Question about 1999 Volkswagen Jetta

1 Answer

Cracked Radiator How do you remove a radiator from a 1999 VW Jetta SR6

Posted by on

1 Answer

  • Level 2:

    An expert who has achieved level 2 by getting 100 points

    All-Star:

    An expert that got 10 achievements.

    MVP:

    An expert that got 5 achievements.

    Vice President:

    An expert whose answer got voted for 100 times.

  • Expert
  • 345 Answers

Remove front bumper,then front panel,then aircon condensor(if fitted with ac)then radiator

Posted on Dec 29, 2008

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

How do i fix the fan relay in a 1999 vw jetta?


Most likely requires radiator fan module

Sep 26, 2014 | 1999 Volkswagen Jetta

2 Answers

1999 VW Jetta, it overheats even after I replaced the thermostat and the plastic housing on the drivers side of the engine (it was cracked). I let it run with the res. tank open because I thought it might...


With the symptoms you describe, coolant is not circulating through the system. Your first move to replace the thermostat was good. My next move would be to replace the water pump. Good luck.

Apr 03, 2011 | 1999 Volkswagen Jetta

1 Answer

Have a small leak in the cooling system of my 1999 VW Jetta 4 cylinder 2.0l, and was advised to use Bar's Stop leak. It is suggested, after calling Bar's, to add it directly to the radiator, not the...


that stuff is only a quick fix, pressure test it and fix the leak other wise run the engine so the thermostat opens then just pour it in the reserviour tank if thats what your radiator directly feeds off then take it for a big drive. good luck.

Feb 01, 2011 | 1999 Volkswagen Jetta

1 Answer

HOW TO REPLACE A RADIATOR ON A 1999 VW JETTA


The procedure to replace radiator on 1999 VW Jetta is as follows:--- **Locate and remove the drain plug on the bottom of the radiator, and let the engine coolant drain into a resealable container. Then unplug the electrical connectors from the coolant fan and thermal switch.
**Then carefully detach the release lever holding the front bumper, and take off the radiator grille. Remove all bolts holding the front bumper and take off the bumper. Disconnect the temperature sensor connector and if necessary remove the spoiler.
**: Unhook the quick release couplings holding the coolant hoses to the radiator. Removing the screws securing the headlights and disconnect the headlights. If your Jetta is equipped with A/C, unfasten the A/C mounting bolts and the condenser bracket bolt on the left of the radiator.
**: Remove the radiator mounting bolts and slide the radiator and fan by sliding them downward. Don't disconnect any refrigerant lines, if your Jetta has an air conditioning unit.
**: Take the retaining clamps off the refrigerant lines and remove the bolts securing the refrigerant line from the side of the radiator. Be very careful that no hoses or lines are stretched or bent. Swing the radiator down and remove it from the vehicle.
**: Replace the radiator and replace and reconnect all engine and electrical components and the fender and bumper in the reverse order.
**: Then carefully fill the radiator with a mixture of half distilled water and half engine coolant. Start the vehicle and let it run for few minutes with the radiator cap off, in order to bleed air from the lines. Check the fluid level and top it off if necessary, then put on the radiator cap.
------Its done.

Thanks. keep updated for any more query.you can rate this solution and show your appreciation.

Sep 22, 2010 | Volkswagen Jetta Cars & Trucks

1 Answer

How do you replace radiator fan motor on 1996 VW Vento (Jetta)


You will need to unbolt the 4 bolts holding the fan shroud to the radiator, usually 10mm bolts. Unplug the fan and remove any relays or anything attached to the shroud. Removing the battery may give you a little more room to get the shroud out. Remove the fan from the motor and unbolt the motor from the shroud.

Dec 20, 2009 | 1996 Volkswagen Jetta

1 Answer

99 VW Jetta is overheating. Where is the thermostat located?


FOLLOW RADIATOR TOP HOSE TO CONNECTION ON BLOCK THE THERMOSTAT IS LOCATED INSIDE HOUSING

Oct 04, 2009 | 1999 Volkswagen Jetta

1 Answer

2002 VW Jetta Radiator Problem


Many older cars (yours is 10 years old ) just needs the raditor changed. Flush the heater and the motor good as you'll stopp the new raditor. The owers manual says flush every year some owners never do it !

Aug 21, 2009 | 2003 Volkswagen Jetta TDI

1 Answer

I have a 2003 VW jetta tdi


You've lost engine coolant somewhere, and need to fill the engine back up with the VW special G12 coolant.

Then find the leak, which will be in one or more of the following places -
Water hoses to heater core, including any other coolant carrying hoses in the engine compartment
Radiator hoses
Plastic manifold bolted to side of engine which is known to leak (have replaced on an '01 VW Beetle, and an '02 Jetta, both members of our family in the past few years.).
Overflow reservoir cracked
Radiator leak.

Reply back what you find. If the engine got too hot, you may need to have the thermostat replaced.


Feb 03, 2009 | 2003 Volkswagen Jetta TDI

1 Answer

1991 and 1997 VW Jetta Radiator??


massive size difference get the proper one or you will be overheating next

Jan 02, 2009 | 1997 Volkswagen Jetta

2 Answers

1999 VW New Beetle Coolant Temp Sensor


at the back of the cylinder head gearbox end it sits in the water pipe

Dec 20, 2008 | 1999 Volkswagen New Jetta

Not finding what you are looking for?
Cars & Trucks Logo

Related Topics:

150 people viewed this question

Ask a Question

Usually answered in minutes!

Top Volkswagen Experts

Colin Stickland
Colin Stickland

Level 3 Expert

21949 Answers

yadayada
yadayada

Level 3 Expert

60769 Answers

Jeff Turcotte
Jeff Turcotte

Level 3 Expert

6811 Answers

Are you a Volkswagen Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...