When I down change my Chrysler Voyager 06 2.5 CDR SE I get clutch judder. It drives fine and gear changing is ok otherwise.
THROW OUT BEARING NEEDS TO BE REPLACED
SOURCE: chrysler voyager automatic transmission problem
Sounds like you have yourself a bad shift solenoid pack this is mounted on the front of the transmission under a thick rubber boot and has an 8 or 10mm bolt holding a plug into it, these usually fail hot as it is an electronically controlled solenoid and there are tiny little springs and magnets inside that can stick also while you are in there do yourself a favor and change the two speed sensors on the transmission they are about $22 each and can also cause the problem you are explaining. the shift solenoid pack is about $120 on ebay and some sellers actually sell them along with the input and output speed sensors you may try changing those first and see if it solves it but i have a feeling your solenoid pack is failing also when you change these parts it may take the computer a few trips to relearn shift points but you'll know it fixed it right off the bat.. please rate and good luck -jeff
SOURCE: Chrysler grand Voyager SE W plate 2000
The only engine that uses a timing belt in the caravan is the 2,4 and 3.0 engine which should be replaced at around 100k miles. The 3.3, 3.8. use timing chains with no service interval,
SOURCE: heating doesnt work - no hot air in chrysler grand voyager
(check water/ antifreeze level first, make sure it's full, low water can cause it not to heat properly) it could possibly be either the thermostat- fairly cheap and easy to fix, great for DIY's- if that doesn't fix it, it could be heater core.
SOURCE: chrysler voyager wont start
hi, have exactly the same problem on a 2000 2.5 tdi, have rectified it by removing first fuse at top of box. This controls central locking, stereo & interior lights so now I just have to trace fault. when you reconnect battery I hear a relay clicking from both the left & right hand sides which seems to be on the bulkhead, these relays are not releasing and are discharging the battery after 3 days. If you can live without the above try it, your odometer light will go off too.
Will post soultion when I find it. [email protected]
350 views
Usually answered in minutes!
Many thanks Jeff, This is the 2nd Voyager I have owned with this problem. The last one cost me a new clutch and was no better after a few thousand miles. How or where do I rate you.
×