Question about 2003 Kia Rio

1 Answer

Can not get the oil filler nut back on the gearbox of my Kia Rio sport 1300

I topped up the transmision oil , and now I can not get the nut back in and the car also does not want to go into reverse gear .

Posted by on

1 Answer

  • Level 2:

    An expert who has achieved level 2 by getting 100 points

    MVP:

    An expert that gotĀ 5 achievements.

    Governor:

    An expert whose answer gotĀ voted for 20 times.

    Filmmaker:

    Uploaded 5 video answers.

  • Expert
  • 141 Answers

That was not the filler hole that was the reverse idler pin you may have to do a partial tear down to install the pin probably split the case at least

Posted on Dec 07, 2012

6 Suggested Answers

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.
goodluck!

Posted on Jan 02, 2017

  • 10 Answers

SOURCE: gear box oil filler plug - kia rio

you have to take off the speedometer cable/wiring harness from the top of the trans and fill it from there....one 10mm bolt...very awkward spot...it might be snug, so just take a flat head screwdriver from underneath to tap it loose...

Posted on May 14, 2010

  • 1 Answer

SOURCE: just changed the clutch in

you should replace the release bearing

Posted on May 30, 2011

alicantecoli
  • 22133 Answers

SOURCE: Gear Box Filler Foe Kia Rio. Where can I find It?

manual gearbox,,,, on casing facing wheel about half way up .with a square recessed hole for tightening /untightening

Posted on Nov 29, 2008

  • 10 Answers

SOURCE: gear box oil filler plug - kia rio 2004

you have to take off the speedometer cable/wiring harness from the top of the trans and fill it from there....one 10mm bolt...very awkward spot...it might be snug, so just take a flat head screwdriver from underneath to tap it loose...

Posted on May 14, 2010

alicantecoli
  • 22133 Answers

SOURCE: kia rio gearbox oil filler location? 1.3 2004 manual

half way-level- on front or side of gearbox,think its on the fifth gear housing behind wheel arch on this model ,round plug with a square drive in centre

Posted on Nov 29, 2008

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

Hy my inglish is not verry well i have a problem whith the gearbox of my rio 2004 it leaks oil at the ax thats conekted to the clutch and to fix it i have to split the gearbox is there a special way to...


no not really but it may be easier to buy another gearbox from scrapyard as splitting a manual gearbox is not that easy without the right tools,now what you do in this case is to remove the filler plug and then pump in with a grease gun some LM grease say about a half kilo can and what happens is the grease gets hot in driving and settles to the bottom of the gearbox sealing it up for you ,old fleet fitters trick from 40 yrs ago but it does work .cloudy and thunderstorm here in spain at the moment hence which is why iam on here and not in the garden watering my orange trees

Jul 09, 2011 | 2004 Kia Rio

Tip

How to change (check) AUDI transmission oil


Transmision oil for Audi A4 (1.8, 1.8T, 1.9 TDI):
Manual gearbox (5 speed):
- Capacity = 2,25 liters
- Specification: Gear oil SAE 75 W 90 (synthetic oil)
Part number G 052 145 S2 (1 liter)
- To check oil level, unscrew oil filler plug placed on the left side of the gearbox in front and near of transmission axle, using an Allen 17 mm key.
- Check oil level with locally manufactured tool, e.g. a piece of angled wire.
- Specification: oil level 7 mm below bottom edge of oil filler hole.
- Install oil filler plug, tightening torque = 25 Nm.

on Dec 19, 2009 | Audi A4 Cars & Trucks

2 Answers

Where is the manual gearbox oil filler plug on 2006 Hyundai Accent MC


hi from uk if memory serves ?the g/box oil level/filler plug is-- as you open the hood/bonnet in uk then look down at the gearbox on the front side behind radiator the filler plug is half way down in the center of g/box the filler is a hexagonal heade nut and the size of wrench needed is 17 or 19 mm ?? the level is correct if when you remove plug the oil is at the lower end of hole hope this helps ?

Mar 04, 2010 | 2006 Hyundai Accent

1 Answer

Change transmision oil


You don't say if it's auto or stick shift. So-

Auto. Start the engine until warm. Drive vehicle onto ramps, SECURE IT! front up, turn engine off. With engine warm, at the back of the gearbox is a drain plug (we'll deal with that first) Remove the plug and drain all oil out of the gearbox. On the bottom of an auto box there is a plate, if it is easily accessable remove the plate, taking care not to split the seal, Wipe off as much of the reidue as possible, then using a releasing oil, somthing like WD40, spray the inside of the plate and it disolves the final bit of gunk. Replace the plate, the plug, Wipe some clean oil on ALL surfaces that are touching, seals etc, and tighten. Under the hood is a dipstick, by the bulkhead, for the gearbox. Remove the dipstick, and with a funnel through the dipstick pipe, top up the gearbox with the CORRECT OIL until it touches the bottom of the stick, Start the engine and slowly, let the car run off the ramps. With the engine running, wait until up to temp, check your level again, it will have dropped, don't panic, then top up the same way until the oil is between the two marks on the dipstick.

NOW

Stick shift. the same as above up until I mention the plate. There isn't one! Remove all the oil, refit the plug. On the top of the gearbox, just off centre, is the re-fil nut. With the car on the ramp, refill with oil. The oil should have come with a flexi tube on top of the bottle, if not, use a funnel on a tube that fits into the nut hole on top of the gearbox, making sure you can access it though the engine bay to fill. Get someone to lie under the car so they can see when the oil comes out of the fill hole, that means it's full. Refit the filler plug, and reverse off ramps. There is no dipstick to check on a stick shift, you don't need it.

It sounds like a long job, but it'll take an hour tops!

Let me know how you get on, any further problembs let my know. Dave

Jul 23, 2009 | 2003 Saturn ION

1 Answer

Gear box oil filler plug - kia rio 2004


you have to take off the speedometer cable/wiring harness from the top of the trans and fill it from there....one 10mm bolt...very awkward spot...it might be snug, so just take a flat head screwdriver from underneath to tap it loose...

Dec 26, 2008 | 2002 Kia Rio

1 Answer

Gear box oil filler plug - kia rio


you have to take off the speedometer cable/wiring harness from the top of the trans and fill it from there....one 10mm bolt...very awkward spot...it might be snug, so just take a flat head screwdriver from underneath to tap it loose...

Dec 26, 2008 | 2004 Kia Rio

1 Answer

Gear Box Filler Foe Kia Rio. Where can I find It?


manual gearbox,,,, on casing facing wheel about half way up .with a square recessed hole for tightening /untightening

Nov 29, 2008 | 2002 Kia Rio

1 Answer

Kia rio gearbox oil filler location? 1.3 2004 manual


half way-level- on front or side of gearbox,think its on the fifth gear housing behind wheel arch on this model ,round plug with a square drive in centre

Oct 06, 2008 | 2002 Kia Rio

Not finding what you are looking for?
2003 Kia Rio Logo

Related Topics:

124 people viewed this question

Ask a Question

Usually answered in minutes!

Top Kia Experts

Colin Stickland
Colin Stickland

Level 3 Expert

22114 Answers

yadayada
yadayada

Level 3 Expert

75797 Answers

Jeff Turcotte
Jeff Turcotte

Level 3 Expert

8152 Answers

Are you a Kia Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...