Question about 1994 Isuzu Trooper

1 Answer

94 isuzu trooper steering gear leaking

I can see power steering fluid pouring from the drivers side steering gear.
I have checked,i think, everywhere for a rebuild kit for this part,found one at auto zone website only to find they(or anyone else for that matter)could no longer get it.
I have found a new steering gear but it is $500 bones,allot for me right now.
Does anyone know if this particular part is shared with any other vehicles?
Perhaps I could find it that way,Thanks in advance

Posted by on

  • imaginashawn Feb 19, 2009

    Thanks millsey42,I have removed the old steering box,broke 2 pitman arm pullers,until taking it to a machine shop to get arm off,took 5 minutes/10 bucks,ordered a replacement steering gear for $50 via car-parts.com,(less than the new gasket rebuild kit).and am hoping its in the mail today.I will order gasket rebuild anyway(when money allows)and rebuild the old one if not only to yell TAKE THAT STEERING BOX!But also to understand the inner workings.
    Cheers!


×

1 Answer

  • Level 1:

    An expert who has achieved level 1.

    Corporal:

    An expert that hasĀ over 10 points.

    Mayor:

    An expert whose answer gotĀ voted for 2 times.

    Problem Solver:

    An expert who has answered 5 questions.

  • Contributor
  • 10 Answers

Youre leaking steering box is most likely an easy fix, the leak can be rectified by changing the lower shaft seal but this means removal of the pitman arm. you can remove the seal and get it matched up at any industrial supplier

Posted on Feb 19, 2009

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

2 Answers

Have a Isuzu Trooper 94 double camshaft 3.2 doc the steering wheel is very heavy to turn toward the sides. I Change the pump power and given service, but continuous heavy turning the steering wheel


does that front end jacked up too?
if yes, binding is cause. if yes, drop tie rods and find who binds.
if turns easy now, then the power steering is bad.
is the PS belt slipping?
do the pressure tests? in the book.

Oct 01, 2016 | 1994 Isuzu Trooper

1 Answer

Steering gone hard on one side on idle not so much when driving with revs


you may have a bad power steering pump i would first check the fluid and if that is ok i would have a pressure test done at the pump. you may also need to check the power steering rack.

Mar 31, 2011 | 1995 Isuzu Trooper

1 Answer

I need to fill the transmission fluid on my 94 trooper but cannot find the filler cap


Remove the transmission dipstick, get a funnel and pour it down the dipstick housing. Replace dipstick and check frequently until full. Hope this helps!

Dec 26, 2010 | 1994 Isuzu Trooper

1 Answer

Is it possible for the radiator to leak fluid into the trans causing the trans to go bad on a 2000 trooper?


If you have coolant in your transmission, I would examine the transmission cooler if it is inside the radiator. I can think of no other way that could happen outside of someone pouring coolant into the transmission fill tube.

Nov 22, 2010 | 2000 Isuzu Trooper

2 Answers

I just bought a 2002 trooper, 142k miles. Where is the transmission / power steering dip stick ?


The transmission doesn't have a dip stick you will have to take some where and have them check it, unless you feel comfortable doing it your self. The power steering on the other hand. If you pop the hood look around you should see a black cap that says powersteering fluid, when you take the cap off it should have a dip stick attached to the lid if not there will be a fluid level mark on the side of the tank, which you took the lid off of.

Oct 02, 2010 | 2002 Isuzu Trooper

2 Answers

Check trans light on....no power


My brake lights are out, the back, reverse, and head lights all work. My steering is fine as well as my brakes. But the warning lights for brake and ABS light up on my dash board

Feb 17, 2010 | 1992 Isuzu Trooper

2 Answers

Changing transmition filter


The transmission filter is located inside the transmission pan. Should take you around an hour or so to drain and drop pan replace filter and replace pan. Thanks for using FixYa!

Mar 26, 2009 | 1994 Isuzu Trooper

1 Answer

What type of trasmission fluid do you use in a 94 manual


90 weight gear lube, also u can go to ur local auto parts store and they will tell u what to use

Oct 28, 2008 | 1994 Isuzu Trooper

Not finding what you are looking for?
1994 Isuzu Trooper Logo

1,477 people viewed this question

Ask a Question

Usually answered in minutes!

Top Isuzu Experts

yadayada
yadayada

Level 3 Expert

61037 Answers

Steve Hurc
Steve Hurc

Level 3 Expert

450 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

21949 Answers

Are you an Isuzu Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...