Question about Mercedes-Benz E350

5 Answers

Heater blower on sprinter van not working ,i need to locate the problem point .has been going off intermitently for some time

Posted by on

  • 2 more comments 
  • rita789 Dec 08, 2008

    I have the same problem. Intermittent.

  • jrichmay Dec 18, 2008

    my heater fan on my sprinter van works very intermitently

  • stev3535 Jan 26, 2009

    i have the same problem ,,, the blower will work when i wiggle the wireing plug on the motor ,,, but will not stay on ,,,,

  • mark morgan
    mark morgan Jan 18, 2012

    hi blower brush worn female pited replace blower take off small cover one screw then the glove comepartment push in the two tabs now it open all the way three screw then slide it two the right to pop it out one screw right bottom l screw on blower turn to the right put grease on new one go in smood .20 min job parts at parts geek llc

×

5 Answers

  • Level 1:

    An expert who has achieved level 1.
    Mayor:

    An expert whose answer got voted for 2 times.

  • Contributor
  • 1 Answer

Email this guy at sales@bargainworlduk.com he sells the carbon brushes new at only 5.99 a pair! Its fantastic and they work a treat. Why pay £300 when it will cost 5.99 to buy a new set of carbon brushes!!

Posted on Jun 29, 2010

  • Level 1:

    An expert who has achieved level 1.
    Corporal:

    An expert that has over 10 points.
    Mayor:

    An expert whose answer got voted for 2 times.
    Problem Solver:

    An expert who has answered 5 questions.

  • Contributor
  • 7 Answers

Check the heater blower motor brushes.

These are very common problems on Sprinters and Vito vans.

The brushes can be replaced and can be bought on ebay for £12.50. Changing them is a 30 min job.

Posted on Feb 25, 2010

  • Jerry Hartley Mar 02, 2012

    I have 2005 vito 115 lwb I see the motor can be accessed by removing the plastic tray above it on the dash getting the heater resistor dropping plug (5 pin black) and its assembly( 2 black lugs hold assy into fan sqirrell cage cooling fins) this can be sent away for repair or replacement.
    Can you replace the brushes without removing blower motor I think the 2 pin white plug goes to the brush housing on top center section motor and housing is held in by 2 torque screws Is that correct ?????

×

  • Level 1:

    An expert who has achieved level 1.

  • Contributor
  • 1 Answer

Hi there, just wondered wether any of you guys had the same issues or had heard about then with your vw lt28 or similar model van.
also i think same as the mercedes sprinter ?
anyway ours is on a 51 plate ( but is a 02 model )
issues we have :
heater blower and demister doesnt work , although it will on occaission ( checked fuse )
drivers side headlamp main beam doesnt work ? ( changed bulb and checked fuse )
parking light dont work ( not bothered about it though )

anyone shed anylight how to fix and stuff
all the best
richard
nottinghamshire

Posted on Jul 15, 2010

  • akn833 Dec 19, 2010

    90% of the time the wiring on the motor has corroded put the heaters on and play around with the wire which is located under the hood on the right hand side top part you will see a big black box it has a 2 pin plug if that is the problem it is very simple to mend the wire

×

mark morgan
  • Level 1:

    An expert who has achieved level 1.

  • Contributor
  • 2 Answers

Replace its baby

Posted on Jan 18, 2012

  • Level 1:

    An expert who has achieved level 1.

  • Contributor
  • 1 Answer

I have the same problem. Intermittent.-

Posted on Dec 14, 2009

1 Suggested Answer

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.
goodluck!

6ya.com

Download 6ya

6ya.com

Need repair answers fast Use 6ya to...

Posted on Jan 02, 2017

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

Blower motor only runs on low for 2006 sprinter van
If your blower runs at low speed at the highest speed setting, it is more likely to be the motor rather than the resistor array. If it runs at low speed setting only then it is likely to be the resistor array.

Apr 07, 2013 | 2006 Dodge Sprinter

1 Answer

Heater blower not working at all? switch lights up to full but nothing working 58 plate sprinter van 112000mls
blower not working[ richycarpets ] i had to order a new one got it in two days 68.00 easy to put in 10min.

Aug 18, 2011 | 2010 Mercedes-Benz Sprinter

2 Answers

1996 astro chevy van heater use to work on low and med but wont work at all now.
The blower resistor has gone bad which is why you lost blower speeds.This may have been caused by the blower motor drawing too much power. At this point I would verify that no fuses burned out and then check the pigtail plugs going to the resistor and blower motor to make sure the connectors and connections are not melted or wiring is frayed. These connectors are located in the engine compartment on the passenger side. After checking this and if everything appears ok then the blower motor itself has probably gone bad and needs replaced. I would also replace the blower motor resistor as well. If the connectors appear damaged replace or repair as needed .

