Question about Cars & Trucks

Open Question

How much does it cost to replace fuel pump in ford falcon 1999 model

Posted by Anonymous on

5 Suggested Answers

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.
goodluck!

Posted on Jan 02, 2017

emissionwiz
  • 75817 Answers

SOURCE: 1999 ford contour fuel pump removal

YOU will need the car on a hoist, doing it on the ground is almost impossiable, disconnect the filler neck at top, remove the straps, lower tank slow and disconnect wiring and fuel hoses, you need a special tool to remove the gas line retainer clips.

Posted on Jul 28, 2008

fordfixer
  • 58 Answers

SOURCE: 1999 ford ranger fuel pump needs replaced.

Hello!

REMOVAL

WARNING:

  • DO NOT SMOKE OR CARRY LIGHTED TOBACCO OR OPEN FLAME OF ANY TYPE WHEN WORKING ON OR NEAR ANY FUEL-RELATED COMPONENT. HIGHLY FLAMMABLE MIXTURES ARE ALWAYS PRESENT AND MAY BE IGNITED, RESULTING IN POSSIBLE PERSONAL INJURY.
  • FUEL IN THE FUEL SYSTEM REMAINS UNDER HIGH PRESSURE EVEN WHEN THE ENGINE IS NOT RUNNING. BEFORE REPAIRING OR DISCONNECTING ANY OF THE FUEL LINES OR FUEL SYSTEM COMPONENTS, THE FUEL SYSTEM PRESSURE MUST BE RELIEVED TO PREVENT ACCIDENTAL SPRAYING OF FUEL, CAUSING PERSONAL INJURY OR A FIRE HAZARD.
  1. Disconnect the battery.
  2. Relieve the system pressure.
  3. Raise the vehicle.
  4. Drain the fuel tank.

cc999cb.gif
  1. Disconnect the fill pipe hoses.
    • Loosen fill pipe hose clamps.
    • Disconnect fill pipe hoses from the fuel tank.

f3fcce3.gif
  1. Remove the 4 bolts (2 each side) and remove the skid plate if equipped.
  2. Support the fuel tank.

918ba9a.gif
  1. Remove the bolts and pivot the fuel tank support straps away from the fuel tank.

e19f38e.gif
  1. Disconnect the fuel pump connector.
    • Lower the fuel tank slightly. Disconnect the fuel pump connector.


958d5a3.gif
Disconnect the fuel supply line push-connect fitting and the vapor tube fitting at the fuel pump


80378e1.gif
  1. Disconnect the vapor line fitting at the rear of the fuel tank.
  2. Lower the fuel tank.

62ccbfd.gif
To install, reverse the removal procedure


df22959.gif Special Tool(s)

REMOVAL

  1. Clean the area around the fuel pump mounting flange.



b28c7f0.gif
  1. Using the special tool, remove the fuel tank pump assembly locking retainer ring.
  2. Remove the fuel pump assembly. CAUTION: The fuel pump assembly must be removed and handled carefully to avoid damage to the float arm and filter.
  3. Remove and discard the fuel pump mounting gasket.
INSTALLATION
  1. Clean the fuel pump mounting flange and the fuel tank mounting surface.
  2. Apply a light coat of Premium Long Life Grease XG-1-C or -K or equivalent meeting Ford specification ESA-M1C75-B to the gasket to hold it in position during assembly. Install the fuel pump mounting gasket.

4976d12.gif
  1. Using the special tool, tighten the fuel pump assembly locking retainer ring.

Posted on Mar 02, 2010

  • 2 Answers

SOURCE: could you tell me where the fuel pump is located

in the tank. easiest way to access is remove the tray

Posted on Nov 19, 2010

tiffany_horn
  • 1 Answer

SOURCE: 1999 ford ranger fuel pump needs replaced.

Would it be easier to just take off the bed?

Posted on Oct 07, 2012

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

How do i remove and reinstall the distributor on ford falcon 4.0 1999 model


First make absolutely sure #1 cylinder is at top dead and the timing mark on the crank pulley is lined up. Pop off the distributor cap and check to see if the rotor is pointing to the #1 spark plug wire. Loosen the bolt that holds the clamp at the base of the distributor. Move it aside or remove it them pull up on the distributor and move it out.

Aug 30, 2016 | 1999 Ford Falcon

1 Answer

My 2005 Ford falcon takes a while to kick over when I turn the ignition on. What's the deal?


Could be a host of things starting with your fuel pump to a relay. Engine light on?

Feb 26, 2016 | 2005 Ford Falcon

1 Answer

AU Falcon turn over no fuel pump no start could it be the transponder in key


Check fuel cut-off switch if fuel pump is not turning on and you have checked the fuses.

May 20, 2014 | Ford Falcon Cars & Trucks

2 Answers

Ford Falcon auto Gli - car loses power and misses when accelerating


It is being happened for bad fuel filter. You can check it out. I have bought Ford since 5 years.
Source : Mechanic Shop Tempe

Nov 28, 2012 | Cars & Trucks

1 Answer

Fuel pump in 98 el ford falcon v6 not working, have squirted fuel down breather nd car starts then dies, dont sound like fuel pump working, have cleaned contacts to pump, still not working, seems like it...


not sure on falcon but on many ford models they use a plastic impeller in the fuel pump .. that works fine until you run out of gas .. that could be just rounding a corner with the gas low ... once the pump runs dry the impeller is damaged quickly and you have just lost an expensive fuel pump .. if the pump jambs then it will likely blow the fuel pump fuse ...you can check with a voltmeter to see if you are getting power back there .. if so and it still doesn't work then start looking for a new pump ..its not a safe job changing the pump in some models .. really hard if the tank is full ..

Feb 22, 2010 | 1992 Ford LTD

2 Answers

Ford falcon el. wont start. raa checked has spark & pulse, where is the fuel line under the hood


Most older cars have a mechanical fuel pump mounted to the side of the engine. Usually turns from the Cam or Crankshaft. i would check under the Valve Cover area. should be a small pump that is mechanically driven by the engine. probably half the size of your fist. Trace the fuel line from the carb to it. most oder cars have this set-up. I hope this helps you out. Never worked on a Ford Falcon. My 74 dodge B100 had that as well as my 78 Lemans. Good Luck!

Jun 04, 2009 | Ford F Cars & Trucks

2 Answers

Fuel pump on 1998 Explorer


I had one replaced on a 1999 Ford Explorer and it cost was Labor / Parts $884.

Sep 24, 2008 | 1998 Ford Explorer

Not finding what you are looking for?
Cars & Trucks Logo

Related Topics:

146 people viewed this question

Ask a Question

Usually answered in minutes!

Top Cars & Trucks Experts

yadayada
yadayada

Level 3 Expert

75817 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

22156 Answers

Randy Ohler

Level 3 Expert

14585 Answers

Are you a Car and Truck Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...