Question about 2007 Chevrolet Malibu Maxx LTZ Hatchback

Open Question

How do you change the fuel sending unit on 2004 chevy malibu

Posted by Anonymous on

6 Suggested Answers

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.
goodluck!

Posted on Jan 02, 2017

  • 206 Answers

SOURCE: program a keyless enrty remote start 2004 chevy malibu

Dealer only If you find a different means let me know

Posted on Apr 08, 2009

lasvegasrich
  • 65 Answers

SOURCE: replacing spark plugs on a 2004 chevy malibu

2.2L Engine

  1. Observe the following service precautions:

    Allow the engine to cool before removing the spark plugs. Attempting to remove spark plugs from a hot engine can cause the spark plugs to seize. This can damage the cylinder head threads. Clean the spark plug recess area before removing the spark plug. Failure to do so can result in engine damage due to dirt or foreign material entering the cylinder head, or in contamination of the cylinder head threads. Contaminated threads may prevent proper seating of the new spark plug. Use only the spark plugs specified for use in the vehicle. Do not install spark plugs that are either hotter or colder than those specified for the vehicle. Installing spark plugs of another type can severely damage the engine.
  2. Turn the ignition OFF .
  3. Disconnect the Electronic Ignition (EI) module harness connector.
  4. Remove the spark plugs using a 5 / 8 inch spark plug socket.

To install:

WARNING Do not coat spark plug threads with anti-seize compound. If anti-seize compound is used and spark plugs are over-torqued, damage to the cylinder head threads may result.
  1. Inspect the gap on the new spark plugs, re-gap the plugs as required. The spark plug gap specification is 42 inch. (1.0 mm).
  2. Install the spark plugs and tighten to 15 ft. lbs. (20 Nm).
  3. Apply dielectric compound to the spark plug boots and make sure no corrosion is present.
  4. Install the ignition coil housing to cam cover and attachment bolts.
  5. Tighten the ignition coil housing bolts to 89 inch. lbs. (10 Nm).
  6. Connect the EI module harness connector. Push in until a click is heard and pull back to confirm a positive engagement.

Posted on Oct 07, 2009

Testimonial: "Thanks for the help, it was easy to change out the plugs with your info."

alicantecoli
  • 22156 Answers

SOURCE: 2004 Chevy Malibu turn signal issues

check the bulb with a test meter and alsof or a feed

Posted on Nov 25, 2009

Molson02536
  • 3854 Answers

SOURCE: where is the fuel pump located on a chevy malibu

It's located in the gas tank and to replace it, your going to have to drop the gas tank.
Thank you for using fixya and if you are going to replace the fuel pump your self. Make sure you also replace the wire harness from the frame to the fuel pump.

Posted on Jun 03, 2010

airjer995
  • 5332 Answers

SOURCE: How do you change the fuel sending unit on a Chevy

The fuel "level" sending unit is located on the side of the fuel pump module, see red arrow on picture below. The fuel tank will need to be dropped and the fuel pump module removed in order to replace the fuel level sending unit. You can expect to pay a couple hours of labor to remove the tank and replace the level sending unit.
airjer995_9.jpg

the fuel tank pressure sensor is located on top of the fuel pump module. The fuel tank will still need to be lowered to get at it but the fuel pump module does not need to be removed from the tank to replaced it.

Posted on Nov 21, 2010

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

2 Answers

Hello i have a 04 chevy malibu 4 2.2 L . MY GAS NEEDLE JUMPS FROM E TO FULL AN WHEN I PUT GAS IN IT IT WONT CRANK UP. IT TAKES 5 MIN OR SO . PLEASE HELP DON'T HAVE NO MONEY TO WASTE ON THESE SHOP


1) Check the ohms reading from the sending unit. On the fuel pump there is a sending unit that sends the signal to the gauge for the level of fuel. On most cars you can get it separate from the fuel pump. Its either the sending unit that is messed up or the cluster.
2) As for the car not starting right away, go to link below:
http://repairpal.com/no-start-due-to-failed-passlock-sensor-300
(sidebar) I'm not a mechanic, but I play one on FixYa !!!

Dec 10, 2014 | 2004 Chevrolet Chevrolet Malibu LT

1 Answer

Need to replace fuel level sending unit in an, 06' chevy malibu


The sender is in the fuel tank.Some GM vehicle's tanks are such a pain to remove that they have an access panel above it(trunk or rear seat area?) so the sender can be changed more easily.If not,you'll have to drop the tank to change it.

May 11, 2012 | 2006 Chevrolet Malibu

1 Answer

Fuel gauge drops down to low fuel even when full on my 2005 Chevy Malibu


sounds like a bad sending unit. if the check engine light is on and you get a code of p0463 then you have a bad sending unit.

Apr 03, 2011 | 2005 Chevrolet Malibu

2 Answers

How do you change the fuel sending unit on a Chevy Malibu? The unit is located, so I am told, on top of the fuel tank (not inside) where the fuel pump goes into fuel tank. Any idea how much would it cost...


The fuel "level" sending unit is located on the side of the fuel pump module, see red arrow on picture below. The fuel tank will need to be dropped and the fuel pump module removed in order to replace the fuel level sending unit. You can expect to pay a couple hours of labor to remove the tank and replace the level sending unit.
airjer995_9.jpg

the fuel tank pressure sensor is located on top of the fuel pump module. The fuel tank will still need to be lowered to get at it but the fuel pump module does not need to be removed from the tank to replaced it.

Nov 21, 2010 | 2007 Chevrolet Malibu Maxx LTZ Hatchback

2 Answers

My 2004 chevy malibu will say it has a full tank of gas then it will say it is empty and then go back and forth and so on and so on


Check the connection at the tank,and if it is secure,replace the fuel sending unit,you may have to purchase the whole fuel pump assembly to get the sending unit.

Oct 12, 2010 | 2004 Chevrolet Malibu

2 Answers

Car not getting fuel


yes the is it is a inertia switch they can get jared when driving down bumpy roads or a bump to the rear bumper that produces the "G" force required to cut the fuel off the switch is usually located in the trunk

Jun 28, 2010 | 1999 Chevrolet Malibu

1 Answer

2004 chevy malibu 2.2 driving 60 mph shut down


either you have a fuel pump that went out, or your fuel pump relay went. These fuel pumps last around 100,000 miles, so if you're way under that, it's more than likely the relay, if you're close to that, it could be either.

Jun 14, 2010 | 2004 Chevrolet Malibu

1 Answer

My 2008 chevy malibu fuel gauge dose not read only some times when its a full tank the gauge is dead but about 1/4 tank it reads but gos in and out ?


this is caused by a defective gas gage sending unit, the sending unit is part of the fuel pump module inside the gas tank, the gas tank must be removed to replace the fuel pump module that also contains the sending unit.

May 30, 2010 | 2008 Chevrolet Malibu Classic

1 Answer

Where is the oil gauge for the engine on a 2004 chevy malibu?


on the instrument cluster..... maybe you mean the sending unit for the light?? on a V6 or 4cyl. is near the bell housing above starter, front of engine, .

Oct 14, 2009 | 2004 Chevrolet Malibu

Not finding what you are looking for?
2007 Chevrolet Malibu Maxx LTZ Hatchback Logo

Related Topics:

142 people viewed this question

Ask a Question

Usually answered in minutes!

Top Chevrolet Experts

yadayada
yadayada

Level 3 Expert

75807 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

22133 Answers

Jeff Turcotte
Jeff Turcotte

Level 3 Expert

8172 Answers

Are you a Chevrolet Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...