Jan 10, 2011 | 1995 Chevrolet Astro

1 Answer

Blowers not working on my sprinter 313 52 plate they work with a direct 12v so motor fine and brushes are new
Does the blower work on full speed only? if so then it is the resistor, which is located in the heater box.

Nov 14, 2010 | 2010 Mercedes-Benz Sprinter

1 Answer

Cannot locate the cord for the block heater on 2010 mercedes sprinter van
The new 3.0L doesnt have a block heater.. Not with Dodge anyway.. you can
buy an in-line heater that splices into the lower radiator hose and will heat up the coolant.. you could also program your auxillary heater to come on before you get up in the morning.. should be in your manual.. let me know if that helps?

Jan 31, 2010 | 2006 Dodge Sprinter

1 Answer

1999 windstar, rear heater was only blowing on med/high no stoppe
be prepared to renew both the blower motor and blower resistor. if it were just a bad resistor it should work on hi-speed only. make sure you have power to the motor when on hi speed. bad blower motors will kill the resistor. follow the water tubes from under the drivers side of van to the point where they enter the van, that is where unit would be located on the inside. be prepared to remove some seats and wall covers.

Dec 22, 2009 | 1998 Ford Windstar

6 Answers

Mercedes sprinter 308 cdi mwb van heater blower not working and have tested all fuses
hi got an r reg mercedes sprinter van mwb got no heat on the heater just blowing cold?

Dec 02, 2009 | 2000 Mercedes-Benz S-Class

1 Answer

Heat/ac blower motor works on high. intermittent on other speeds.
Check the blower resistor pack - usually located in the heater air ducting in the blower fan airflow. Check for loose connections and open circuit resistors on the unit.
If speed 4 works always, its unlikely to be the blower motor ground connection.

Aug 10, 2009 | 2004 GMC Canyon

1 Answer

No heat in heater of sprinter van
your termastat is gon get a new one

Jan 26, 2009 | 2004 Dodge Sprinter

1 Answer

02 Blazer. Heater worked intermitly.. now not at all
The blower lives under the dash on the pass side Look for 12v on the large purple wire with the heater on..also run 12v to the blower to confirm it works. If no 12v check the blower relay in the power dist center under the hood. Also the 30a fuse to it .....look for melting etc...tap on the relay...from this point you need some expertise. Ill help if you want

Nov 22, 2008 | 1995 Chevrolet S-10 CA Edition

Not finding what you are looking for?

View Most Popular

Cars & Trucks

Related Question

Blower motor only runs on low for 2006 sprinter van

  • 2006 Dodge Sprinter

Open Questions:

0 Answers

Where are the high and low ports for a/c on 1983 380sel

Jun 26, 2017 | Mercedes-Benz Cars & Trucks

0 Answers

mercedes benz 2007 radio code unlock -vin wdc2030422r260505

Jun 23, 2017 | Mercedes-Benz Cars & Trucks

0 Answers

i have 2010 mercedes benz c180 it starts well after some kilometers it cuts as if no fuel then I stopped and re-start it goes well and cuts again only wen it is loaded when I am alone its fine help

Jun 23, 2017 | Mercedes-Benz C-Class Cars & Trucks

0 Answers

need a diagram of to top of the trunk fuse box for 03 mercedes e320

Jun 20, 2017 | Mercedes-Benz E320 Cars & Trucks

Cars & Trucks Logo

Related Topics:

4,049 people viewed this question

Ask a Question

Usually answered in minutes!

Popular Questions

Mercedes-Benz E350 Cars &...

2007 Mercedes-Benz E350 4Matic...

2007 Mercedes-Benz E350 4Matic...

2007 Mercedes-Benz E350 4Matic...

2007 Mercedes-Benz E350 4Matic...

Check Out the Latest Top Trucks Report!
Check Out the Latest Top Trucks Report!

View all Fixya Reports

Top Mercedes-Benz Experts

Colin Stickland
Colin Stickland

Level 3 Expert

22059 Answers

yadayada
yadayada

Level 3 Expert

71288 Answers

Michael Contreras
Michael Contreras

Level 2 Expert

166 Answers

Are you a Mercedes-Benz Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...