Question about 2002 Dodge Caravan

Open Question

2002 grand caravan oil pan gasket leaking - 2002 Dodge Caravan

Posted by Anonymous on

Ad

6 Suggested Answers

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.
goodluck!

Posted on Jan 02, 2017

Ad
  • 1596 Answers

SOURCE: change oil pan gasket

This Is A Fairly SIMPLE Procedure The IMPORTANT Thing is To Use Generous Amount of Sealant and Allow Plenty of TIME for Sealant to CURE After Pan is On and Tightened Over Night At Liest


REMOVAL

  1. Disconnect negative cable from battery and remove engine oil dipstick.
  2. Raise vehicle on hoist and drain engine oil.
  3. Remove bending brace to transaxle attaching bolt.
  4. Remove bolts attaching dust cover to transaxle housing. Lower dust cover to gain access to oil pan bolts.
  5. Remove oil pan screws and remove oil pan.
INSTALLATION
  1. Clean surfaces and apply a 1/8 inch bead of Mopar(R) Silicone Rubber Adhesive Sealant or equivalent, at the parting line of the chain case cover and the rear seal retainer.
    1. Use a new pan gasket.
    2. Install pan and tighten screws to 12 Nm (105 in. lbs.).
    3. Install dust shield and bending brace to transaxle housing.
    4. Lower vehicle and install oil dipstick.
    5. Connect negative cable to battery.
    6. Fill crankcase with oil to proper level.
Happy Motoring and Have A Great Day . Also Please Dont Forget to RATE Me Thank You Very Much,rejakwilson

Posted on Feb 04, 2009

Ad
  • 1 Answer

SOURCE: replace valve cover gasket

I have the same problem on a 2003 Town & Country. The cover for the front 3 cylinders is quite straight forward, but in order to do the rear cylinders I believe you are going to have to remove the cowling below the windshield. You will need a gear puller to remover the windshield wipers first, then remove the cowling. Than should give you more room to work. It's still not going to be easy, but it sure beats paying hundreds of $$$$ in labor charges.

Posted on May 04, 2009

c17hydro
  • 2984 Answers

SOURCE: What is the sequence for the bolts on oil pan, for

For the 2.8L there is no sequence. Torque for the bolts are 105 in.lbs.

For the 3.0L torque is 50 in.lbs. in sequence:




40be0ec.gif

30fedd0.gif
For the 3.3L and the 3.8L, no sequence but torque each bolt to 105 in.lbs.

Please don't forget to rate!

Posted on Jul 12, 2009

  • 109 Answers

SOURCE: Oil pan gasket change on 2000 dodge grand caravan

TO answer all your questions, the red oring is for the oil pump pickup tube, one bolt will fix that, RTV sealet is used in the seperation seams at the timing cover and rear seal retainer, 1/6th thick bead, 1/4" wide at seams, has for the trans inspection cover remove it for the repair, 5 bolts will do that part, and rear bracket, then the pan is ready to come off... GOOD LUCK RDJRP

Posted on Aug 07, 2009

  • 149 Answers

SOURCE: 2002 dodge grand caravan fuse box

The fuse box is located under the hood. There is component map printed on the inside of the cover. This tells you on your model where the fuse or relay is located

Posted on Jan 19, 2010

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

Leaking car and smoking while idling after driven


If smoke comming from tail pipe then the valve seals r leaking if from under the hood then the valve pan seals r leaking on to the exost manafold and thebpil is then burrning off if tail pipe then it means motor work if under the hood then just replace the gaskets for the valve pans and the leaking/smoking should stop

Jan 04, 2014 | 2002 Dodge Grand Caravan

1 Answer

Oil leaking around oil pan


most of the time when a oil pan leaks, its a oil pan gasket. between engine and the pan. unless theres a hole in the pan. check the gasket! good-day !

Sep 19, 2011 | 2000 Dodge Caravan

1 Answer

99 dodge caravan 3.3lt leaking transmission fluid out of a rusty side pan. How difficult to replace/fix


even if you bought a new trans pan gasket it will still leak this is a easy repair get a new gasket and silicone (gasket making silicone) use bothe gasket and silicone that the only way you will stop a leaking pan gasket and yes its simple

Jun 08, 2011 | 1999 Dodge Grand Caravan

2 Answers

I have a 2000 Ponitac Grand Am but the motor in the car is a 2002. I have had the car for a couple of days and now the oil is leaking rather bad, now I am no car expert but my husband and I were thinking...


u might check that the oil filter gasket did not slip when it was put on and have the oil running down over the pan . this car is not known to have oil leak problems.if i am thinking right it has a 3.4 liter and they are known (like there cousin the 3.1 )to leak anti-freeze from the intake gasket.

