Question about 1997 Chevrolet Astro

1 Answer

Fuel pump i need to know how to change a fuel pump in 1995 chevy astro

Posted by on

1 Answer

  • Level 2:

    An expert who has achieved level 2 by getting 100 points

    MVP:

    An expert that gotĀ 5 achievements.

    Governor:

    An expert whose answer gotĀ voted for 20 times.

    Hot-Shot:

    An expert who has answered 20 questions.

  • Expert
  • 51 Answers

The fuel pump is in the tank. You will have to lower the tank, and remove a locking ring from the tank to get the pump out. It helps to drain the tank if you can.

Posted on Oct 08, 2008

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

2 Answers

How can you check if fuel pump is bad on a 2002 chevy astro


Check your TPS Sensor. My 1995 Chevy Astro Van did the same thing and I thought it was the fuel pump but I was wrong.

Feb 15, 2014 | 2000 Chevrolet Astro

1 Answer

Where is the chevy astro fuel pump relay for a 1995 astro van


under the hood in the relay/fuse box, should be labeled

Sep 28, 2011 | 1995 Chevrolet Camaro

1 Answer

My '95 Chevy Astro has a leak in the Power steering pump. Should I repair or replace the pump. Is it a difficult job to replace it?


I would p/u a rebuilt unit at the local parts store rather than trying to rebuild it.

Changing the pump is pretty straightforward, not too cramped. You will need a pulley puller and you will need to bleed the system after install. Don't forget to change the belt.

Tip: if you register @ autozone.com, they offer step by step remove/replace instructions on most common part including the power steering pump for your Astro.

Hope this helps.

Jan 29, 2011 | 1995 Chevrolet Astro

1 Answer

How to change a fuel pump on a 2000 chevy astro van


It is located in the gas tank, you will need to remove the sending unit at the top fo the tank. To access the sending unit, you will need to drop the tank by removing the straps. It is a big tank so drain as much as possible and disconnect the batter before you start.

Hope this helps

May 20, 2010 | 2000 Chevrolet Astro

1 Answer

I have a 1998 chevy astro V6 over 200000 miles


The fuel pump might be working but it is not priming. When you turn on the vehicle, the pump sends fuel under pressure to the injectors, to "prime" or have fuel present to be able to start engine. Without it there will no fuel available to start it. You are manually priming the engine, and the fuel pump is taking over from there. Check connections to fuel pump and replace if necessary. It is not an inexpensive repair

May 16, 2010 | 2000 Chevrolet Astro

1 Answer

1995 Chevy Astro rough idle after choke goes off and engine is at full operating temperature, also no check engine light.


Inspect/replace air filter.
Fill the gas tank to above 3/4 and add Lucas FUELSYSTEM CLEANER.
Ran on the highway for 10+ miles.

Monitor is the rough idle condition is getting worst on below 1/4 tank.
Change fuel filter and check fuel pressure.
Most failing/weak fuel pump will not work well below 1/4 tank mark.
It will fail in a HOT DAY.

Mar 05, 2010 | 2005 Chevrolet Astro

1 Answer

How do you change a fuel pump on 2003 chevy astro


on the engine compartment on the fuel rail there is a pressure port that is usually covered by colored plastic cover open it then turn the ignition switch listen for the sound of your fuel pump turning on momentarilly. if you cannot hear it while ignition is on insert small screw driver on the port to open the valve make sure you wrap rugs to control the flow of fuel if there is any. the fuel should around 40-50 psi so expect heavy fuel coming out at port if your pump is working. to change it you have to drop your fuel tank and replace your pump. this is usually left for professional due to fire hazard. any spark due to static electricity can set your fuel to flame up.

Nov 23, 2009 | 2003 Chevrolet Astro

1 Answer

95 astro van will turn over but won't start. The fuel filter was replaced and when you turn the ignition key you can hear the fuel pump running and it'll try to fire once but after that it just will keep...


try changing the turn and brake light fuses.
this is a common problem i've run into and it usually solves it.chevy for some reason hooked the fuel pump in with this fuse.
good luck

Jul 20, 2009 | 1995 Chevrolet Astro

Not finding what you are looking for?
1997 Chevrolet Astro Logo

139 people viewed this question

Ask a Question

Usually answered in minutes!

Top Chevrolet Experts

yadayada
yadayada

Level 3 Expert

60792 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

21949 Answers

Jeff Turcotte
Jeff Turcotte

Level 3 Expert

6811 Answers

Are you a Chevrolet Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...