Question about 1989 Volvo 240

1 Answer

I need to know the steps for uninstalling, and reinstalling the alternator on a 1989 Volvo 240 DL.

Posted by on

1 Answer

  • Level 2:

    An expert who has achieved level 2 by getting 100 points

    MVP:

    An expert that gotĀ 5 achievements.

    Governor:

    An expert whose answer gotĀ voted for 20 times.

    Scholar:

    An expert who has written 20 answers of more than 400 characters.

  • Expert
  • 99 Answers

Steps

1. Disconnect the battery
2 Loosen botls so you can remove the drive belt to alternator.
3. If it has a serpertine belt, then pry with proper tool on the tensioner to remove the belt.
4. Disconnect harness to alternator and ground wire if any and filter condenser if any.
5. Loosen bolts to alternator and remove alternator.
6. If AC equipped, not knowing your belt configuration would require to loosen the AC Belt also, depending if your alternator belts is the first one near the engine, then all belts have to be loosen to remove it. unless #3 applies.
Reverse the steps to put it back on.

Posted on Dec 26, 2008

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

1982 Volvo 240 DL


To start engine needs air, compression, ignition, fuel.

Start checking the various areas.

Aug 23, 2016 | 1982 Volvo 240 Series

1 Answer

What size battery does my 1989 volvo 240 DL take? I need to replace it and cannot research the cost until I know what size


Just call a couple parts stores and get prices, the cheapest battery is rarely the best deal and they can dispose of the old one for you. They will know what size you need. Also if you have a warranty need in the future they are open seven days a week.

Jan 12, 2011 | 1989 Volvo 240

1 Answer

1990 240 dl Volvo wagon, have to put fully charged battery, then when the battery is discharges the car dies, alternator ? Voltage regulator ?


sounds as though you have a bad alternator or a loose alternator belt and the battery is not being charged. while the car is running - check the voltage from the alternator and make sure it is about 13.4 volts DC.

c...

Jan 03, 2011 | 1990 Volvo 240

1 Answer

1989 volvo 240 DL wagon firing order



87862010.gif

D24 and D24T diesel enginesEngine Firing Order: 1-5-3-6-2-4

Oct 23, 2010 | 1989 Volvo 240

1 Answer

I was wondering where the fuel filter is located in a 1989 Volvo 240 DL station wagon


Check the left front fender area under the hood. If it is not there, it will be located under the car, right wheel area.

May 23, 2010 | 1989 Volvo 240

1 Answer

:::Volvo;1989 240 DL 2.3 liter automatic transmition:::


Fuel pump relay,controls the power to the system,its an small wt box mounted under dash on P/S foot well.

Jun 20, 2009 | 1989 Volvo 240

1 Answer

Rotor replacing on a 240DL


The rotor has a very strong spring. just keep pulling. Be careful not to bend the shaft (I doubt that could happen). If you get a screwdriver or something to pry with, just try to force it straight up.

Mar 24, 2009 | 1989 Volvo 240

1 Answer

Alternator ground wire location for 1988 240 DL


check the ground to the alternator...clean up any rust & the alternator belt may need to be tightened... also make sure to use only bosch or volvo parts!!!

Mar 08, 2009 | 1991 Volvo 240

Not finding what you are looking for?
Cars & Trucks Logo

Related Topics:

261 people viewed this question

Ask a Question

Usually answered in minutes!

Top Volvo Experts

yadayada
yadayada

Level 3 Expert

61249 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

21949 Answers

Mark Jones

Level 2 Expert

76 Answers

Are you a Volvo Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...