Question about 2002 Mazda Millenia

Open Question

Install a fuel pressure regulator in a mazda millenia s

Posted by Anonymous on

6 Suggested Answers

6ya6ya
  • 2 Answers

SOURCE: I have freestanding Series 8 dishwasher. Lately during the filling cycle water hammer is occurring. How can this be resolved

Hi,
a 6ya expert can help you resolve that issue over the phone in a minute or two.
best thing about this new service is that you are never placed on hold and get to talk to real repairmen in the US.
the service is completely free and covers almost anything you can think of (from cars to computers, handyman, and even drones).
click here to download the app (for users in the US for now) and get all the help you need.
goodluck!

Posted on Jan 02, 2017

  • 21 Answers

SOURCE: i want to know how

Fuel filter is located in the trunk.

1. Relieve fuel pressure
First start up the car in PARK. Open up the hood and pull the Fuel Pump Relay. It looks like a big green fuse. Do this as the car runs. Do not worry the car will stale. Crank engine a few times and turn off ignition switch. Put the relay back in. Disconnect negative battery cable.

2. Reach filter.
This is annoying unless you can fit comfortably in the trunk. Pull out the carpet cover and you will see a metal cover screwed down by 3 screws. Remove these and you will see the fuel filter.

3. Replace
Lay down some shop towels underneith the hoses connected at both ends of the filter as fuel will spill out. What I did was place forceps on each hose to minimize spillage. This is also why we releive fuel pressure so it doesn;t spray in your face. Hoses may be stuck onto filter so I took a very small flathead screwdriver and wedge it between the the hose and the filter nozzels so it will free itself from the filter. Becarful as the fuel filter is filled with fuel. Replace filter and follow your steps back.

Posted on Jul 31, 2008

  • 1 Answer

SOURCE: fuel filter on a 1996 Mazda Millenia

The fuel filter is accessable from inside the trunk. remove the trunk carpet mat. You will notice a circular panel on the left side which is held to the trunk floor with two screws. remove the screws and panel and you will immediately see the fuel filter. When replacing the fuel filter, note the direction of fuel flow and Do Not Install The New Fuel Filter Backwards!

Posted on Dec 21, 2008

SOURCE: 95 mazda millenia won't start

check out if you have any form of security installed,or change the brain box,that is it

Posted on Dec 23, 2008

emissionwiz
  • 75807 Answers

SOURCE: Location under hood for fuel pump relay on 2002 Mazda Millenia S

JUST RELEASE THE PRESSURE AT THE FUEL PRESSURE TEST PORT ON THE FUEL SUPPLY RAIL THAT SUPPLIES THE INJECTORS, IT IS A METAL VALVE LIKE A TIRE VALVE, THAT IS THE FACTORY RECOMMENDED METHOD..

Posted on Mar 11, 2009

  • 750 Answers

SOURCE: my hold light is flashing in my 2001 mazda millenia

hold light flashing means you have a transmission fault of some kind, check vehicle speed sensor

Posted on Jul 03, 2009

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

No fuel presure mazda b3000 v-6


check operation of fuel pump. Check that there is sufficient fuel in the tank. Check for blocked filter. Check the pressure regulator on the fuel manifold.

Nov 30, 2013 | 2002 Mazda Millenia

1 Answer

2000 mazda millenia seems to be getting fuel but was told not getting enough and car wont start


have a fuel pressure test done. Run fault codes and look for a can purge valve/ solenoid fault.

Apr 26, 2013 | 2000 Mazda Millenia

1 Answer

2002 mazda millenia fuel pressure relay location


you are looking for the fuel pressure regulator.what motor do you have ? the 4 cylinder or the 6 cylinder. if the 6 cylinder it is at the end of the fuel rail next to the throttle body

Jan 28, 2013 | Cars & Trucks

1 Answer

Car won't start...


CHECK THE FUEL PRESSURE REGULATOR BY REMOVING VACUUM LINE AND LOOK FOR FUEL.

Nov 02, 2012 | 2001 Mazda Millenia

1 Answer

I have a 97 millenia that runs but will not go I have replaced the fuel pump but still no luck


I would check the fuel pressure with a gauge next. The filter could be stopped up or the fuel pressure regulator could be faulty.
Is the check engine light on and have you checked the computer for trouble codes ?

