Question about 2004 Pontiac Grand Am

1 Answer

Thermostat location where can i find the thermostat on 2004 pontiac grand am.please help me find it.

Posted by on

1 Answer

  • Level 1:

    An expert who has achieved level 1.

    MVP:

    An expert that gotĀ 5 achievements.

    Governor:

    An expert whose answer gotĀ voted for 20 times.

    Hot-Shot:

    An expert who has answered 20 questions.

  • Contributor
  • 31 Answers

On a GM six clinder it is in the housing that the upper radiator hose is hooked on the upper intake. It is very difficult to remove with the exhaust cross over pipe in the way but is possible with some time.

Posted on Dec 23, 2008

5 Suggested Answers

blueextc3221
  • 15935 Answers

SOURCE: Where is the thermostat located on a pontiac grand

3.4L Engine

  1. Drain the cooling system.
  2. Remove the air cleaner.
  3. Remove exhaust crossover pipe.
  4. Disconnect the surge tank line fitting from the coolant outlet.
  5. Remove the thermostat housing to intake manifold bolts.
  6. Remove the thermostat housing outlet and thermostat
  7. Clean the mating surfaces.

To install:
  1. Install the thermostat and housing outlet.
  2. Install the thermostat housing bolts. Tighten the thermostat housing bolts to 18 ft. lbs. (25 Nm).
  3. Install exhaust crossover pipe.
  4. Connect the surge tank line fitting to the coolant outlet. Tighten the fittings to 15 ft. lbs. (21 Nm).
  5. Install the air cleaner.
  6. Fill the cooling system.
  7. Inspect the system for leaks.

Thanks for using FixYa - a 4 THUMBS rating is appreciated for answering your FREE question.

Posted on Nov 23, 2009

  • 71 Answers

SOURCE: where is the thermostat located in a 2004 pontiac

Sorry for being slow to respond,really bad cold.The thermostat is right under the throttle body.If you follow the upper hose from the radiator to the engine you have found the t-stat housing.It IS possible to change the t-stat without removing the exhaust pipe but you must be willing to fiddle around due to limited access.

Posted on Apr 12, 2010

  • 5 Answers

SOURCE: location of thermostat for a 2004 pontiac grand am.

follow the upper rad. hose from the rad. to the other end. It should be under the throttle body. I'm a certified Master Tec and these are not easy to do.

Posted on Dec 23, 2008

litoshop
  • 298 Answers

SOURCE: Where is the horn located on A 2004 Pontiac Grand

behind right fender

Posted on Jul 09, 2009

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.
goodluck!

Posted on Jan 02, 2017

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

Where is the engine coolant temp sensor located on a 2004 grand prix gt


On the 3.8 liter the coolant temp sensor is right below the the thermostat in the intake manifold on the drivers side of the engine.

The thermostat is under the housing that is bolted to the intake plenum that the upper hose is attached to.

Jan 18, 2012 | 2004 Pontiac Grand Prix

4 Answers

I need the location of the coolant sensor on a 2004 pontiac grand am 6 cylinder


It's here on the thermostat housing. Please let me know if you have more questions.

jturcotte_409.gif

Dec 07, 2010 | 2004 Pontiac Grand Am

1 Answer

Im not getting any heat to come out my vents, going to be in 20's....cold ride! Should be a recall on this 2004 pontiac grande prix. What can I do?


If engine temp is warm, then either your heater core is clogged and needs flushed or your warm /cold door motor is not working properly(located under the dash). if you engine si not getting warm you have a bad thermostat.


Please take a moment and rate my answer..........Thanks

Dec 01, 2010 | 2004 Pontiac Grand Prix

1 Answer

Thermostat for 2004 grand am 4 cylinder


The thermostat is located under the housing on the engine where the top rad hose connectes to...Hope this helps.

Oct 12, 2010 | 2004 Pontiac Grand Am

1 Answer

Where is the thermostat located for 2004 grand am se 6v is it hard to take out and put in. is it a electronic or electric thermostat also


The thrmostat is mechanical, follow the top radiator hose to the engine where it connects and that cover get unbolted its under it.

Apr 18, 2010 | 2004 Pontiac Grand Am

2 Answers

Where is the thermostat located in a 2004 pontiac grand am and how do i fix it?


Sorry for being slow to respond,really bad cold.The thermostat is right under the throttle body.If you follow the upper hose from the radiator to the engine you have found the t-stat housing.It IS possible to change the t-stat without removing the exhaust pipe but you must be willing to fiddle around due to limited access.

Apr 09, 2010 | 2004 Pontiac Grand Am

1 Answer

How to change the thermostat on a 3.4L engine for the 2004 Pontiac Grand Am GT


You have to locate the big hose that comes off the radiator and follow it to where it goes into the the engine block. There will be 4 bolts on the flanged housing. The thermostat is in that housing.

Mar 09, 2010 | 2004 Pontiac Grand Am

1 Answer

Where is the thermostat located on a v6 pontiac grand am


thermostat is located below throttle body where upper rad hose connects..housing has 3 bolts..a little tricky to get at..behind exhaust crossover pipe

Apr 27, 2009 | 2004 Pontiac Grand Am

1 Answer

Location of thermostat for a 2004 pontiac grand am.


follow the upper rad. hose from the rad. to the other end. It should be under the throttle body. I'm a certified Master Tec and these are not easy to do.

Dec 23, 2008 | 2004 Pontiac Grand Am

Not finding what you are looking for?
2004 Pontiac Grand Am Logo

810 people viewed this question

Ask a Question

Usually answered in minutes!

Top Pontiac Experts

yadayada
yadayada

Level 3 Expert

64286 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

21990 Answers

Jeff Turcotte
Jeff Turcotte

Level 3 Expert

6812 Answers

Are you a Pontiac Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...