Question about 2003 Suzuki Aerio

1 Answer

Engine PROBLEM My 2003 SX wagon keeping burning out the ignition coils, what do you think can solve this problem and my Car doesn't want to start, my wife stated that she smelled smoke and i notice ignition coils burned out, i replace them should i also replace the sparks etc., this vehicle only has 27.000 miles. please give me some feed back

Posted by on

1 Answer

  • Level 1:

    An expert who has achieved level 1.

    Corporal:

    An expert that hasĀ over 10 points.

    Mayor:

    An expert whose answer gotĀ voted for 2 times.

  • Contributor
  • 3 Answers

Some how you are getting a massive voltage surge that is frying the coils. Could be a bad ground, the coils get charged up then you lose ground and the coils can’t discharge their load so they burn out. You’re probably gonna need someone really proficient with a scan tool to trace this problem down. At $500 a pop for all new coils I’d definitely give some serious consideration to taking it to the dealer or even good auto electric shop. At the very least you need to find someone with a scan tool to pull the codes and see if there are any trouble codes listed in the computer.

Posted on Jan 22, 2009

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

Ignition coils burning up


coils come in t different voltages for two different wiring applications in cars.. Let me give you a sample . Car A ignition is 12 volts so there is a 12 volt coil fitted IT starts on 12 volts and runs on 12 volts. no problem .BUT car B ignition system is divided into 2 sections The start section is 12 volts so that the coils get maximum voltage fro starting but in the run position the circuit switches to a resisted circuit so that the coil only gets 7.5 volts . Now if you put a resisted coil in a 12volt car (A) then the coil will burn out very quickly as there is no resistance circuit to protect it. The General (GM) use a resisted wire from the ignition switch to the coil so that you have 2 wires on one terminal and one wire to the distributor. Check which coils you have been using as you will see on the bottom a note --use with resistor--. Second point if you leave the ignition on and the engine is not running then there is a current that is passing through the coil and this is an electric field and that will (like and induction heater burn up the coil

Dec 23, 2013 | 1997 Chevrolet C/K 3500

1 Answer

Po352 problem on camry, car doesn't start


DTC P0352 - Ignition Coil "B" Primary/Secondary Circuit

The DTC P0352 is, in fact, the p-code for a faulty ignition "coil-on-plug" for cylinder 2. Replacing the coil should solve the problem. It's the one closest to the front of the vehicle, and closest to the passenger's side.

Keep in touch through links sent, if you need additional details or sending PDF files on other diagnoses, tests and solutions.

Hope helps.