Nov 12, 2010 | 2002 Pontiac Grand Am

1 Answer

Oil pump ,,,where is the oil pump located on a 1997 dodge caravan


Hello
Welcome!
Oil pump is located on the oil pan.
Parts needed,,,oil,,,, oil filter,,,, oil pan gasket,,, oil pump,,,, oil pump pickup tube..
time to do this,, about 3 hours
Instructions,
Raise van place on 2 jack stands
drain oil remove oil filter fill new filter install.
remove bolts from oil pan,
remove oil pan..
remove 2 bolts that hold oil pump and tube.

install new pump and tube tork bolts to 45 fp
replace oil pan gasket and install oil pan
tork pan bolts to 35" pounds
install drain plug
fill with oil
start and check for leaks

let me know if i can help more

Jul 17, 2010 | 1997 Dodge Caravan

1 Answer

How to change oil pan gasket for 2005 dodge caravan


Caravan, Grand Voyager, Town and Country, Voyager, 2000-2004

Oil Pan - Removal & Installation

2.4L Engine
  1. Before servicing the vehicle, refer to the Precautions Section.
  2. Drain the engine oil.
  3. Remove or disconnect the following:
    Negative battery cable Structural collar A/C compressor bracket to oil pan bolt Oil pan
  4. Clean the oil pan and all gasket mating surfaces.
To install:
  1. Install or connect the following:
    Oil pan gasket to the block after applying engine RTV at the oil pump parting line Oil pan. Torque the bolts to 105 inch lbs. (12 Nm). Structural collar Negative battery cable
  2. Fill the crankcase to the correct level.
  3. Start the engine, check for leaks and repair if necessary.

3.0L Engine
  1. Before servicing the vehicle, refer to the Precautions Section.
  2. Drain the engine oil.
  3. Remove or disconnect the following:
    Negative battery cable Starter motor Front motor mount bracket Bending braces Torque converter dust shield Oil pan

    e6c7cfd.jpg
    Fig. Oil pan mounting bolt tightening sequence-3.0L engine

To install:
  1. Clean the oil pan all mating surfaces.
  2. Apply RTV gasket material to the oil pan.
  3. Install or connect the following:
    Oil pan. Tighten the bolts in sequence to 50 inch lbs. (6 Nm). Torque converter dust shield Bending braces Front motor mount bracket Starter motor Negative battery cable
  4. Fill the crankcase to the correct level.
  5. Start the engine, check for leaks and repair if necessary.

3.3L & 3.8L Engines
  1. Before servicing the vehicle, refer to the Precautions Section.
  2. Drain the engine oil.
  3. Remove or disconnect the following:
    Negative battery cable Engine oil dipstick Drive belt splash shield Strut to transaxle attaching bolt and loosen the strut to engine attaching bolts Transaxle case cover Oil pan fasteners Oil pan and gasket

To install:
  1. Clean the oil pan and all mating surfaces.
  2. Apply a 1 / 8 inch bead of gasket material at the parting line of the chain case cover and the real seal retainer.
  3. Install or connect the following:
    New gasket on the oil pan Oil pan. Torque the bolts to 105 inch lbs. (12 Nm). Transaxle case cover All bending brace bolts Drive belt splash shield Engine oil dipstick Negative battery cable
  4. Fill the crankcase to the correct level.
  5. Start the engine, check for leaks and repair if necessary.

Hope helps (remember rated this).

Jun 24, 2010 | 2005 Dodge Caravan

1 Answer

Bad oil leak around oil pan, does somebody have an engine diagram for the Dodge 3.0 in this Grand Caravan?


This is what I found on my 1998 with a 3.0 motor Most likely you have a rusted pan with a hole on the passenger side of pan, clean the oil pan real good and inspect it real good and check for small leaks,
Also the transmission pan is also known to rust through on the left side top and bottom, Salt and brime plays heck on all pans and brake lines

Sep 30, 2009 | 1996 Dodge Grand Caravan

2 Answers

Have a serious oil leak.


the 3.0 liter engine was known to walk out cam shaft seals. there are covers over the camshaft gears that can be removed and you should be able to see if the seal has came out

Jan 31, 2009 | 2000 Dodge Caravan

Not finding what you are looking for?
2002 Dodge Caravan Logo

Related Topics:

163 people viewed this question

Ask a Question

Usually answered in minutes!

Top Dodge Experts

yadayada
yadayada

Level 3 Expert

76164 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

22156 Answers

Jeff Turcotte
Jeff Turcotte

Level 3 Expert

8273 Answers

Are you a Dodge Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...