Question about 2003 Mercury Sable

1 Answer

2003 Mercury Sable sedan

Blend door stuck. Is there a way to remove and replace without removing the dash. I would cut thru the plastic below dash and repair if I new where the door was located

Posted by on

1 Answer

  • Level 1:

    An expert who has achieved level 1.

    Corporal:

    An expert that hasĀ over 10 points.

    Mayor:

    An expert whose answer gotĀ voted for 2 times.

    Problem Solver:

    An expert who has answered 5 questions.

  • Contributor
  • 18 Answers

No, not really. Even if you could hack your way to it's approximate location, there's way too much involved with no room to do anything for you to have any success. You can't just say "okay, there it is" because you can see it, and fix it

Posted on Nov 16, 2008

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

How do i fix my ac so it will blow throuhg the vents


Most common reason is a faulty blend door under the dash.
The blend doors direct air thru the vents and also control temp.
You may need a shop manual to diagnose the actual problem and repair it.

Aug 06, 2015 | 2001 Mercury Sable

2 Answers

2003 mercury sable blows cool air when heater is turned on.


Most likely it is a clogged heater core. Have your heater core reverse flushed or your blend door is stuck open.

Oct 10, 2014 | 2003 Mercury Sable

1 Answer

2003 mercury sable heater blows hot air out dash but when transfered to floor or defroster it blows out cold air tryed flushing system but didnt help ...any advice Confused


Not in the coolant system, you flushed

It is a failed HVAC Blend Door Motor, under the dash

The fact you have heat or A/C, but not in all 5 positions
or combinations, should have told you, the air flow is not
switching as it should

Oct 05, 2014 | 2003 Mercury Sable

1 Answer

Heat blows even with ac on


Usually a problem with a blend door under the dash. The blend doors direct air thru the heater core and out the vents.

Jan 25, 2013 | 2001 Mercury Sable

1 Answer

I hear a click click click then a pause then click click click again when I go to start my 2008 mercury sable the clicking starts when the accessories are activated right before the motor turns over it...


This noise is indeed coming from the dash and it is caused by a part called the air temperature control blend door actuator motor. The noise is a tiny electric gear drive that moves the door and controls air temperature jumping teeth due to a defective sticking blend door inside the air ducting. To replace these parts requires the dash be removed from the car, a 12-14 hour job.

Jul 03, 2012 | 2008 Mercury Sable

2 Answers

2003 mercury grand marquis LS heater does notr blow hot air, blower blows but cold air comes what is the problem


The blend door is stuck in cold position. That usually happens because the blend door actuator has failed.

You will need to test and replace the blend door actuator.

To replace the actuator you will need to take apart the dash and remove completely the instrument panel,d isconnect the connector, remove the four screws, remove the temperature blend door actuator and replace it.

The replacement is not a job for beginners, since you have to take apart the dash to access the actuator.

Regards.


Nov 18, 2009 | Mercury Grand Marquis Cars & Trucks

1 Answer

Heater air flap stuck


My 01 sables blend door gets stuck I have learned that if you disconnect the battery for 5-10 minutes and reconnect the battery the blend door starts working again. It sounds crazy but it works

Jun 22, 2009 | 2001 Mercury Sable

1 Answer

Ac problem with 1999 mercury sable


most likely a broken blend door or blend door motor, the dash has to come out to replace this.hope this helps and good luck.

May 24, 2009 | 1999 Mercury Sable

3 Answers

2002 mercury sable heater wont get hot


you have a broken or stuck temp blend door in the heater case. or the servo motor is broken. this sits on top of the heater case

Dec 02, 2008 | 2001 Mercury Sable

Not finding what you are looking for?
2003 Mercury Sable Logo

265 people viewed this question

Ask a Question

Usually answered in minutes!

Top Mercury Experts

yadayada
yadayada

Level 3 Expert

61249 Answers

Fordexpert

Level 3 Expert

5331 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

21949 Answers

Are you a Mercury Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...