010 | 1996 Volvo 850

1 Answer

1996 trooper.will not heat from key .have to heat with lead from battery to heating plug


Check the fuse FL 5 50 amp square thing with a clear window on top and the relays , two in a box behind the main engine bay fusebox .
One comes on to heat the plugs and work the glow lightlight ,one comes on for afterglow once the engine is running ..

Jan 19, 2010 | 1996 Isuzu Trooper

2 Answers

Where is the fuse box


Under dash, driver side; check this documentation: 850 Fuses and Circuit Breakers

I hope helped with this (remember rated this help) Good luck.

Nov 25, 2009 | 1996 Volvo 850

3 Answers

I'am getting no power to my glow plugs on my 99VW bora is their a fuse or relay that might be the problem and if so where are they located any help appreciated


you will need to get the code to begin diagnosing. Their are several thing that can cause this and to guess sight unseen can get expensive

Nov 23, 2009 | 2002 Volkswagen Jetta TDI

4 Answers

Vw jetta 1995 2.0 fuse panel diagram,


Here is the fuse diagram you need see following text description 90-98 Golf-Jetta-Beetle Fuse Box Diagram
b04a14d.jpg



Fuse locations for options not shown can be found in the corresponding wiring diagrams.
Amp.

1 - Headlight, Low Beam, Left (56b) 10
2 - Headlight, Low Beam, Right (56b) 10
3 - License Plate Lights (5
4 - Rear Window Wiper And Washer System 15
5 - Windshield Wiper/Washer 15
6 - Fresh Air Blower, A/C (X) 20
7 - Tail Lights, Right (58R) 10
8 - Tail Lights, Left (58L) 10
9 - Rear Window Defogger 20
10 - Fog Lights 15
11 - Headlight, High Beam, Left (56a) 10
12 - Headlight, High Beam, Right (56a) 10
13 - Horn (15) 10
14 - Back-Up Lights 10
15 - Engine Electronics (15) 10
16 - Power Sunroof, Front Map/Reading Light 15
17 - Emergency Flashers (15) 10
18 - Fuel Pump (FP), Heated Oxygen Sensor (HO2S)
Control Module 20
19 - Coolant Fan, A/C Relay (30) 30
20 - Brake Lights (30) 10
21 - Interior Lights, Clock, Luggage Compartment
Light (30) 15
22 - Cigarette Lighter, Radio, Luggage Compartment
Release 10

Separate Fuses
(Located above the relays)
- Fuse for ABS hydraulic pump relay 30
- Fuse for ABS main relay 30
- Fuse for A/C 30
- Fuse for power windows 20
- Fuse for cruise control 5
- Fuse for cigarette lighter 15
In the engine compartment above the brake booster:
- Glow plugs 50
Note: The Glow plug fuse should be changed by your authorized Volkswagen dealer only.

Apr 10, 2009 | 1995 Volkswagen Jetta

1 Answer

2000 tdi wont start!!!


glow plug relay is marked #180 on the housing.
in 0 to 11 degrees they have a starting prob were the glow plugs go on and off very quickly.need VAG.com to exstend glow plug timing.
to test glow plugs disconeect ect turn key on plugs should draw 15 amps each 60 amps all together.if you dont have amp meter use test light.

Nov 24, 2008 | 2000 Volkswagen Jetta TDI

Not finding what you are looking for?
Cars & Trucks Logo

Related Topics:

66 people viewed this question

Ask a Question

Usually answered in minutes!

Top Volkswagen Experts

Colin Stickland
Colin Stickland

Level 3 Expert

22095 Answers

yadayada
yadayada

Level 3 Expert

74896 Answers

Jeff Turcotte
Jeff Turcotte

Level 3 Expert

7688 Answers

Are you a Volkswagen Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...