Oct 13, 2011 | Cars & Trucks

2 Answers

Where located fuel sensor Suzuki Ario 2003


Component location diagrams for most 2003 Suzuki Aerio cars and light trucks sold in the U.S. from 1990+.
clsk2003aeri003.gifIgnition System Components Location Diagram for 2003 Suzuki Aerio 2.0 L4 GAS
Components on diagram:
  • TP Sensor
  • Ignition Coil
  • ECM
  • MAF Sensor
  • CMP Sensor
  • clsk2003aeri007.gifElectronic Shift Control System Components Location Diagram for 2003 Suzuki Aerio 2.0 L4 GAS
    Components on diagram:
  • Data Link Connector
  • Transmission Range Sensor
  • Throttle Position Sensor
  • Pressure Control Solenoid Valve
  • Battery
  • clsk2003aeri010.gifInstrument Panel For Connector Layout Diagram Diagram for 2003 Suzuki Aerio SX 2.0 L4 GAS
    Components on diagram:
  • Clutch Switch
  • Thermistor
  • Brake Light Switch
  • Blower Motor Relay
  • Heater Fan Motor
  • clsk2003aeri011.gifInstrument Panel Harness Diagram for 2003 Suzuki Aerio SX 2.0 L4 GAS
    Components on diagram:
  • Wiper Switch
  • Washer Switch
  • Data Link Connector
  • Turn Signal Relay
  • Radio
  • clsk2003aeri015.gifHeadlight System Location Diagram for 2003 Suzuki Aerio SX 2.0 L4 GAS
    Components on diagram:
  • Headlight Relay
  • Headlight
  • Clearance Light
  • Headlight Diode
  • Clearance Light Relay
  • clsk2003aeri022.gifFuel System Components Diagram for 2003 Suzuki Aerio SX 2.0 L4 GAS
    Components on diagram:
  • Fuel Pump Relay
  • Fuel Tank Pressure Sensor
  • EVAP Canister
  • Fuel Tank Pressure Control Valve
  • Fuel Filler Cap
  • clsk2003aeri027.gifFloor For Single Unit Parts Diagram for 2003 Suzuki Aerio 2.0 L4 GAS
    Components on diagram:
  • Wheel Speed Sensor
  • ABS Control Module
  • G Sensor
  • Air Bag Control Module
  • EVAP Canister Vent Valve
  • clsk2003aeri030.gifInstrument Panel For Ground Point Diagram for 2003 Suzuki Aerio SX 2.0 L4 GAS
    Components on diagram:
  • Instrument Panel Ground Points
  • clsk2003aeri036.gifEngine Compartment For Single Unit Parts Diagram for 2003 Suzuki Aerio 2.0 L4 GAS
    Components on diagram:
  • Throttle Position Sensor
  • Horn Relay
  • Radiator Fan Control Relay
  • Cruise Control Module
  • Condenser Fan Relay
  • clsk2003aeri037.gifEngine Compartment Components Diagram for 2003 Suzuki Aerio SX 2.0 L4 GAS
    Components on diagram:
  • MAP Sensor
  • Knock Sensor
  • Noise Suppressor
  • Heated Oxygen Sensor
  • Sep 18, 2011 | 2003 Suzuki Aerio

    1 Answer

    I have a 1990 Nissan California Wagon, 1.5L 12Valve 4cyl Gas engine. I'm not too sure if it's the ignition coil, my engine cannot start on one (1) turn of the key, you need two or more or with a blip of...


    If the coil is leaking oil, replace it. I'm not saying this will fix the car, but the coil should not leak oil. It's possible a crack in the coil will cause sparks to jump to the coil terminal rather than to the spark plugs. If you want to troubleshoot, have someone try to start the car while you watch/liosten at the coil to see if the sparks are leaking out to the terminal. If yes, perhaps the coil is your only problem.

    Sep 03, 2010 | Nissan Sentra Cars & Trucks

    2 Answers

    My 2001 Passat wagon has an intermittent starting problem, engine turns over but won't catch. Dealer says to replace instrument cluster but not guaranted to fix the problem. Any suggestions appreciated.


    I have seen the ignition coil on the 4 cylinder models cause intermitant no start when wet the coil arcs causing loss of spark to the plugs this happens after hard rain falls and engine detailing are some examples.

    Jul 15, 2009 | 2000 Volkswagen Beetle

    2 Answers

    What causes to burn out one of the ignition coil of 03 bmw 325i


    replace the busted transistor in your ECU. For Bosch 30011 or 30014 you can use BU323Z transistor for replacement. it´s 100% pin-compatible and released for transistor ignition systems.

    Mar 19, 2009 | 2003 BMW 325

    4 Answers

    86 subaru gl wagon not firing.


    I have the same problem with my 86 GL 4WD. One day it started to turn, and then lost all power. I couldn't even turn on the lights. I have played with the ignition switch wires, and gotten it to fire. I think there may be a short somewhere in the switch or the wires to the harness, but I have not isolated it yet. You might check your ignition switch and wiring...

    Aug 22, 2008 | 1986 Subaru Gl 2 Door

    Not finding what you are looking for?
    2003 Suzuki Aerio Logo

    Related Topics:

    150 people viewed this question

    Ask a Question

    Usually answered in minutes!

    Top Suzuki Experts

    yadayada
    yadayada

    Level 3 Expert

    61037 Answers

    Colin Stickland
    Colin Stickland

    Level 3 Expert

    21949 Answers

    Jeff Turcotte
    Jeff Turcotte

    Level 3 Expert

    6812 Answers

    Are you a Suzuki Expert? Answer questions, earn points and help others

    Answer questions

    Manuals & User Guides

    Loading...