Question about 2002 Chrysler Voyager

1 Answer

2.5 voyager crd on 52 plate

Hi my car is blowing back through an injector , exhaust fumes it seems , can I just replace some seels ?

Posted by on

1 Answer

  • Level 1:

    An expert who has achieved level 1.

    Corporal:

    An expert that hasĀ over 10 points.

    Mayor:

    An expert whose answer gotĀ voted for 2 times.

  • Contributor
  • 3 Answers

Hi there, you will need to remove the injector and replace the copper seal on the base of the injector. You do this by de-pressurising the fuels rail, ie, loosen the metal pipe attached to the injector, fuel will spill till all pressure has gone. remove the metal pipe and the multiplug connector too, remove the clamp and bolt holding the injector in place. Gently twist the metal part of the injector body and with an upwards motion remove it from the bore. Clean the bore thoroughly and use a vacuum to remove the carbon as you scrape it away. Once happy everything is clean, replace the copper washer and refit the injector in reverse order as for removal. You will have a sealed injector and no blowing will be heard.

Hope this helps

Cliff

Posted on Jan 17, 2009

1 Suggested Answer

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.
goodluck!

Posted on Jan 02, 2017

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

Heater only blowing cold air 2002 chrysler grand voyager 2.5 crd


check and see if the a/c compressor is running,if it is unplug it and see if you get heat,or it could be a heater actuator stuck or bad........good luck

Feb 11, 2013 | 2003 Chrysler Voyager

2 Answers

Smoke from a side pipe


Leaking exhaust pipes and deflated radiator can be the result of this. Better start with the radiator first and check if its deflated. Also make sure the pipes are tightly mounted and double check any leak.

Oct 04, 2008 | 2002 Chrysler Voyager

2 Answers

Chrysler voyager 2.8 crd 2006 wont start without pumping the fuel primer replaced fuel filter and housing . checked in tank no primer pump found ?


Even though your vehicle starts and runs but dies, Your fuel pressure doesnt seem to be pushing enough pressure. It could be a faulty fuel pressure regulator.

Nov 23, 2010 | 2004 Chrysler Voyager

1 Answer

Car fumes merc e class cdi replaced fuel injectors engine has been cleaned down fumes still there effects the mouth throat constant headache driving me mad


Get the exhaust checked, if it is leaking the exhaust gas'es will be coming in the car. most garages can check an exhaust for you.

Hope this helps

regards
dan

Jan 25, 2010 | 2005 Mercedes-Benz E-Class

1 Answer

How to remove injectors


Take the bolts out of the fuel rail and lift the fuel rail off the injectors then remove injectors

May 19, 2009 | 2002 Chrysler Voyager

1 Answer

2.5 voyager crd on 52 plate


get a local mechanic to have a look ,sounds like a big fat northerner has owned this car and squashed the elements in the seat.replace the rear electric motor in the door for the window .and radio code should be in the cars books if not you will have to remove and post chassis number of radio and make so this poofty southerner can generate a code for you

Jan 17, 2009 | 2002 Chrysler Voyager

1 Answer

2.5 voyager crd on 52 plate Not starting


petrol or diesel ??,,factory immobiliser ???could very well be ,only need to leave key in pocket with a mobile phone and its a non starter .shouldnt cost more than 200€ to reset the key ,tried the spare key??

Jan 17, 2009 | 2002 Chrysler Voyager

2 Answers

2002 Chrysler Voyager 02 sensor


From under vehicle, follow exhaust down from engine, eventually you'll see a piece about 3-4" long sticking out side of the exhaust with wire(s) going to it.

Oct 29, 2008 | 2001 Chrysler Voyager

Not finding what you are looking for?
2002 Chrysler Voyager Logo

Related Topics:

309 people viewed this question

Ask a Question

Usually answered in minutes!

Top Chrysler Experts

yadayada
yadayada

Level 3 Expert

71288 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

22059 Answers

Jeff Turcotte
Jeff Turcotte

Level 3 Expert

7009 Answers

Are you a Chrysler Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...