Sep 09, 2012 | 1997 Mazda Millenia

1 Answer

How do I check the fuel pressure on a 2000 model mazda millenia with a 2.3 engine in it


Hi.

You connect a fuel pressure gauge like this to the pressure rail. Pressure in this car must be between 35 and 45 psi. If pressure is too low look for kinked fuel lines and eventually replace the pump. If the pressure drops down more than 10 psi in five minutes or if the pressure is considerably higher than that replace the fuel pressure regulator. Below the parts that may need testing:

ginko_261.gif

1. Fuel tank
2. Shut-off valve
3. Non-return valve
4. Fuel pump
5. Fuel pump (Transfer)
6. Fuel filter (High-pressure)
7. Injector
8. Pressure regulator
9. PRC solenoid valve
10. Fuel pump relay
11. Fuel pump resistor and relay (KJ model)

Aug 04, 2011 | 2000 Mazda Millenia

1 Answer

How do you replace a 2001 Mazda 626 Fuel Filter


Fuel Filter On all models except the Millenia, the fuel filter is attached to a bracket located in the left rear of the engine compartment, next to or beneath the brake master cylinder fluid reservoir. On the Millenia, the fuel filter is located beneath an access cover in the trunk. Access to the cover is achieved by removing the trunk mat to expose the cover.
---
REMOVAL & INSTALLATION Except Millenia
  1. Before servicing the vehicle, refer to the precautions in the beginning of this section.
  2. Properly relieve the fuel system pressure.
  3. Remove or disconnect the following:
    • Negative battery cable Fig. 1: Exploded view of a common fuel filter and related components 7923mg68.gif

    • Air intake hose and/or filter housing, if necessary
    • Fuel line clamps, if equipped
    • Fuel lines from the filter and plug the openings
    • Filter clamp bolt/nut by loosening them.
    • Fuel filter from its mounting bracket
    NOTE: Note the direction of the flow arrow on the filter so the replacement filter can be installed in the correct position. To install:
  4. Install or connect the following:
    • Fuel filter in its mounting bracket, making sure the flow arrow is pointing in the proper direction
    • Fuel lines to the fuel filter
    • Fuel line clamps, if equipped
    • Air intake hose and/or filter housing, if removed
    • Negative battery cable
  5. Pressurize the fuel system and check all connections for leaks.
Millenia
  1. Before servicing the vehicle, refer to the precautions in the beginning of this section.
  2. Insure the ignition switch is OFF.
  3. Relieve the fuel system pressure.
  4. Remove or disconnect the following:
    • Negative battery cable
    • Trunk mat
    • Service hole cover
    • Fuel lines from both ends of the fuel filter
    • Fuel filter and bracket
    • Fuel filter from the mounting bracket.
    To install:
  5. Install or connect the following:
    • Filter in the bracket. Tighten the nut to 70-95 inch lbs. (8-11 Nm).
    • Fuel lines to the filter
    • Service hole cover
    • Trunk mat
    • Negative battery cable
  6. Run the engine and check for any fuel leaks.
prev.gif next.gif

Oct 17, 2010 | 2001 Mazda 626

2 Answers

Location under hood for fuel pump relay on 2002 Mazda Millenia S


JUST RELEASE THE PRESSURE AT THE FUEL PRESSURE TEST PORT ON THE FUEL SUPPLY RAIL THAT SUPPLIES THE INJECTORS, IT IS A METAL VALVE LIKE A TIRE VALVE, THAT IS THE FACTORY RECOMMENDED METHOD..

Mar 11, 2009 | 2002 Mazda Millenia

2 Answers

Fuel filter on a 1996 Mazda Millenia


The fuel filter is accessable from inside the trunk. remove the trunk carpet mat. You will notice a circular panel on the left side which is held to the trunk floor with two screws. remove the screws and panel and you will immediately see the fuel filter. When replacing the fuel filter, note the direction of fuel flow and Do Not Install The New Fuel Filter Backwards!

Sep 12, 2008 | 2000 Mazda Millenia

Not finding what you are looking for?
2002 Mazda Millenia Logo

Related Topics:

150 people viewed this question

Ask a Question

Usually answered in minutes!

Top Mazda Experts

yadayada
yadayada

Level 3 Expert

75807 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

22133 Answers

Jeff Turcotte
Jeff Turcotte

Level 3 Expert

8172 Answers

Are you a Mazda Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...