Question about Cars & Trucks

Open Question

Case 580L Cold start issue

I have a Case 580 Super L with a diesel engine. This machine starts and runs fine when the weather is warm or if it is stored inside. When the machine stays outside in the cold weather it will start, run for maybe 20 - 30 seconds shut down and will not restart. I also have a Case 590 super L and it starts every time. It seems that if I bleed the injection system at the injectors and hit it with either, it will start but again die shortly. i have checked the lines going to the primer pump, the pump itself, and all seems OK. Why would this seem to run out of fuel only when cold? Where should I check next, I was leaning maybe towards the injector pump timing. The shutoff solonoid has been replaced already and still the same. Any info would be appreciated, Thanks, jon

Posted by on

6 Suggested Answers

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.
goodluck!

Posted on Jan 02, 2017

godspeed808
  • 125 Answers

SOURCE: olds alero 2.4 idle fuel pressure

most likely idle air control sensor or low engine coolant I know sounds funny but IAC uses coolant to regulate idle. Idle air control valve or throttle body positioning sensor.

Posted on Feb 26, 2009

  • 625 Answers

SOURCE: cold start valve problem

if you have an electric cold start valve make sure to unplug it and if keeps apling fuel with electrical conector unpluged that means the valve is not good, but if not then you have an electronic problem, possible a bad cold start sensor or cold start module or cicuit problem, and might be a time to take it to an electrical shop

Posted on Jun 17, 2008

  • 74 Answers

SOURCE: 1998 Chevy tahoe Hard to start when cold

replace your MAP sensor(manifold absolute pressure) the map sensor is the computer for your fuel pressure regulator telling how much pressure. Unless your tahoe runs like **** going up hill than it inevitably your fuel pump

Posted on Feb 17, 2009

wracefans24
  • 1985 Answers

SOURCE: 2000 ford super duty 7.3 diesel will not cold start

you need to have the engine coolant switch checked,since the computer relies solely on sensors,the ect tells the computer how cold or hot it is so the computer will make it a rich or lean mixture to start the engine,if it tells the computer that it is 75 degrees the computer will lean the mixture like starting a car in the winter without a choke.

Posted on Jan 06, 2010

  • 1 Answer

SOURCE: dodge cummins won't start, fuel reaching injector pump but no fuel coming out of injector pump.

i have a 2001 dodge cummins 1 ton won t start i have feul to the injector pump and to the injectors but won t start need help

Posted on Sep 05, 2010

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

Starter problems


It's diesel. Diesel engines do not like cold, but that is normal. I am going to assume this engine has a start delay in cold weather to allow for Glow Plugs to warm up the cylinders before actually turning over the engine. I don't know about TDI's specifically, but I think a TDI Mech at your local Volkswagen dealer could confirm my assumption. They may call the parts something different, but the function will be the same. Sounds like normal operation for a diesel engine in cold weather...obviously, this would be why the engine always turns over immediately in warm weather...no need for the Glow Plugs to warm the cylinders. Best of luck resolving this problem.

Dec 06, 2013 | 2003 Volkswagen Beetle TDI

2 Answers

High rev at cold (winter cold!) idle


Your toyota technician should know what a "cold starting solenoid" is. It is the little thing that works your throttle until the motor warms up and something else takes over. I'd suggest going to another technician.

Nov 28, 2013 | 2003 Toyota Corolla

1 Answer

I have a 2001 Super Duty Diesel 7.3 Starts and runs fine for about 1 and a half min the cuts off and will restart then does the same thing again...no codes comming up on code reader. Any help would be...


My first thought might be a faulty thermostat, which regulates cold cycles and warm cycles in the engine. If the thermostat is faulty and the unable to switch to a warm loop after the engine warms up, it causes the engine to run much less efficiently. Whether or not it will cause the car to completely turn off, I'm not certain, but this might be one thing to mention to a mechanic.

Dec 06, 2012 | 2001 Ford F250 Super Duty Super Cab

1 Answer

98 astro awd doesnt like to start in real cold weather (-18C) otherwise runs fine


I have a 98 and we just had a cold snap where it was super cold and I didn't start it for about a week. I had just got a new battery because mine tested out bad. Everything was good but now it doesn't want to get fuel. Cleaned all battery and relay connections and it's turning over great and fires with starting fluid but won't start. Guy at Napa said the fuel pump on these are known to not work well in the cold and suggested to warm the tank. I'm parked outside and can't move it to get it inside somewhere. Anyone know of good solution to this fuel pump not working in cold temps issue?

Nov 20, 2011 | 1998 Chevrolet Astro

2 Answers

2000 ford super duty 7.3 diesel will not cold start


you need to have the engine coolant switch checked,since the computer relies solely on sensors,the ect tells the computer how cold or hot it is so the computer will make it a rich or lean mixture to start the engine,if it tells the computer that it is 75 degrees the computer will lean the mixture like starting a car in the winter without a choke.

Jan 06, 2010 | 2000 Ford F350 Super Duty Super Cab

1 Answer

F250 Diesel engine won't start in cold weather


check your glow plug relay! located on the right side head

Dec 27, 2009 | 2003 Ford F250 Super Duty Crew Cab

1 Answer

I have a 1999 Ford F450 super duty diesel. It


Replace the glowplug relay.Its faulty.The glow plugs stay on until engine warms up.The engine temp switch then activates the relay to switch off.So it could be the temp switch also faulty.

Jul 17, 2009 | 1999 Ford Super Duty F 450

2 Answers

2.8 Diesel Pajero Cold start


Have replaced your glow plugs?They dont cost alot to replace,try this

Jun 22, 2009 | 2002 Toyota Land Cruiser

1 Answer

Starting in damp weather 1993 240 wagon, auto/od, 235k miles


perhaps you need a new cap and roter a new spark plug wire set. they don;t like moisture. also check to see if you have any broken or leaking vacuum hoses. the worse case senerio would be that your head gasket is leaking--at cold temps a little antifreeze will enter until everything warms up and it seals shut due to metal expanding. but since you say it's cold weather only--this probably wou;dn't be the case. good luck.

Dec 27, 2008 | 1993 Volvo 240

3 Answers

Volks jetta deisel 1997 won't start


DEPENDING HOW COLD OUT IT IS DIESELS DONT LIKE TO START IN COLD WHEATHER UNLESS THE GLOW PLUGS ARE WARM THIS IS THE REASON FOR PLUGGING DIESELS IN MOST WONT START IF ITS COLD OUT IF ITS NOT THAT COLD OUT IT SHOULD START IF YOU HAVE ENOUGH BATTERY POWER MAYBE THERES NOT ENOUGH FUEL GETTING UP TO THE THROTTLE BODY HOPE THIS HELPS

Oct 23, 2008 | 1997 Volkswagen Jetta

Not finding what you are looking for?
Cars & Trucks Logo

Related Topics:

162 people viewed this question

Ask a Question

Usually answered in minutes!

Top Cars & Trucks Experts

yadayada
yadayada

Level 3 Expert

74896 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

22095 Answers

Randy Ohler

Level 3 Expert

14585 Answers

Are you a Car and Truck Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...