Question about Kia Cars & Trucks

Open Question

Where is the Oil Filler on a 2004 Kia Carnival Manual Gearbox?

Where is the filler hole on a 2004 Manual Kia Carnival?

Posted by Anonymous on

6 Suggested Answers

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.
goodluck!

Posted on Jan 02, 2017

  • 10 Answers

SOURCE: gear box oil filler plug - kia rio 2004

you have to take off the speedometer cable/wiring harness from the top of the trans and fill it from there....one 10mm bolt...very awkward spot...it might be snug, so just take a flat head screwdriver from underneath to tap it loose...

Posted on May 14, 2010

alicantecoli
  • 22095 Answers

SOURCE: kia rio gearbox oil filler location? 1.3 2004 manual

half way-level- on front or side of gearbox,think its on the fifth gear housing behind wheel arch on this model ,round plug with a square drive in centre

Posted on Nov 29, 2008

budgie140
  • 501 Answers

SOURCE: manual gearbox filler

according to my book,the speedo gear,on top of g/box,is used to check oil level.pull speedo cable out,youll c the oil level marks

Posted on Jul 01, 2010

Testimonial: "yes we have found that but it is not going in and we have been told of another place wich we will find out today thanks mate"

  • 1 Answer

SOURCE: just changed the clutch in

you should replace the release bearing

Posted on May 30, 2011

bayyagg
  • 1672 Answers

SOURCE: Hi, I have read your answer

Hi,
The filler hole is on the side of the transmission, you could distinguish the hole by the screw plug.
The screw plug is sometimes a square screw or a square hole, it's near the left side axle shaft.
Hope that helped you out!

Posted on Sep 13, 2011

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

Gearbox filler hole on my kia carnival ls 2002


It is on the upper side of the gear box, a plug with a square recess hole you stick a socket extension 3/8 drive and turn with ratchet

Hope this helps Mike

Feb 04, 2016 | Kia Cars & Trucks

1 Answer

Filling gear box with oil 2000 kia carnival


Use a bottle with a long narrow spout. Fill until oil just starts to come back out of the fill hole. let oil stop dripping from filler hole before you put back the filler plug or it will be over filled.

Aug 08, 2015 | Kia Cars & Trucks

1 Answer

Can not get the oil filler nut back on the gearbox of my Kia Rio sport 1300


that was not the filler hole that was the reverse idler pin you may have to do a partial tear down to install the pin probably split the case at least

Dec 07, 2012 | 2003 Kia Rio

1 Answer

My engine is perfect but the power is not reaching the wheels, it is an automatic. Could it be gearbox or low oil in gearbox


How to check & change oil in automatic transmission on 2004 Audi A4

At the bottom of the automatic gearbox (tiptronic) you will find 2 threaded plugs on below surface. First (in front of the car) is for emptying, and second is for filling up. Tightening torque is 24 Nm.

tdisline_168.jpg


Automatic Transmission Fluid (ATF) checking:
1. Requirements for check:
1.1. Vehicle standing on level surface.
1.2. Transmission must not be in fail-safe mode.
1.3. Shift lever in "P" position, parking brake applied.
1.4. Engine idling.
1.5. Air Conditioner and heater OFF.
1.6. ATF temperature must not exceed 104 Fahrenheit degree (40 Celsius degree) at start of test.
1.7. Only ATF with designation ESSO LT 71 141 may be used. Do not use any lubricant additives.
1.8. Automatic Transmission Fluid ATF - part number: G 052 162 A2 (1 liter wrapping)
1.9. An ATF level check when transmission oil temperature is too low results in overfilling, when too high results in underfilling.
2. CAUTION: Too much or too little ATF will affect the operation of the transmission. The ATF level must be checked at regular intervals.
3. The oil level is correct if a slight amount of oil runs out when ATF temperature is between 86 Fahrenheit degree (30 Celsius degree) and 113 F deg (45 C deg) (caused by increase of oil level when heated). For warmer climates, 122 F deg (50 C deg).
4. Hang filled ATF reservoir VAG 1924 as high as possible.
5. Shift lever in "P" position, engine running at idle.
6. Place oil drip pan under transmission oil pan.
7. Remove ATF filler plug (at the bottom of the automatic gearbox you will find 2 threaded plugs on below surface. First (in front of the car) is for emptying, and second is for filling up.
8. With ATF temperature between 86 Fahrenheit degree (30 Celsius degree) and 113 F deg (45 C deg), for warmer climates, 122 F deg (50 C deg), a slight amount of oil will flow from filler hole when ATF level is correct.
9. If necessary drain or top off ATF to attain correct oil level. Top ATF with filler hook from VAG 1924 ATF reservoir. Insert VAG 1924 (tool) ATF reservoir filler hook into filler hole and top off until a slight amount of oil flows from filler hole.
NOTE: Fit filler hook into one of the oil deflector cap slots placed on the filler opening.
CAUTION: Do not press filler hook upward or oil deflector cap can be pushed off.
10. Reinstall ATF filler plug. Tightening torque is 24 Nm.


Please do rate my response. Thanks!

Jan 22, 2011 | 2004 Audi A4

2 Answers

Where is the manual gearbox oil filler plug on 2006 Hyundai Accent MC


hi from uk if memory serves ?the g/box oil level/filler plug is-- as you open the hood/bonnet in uk then look down at the gearbox on the front side behind radiator the filler plug is half way down in the center of g/box the filler is a hexagonal heade nut and the size of wrench needed is 17 or 19 mm ?? the level is correct if when you remove plug the oil is at the lower end of hole hope this helps ?

Mar 04, 2010 | 2006 Hyundai Accent

1 Answer

WHERE IS THE FILLER PLUG ON THE GEARBOX ON A 1998 PASSAT TDI PLEASE


Hi,

Just checking.... it is a manual gearbox?

You may need a special tool for the drain plug and a 17mm allen key for the filler (some use the special drain tool for the filler as well)

The drain plug is located under the diff housing.

The filler plug is located on the left (nearside) off the gearbox (look to the left of the hole and you can see the 17mm hex filler bung).

Check you can undo the filler bung, then drain the gearbox oil.

Refit drain bung and fill gearbox through filler/level ********* until gearbox oil is up to the level of the filler bung.

Refit, test drive, check for leaks and retest level again when cold.

Cheers,

"If this has helped you in any way, please rate this solution" :-)

Jan 27, 2010 | 1998 Volkswagen Passat

1 Answer

Gear Box Filler Foe Kia Rio. Where can I find It?


manual gearbox,,,, on casing facing wheel about half way up .with a square recessed hole for tightening /untightening

Nov 29, 2008 | 2002 Kia Rio

1 Answer

Kia rio gearbox oil filler location? 1.3 2004 manual


half way-level- on front or side of gearbox,think its on the fifth gear housing behind wheel arch on this model ,round plug with a square drive in centre

Oct 06, 2008 | 2002 Kia Rio

Not finding what you are looking for?
Cars & Trucks Logo

Related Topics:

296 people viewed this question

Ask a Question

Usually answered in minutes!

Top Kia Experts

Colin Stickland
Colin Stickland

Level 3 Expert

22095 Answers

yadayada
yadayada

Level 3 Expert

74945 Answers

Jeff Turcotte
Jeff Turcotte

Level 3 Expert

7697 Answers

Are you a Kia Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...