Question about 2001 Chevrolet Silverado 2500HD

1 Answer

Chevrolet 2500 Not Running, May Be Fuel Filter Sensor

Need help starting my 2002 Chevrolet 2500? Duramax Diesel 2002 Chevrolet 2500 Started the truck this morning, ran for two minutes then died. Has power, turns over and is not giving me any computer codes. No dead fuses either. A red wire ontop the fuel filter had come undone so I plugged back in. Still won't run. I primed the and drained the fuel filter a couple times and it is getting fuel. I have a feeling that the truck won't run because of something to do with the Fuel Filter sensor, an ideas? I have same problem with 2001 chevy diesel ran for two min. then quit,wont start. has been showing fuel leakage code when pulling a load or even turning on the air conditioning , before this happen the other night but always reset it self. now not showing any codes ..HELP

Posted by on

  • Don Borges Mar 29, 2009

    From one day to the next. Just turns over but no signs of life. the day before I was driving for 6 hours with no problems. Bleed filter and no air. plenty of fuel and all the wires are fine including all fuses.

  • Anonymous Mar 14, 2014

    suddenly stopped running while driving. It turns over but won't start again

×

1 Answer

  • Level 2:

    An expert who has achieved level 2 by getting 100 points

    MVP:

    An expert that gotĀ 5 achievements.

    Governor:

    An expert whose answer gotĀ voted for 20 times.

    Hot-Shot:

    An expert who has answered 20 questions.

  • Expert
  • 99 Answers

If it dont have good compression it will not start check the comp and make sure there no water in oil if fuel pressure is low it will not pop the injector open try some starting fluid

Posted on Jan 26, 2009

2 Suggested Answers

  • 57 Answers

SOURCE: Chevrolet 2500 Not Running, May Be Fuel Filter Sensor

That red wire is only for the fuel heater.will not cause a no start.try pumping the primer pump on top of the fuel flter hsg. but first open the bleed screw,which is black plastic also located on the top.this will eliminate any trapped air that might have entered the fuel intake system.if the pump does not get firmer and harder to push, then you have a leak in the fuel supply lines or the ck valves in the fuel filter hsg or stuck open. Still no start have it scanned to ck fuel pressure while cranking.it should be close to 5000 lbs

Posted on May 14, 2008

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.
goodluck!

Posted on Jan 02, 2017

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

2005 Duramax stopped running.replaced fuel filter and sensor,no luck cam you help.


After replacing the fuel filter did you prime the system? There should be a small circular pump on top of the filter assembly to prime it. I own a 2003 Duramax and it usually takes about 5 pumps / turn over / 5 more pumps / turn over / and 5 more and you should get it started. It will take longer if you didn't fill the fuel filter with diesel before installing it as well. Let me know. Thanks.

Sep 11, 2012 | Cars & Trucks

2 Answers

2002 chevy 6.6 duramax wont start even in warm weather or after motor is warm..... only starts with starting fluid. codes are p0335/p0193/poo87/p0090


The Duramax fuel filter assembly is bad about sucking air. Replace the fuel filter assembly. It comes with a new fuel filter.
I need some good feedback.

Oct 09, 2011 | 2002 Chevrolet Silverado 2500HD

1 Answer

My 2500 duramax diesel dosent want to start


Does it have diesel?
Could be fuel filter or fuel pump.
Glow plugs?
Injectors? these trucks have been known to have bad injectors.
Possibly the oil pump, the injectors run off the oil pump.

Sep 23, 2011 | 2003 Chevrolet Silverado 2500HD

1 Answer

2002 duramax diesel that seems to be starving for fuel. replaced the fuel filter and no help. The fuel lines are colapsing at the fuel filter.


try to replace the fuel pump. possibly cause might be you replaced your filter a little to late, that some dirt already entered your pump. also, try to clean the fuel lines itself.

Aug 06, 2011 | Chevrolet 2500 Cars & Trucks

1 Answer

2002 chev. duramax starts fine when temp. out side


whens the last time you changed the fuel filter? ther maybe to much water in the filter and the tank, on warmer days the fuel maybe trying to seprate in the filter, when you go to start it you maybe trying to run it on water more then diesel. add a cetien booster to the tank of fuel you have see if that helps

Sep 21, 2009 | 2002 Chevrolet Silverado 2500HD

1 Answer

2001, Duramax Deisel 6.6 won't "restart"


fuel pump is obviouslynot working !
check it & its wiring!!!!!

Jul 20, 2009 | 2003 Chevrolet Silverado 2500HD

1 Answer

2004 chev 2500 duramax diesel no start and no fuel pressure


primay fuel pump is defective and won't allow the secondary pump to build pressure and causes it to die and has lack of power, most likely it started getting gutless before it happened.

Jun 17, 2009 | 2003 Chevrolet Silverado 2500HD

5 Answers

2003 gmc sierra duramax 2500


Problem with Diesel Fuel System. Gmc 2002 duramax 2500 HD 4x4 will start 

Apr 19, 2009 | 2003 GMC Sierra

1 Answer

Chevrolet 2500 Not Running, May Be Fuel Filter Sensor


That red wire is only for the fuel heater.will not cause a no start.try pumping the primer pump on top of the fuel flter hsg. but first open the bleed screw,which is black plastic also located on the top.this will eliminate any trapped air that might have entered the fuel intake system.if the pump does not get firmer and harder to push, then you have a leak in the fuel supply lines or the ck valves in the fuel filter hsg or stuck open. Still no start have it scanned to ck fuel pressure while cranking.it should be close to 5000 lbs

May 14, 2008 | 2003 Chevrolet Suburban 2500

Not finding what you are looking for?
Cars & Trucks Logo

1,071 people viewed this question

Ask a Question

Usually answered in minutes!

Top Chevrolet Experts

yadayada
yadayada

Level 3 Expert

70346 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

22041 Answers

Jeff Turcotte
Jeff Turcotte

Level 3 Expert

6864 Answers

Are you a Chevrolet Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...