Question about 1998 Ford Windstar

2 Answers

2 problems: disaperring antifreeze & rough idling

Problem #1: About two winters ago, we started smelling burning antifreeze smell when the car was running, and the level would definitely go down in the reservior. But, you couldn't ever find any external evidence of this. Also, the heater/defroster doesn't work as well as it should.
Problem #2: The car is idling badly and occasionally missing (still accelerates well). The "service engine soon" light is on. I take it to the local parts store and have them plug-in the hand held code reader. It says, "System running lean - bank 1." The store clerk gives me his opinion that it might be the fuel pump. You can definitly hear the fuel pump whining. We have replaced several things on this car trying to get it to run correctly. Any help would be greatly appreciated.

Posted by on

2 Answers

  • Level 2:

    An expert who has achieved level 2 by getting 100 points

    MVP:

    An expert that got 5 achievements.

    Novelist:

    An expert who has written 50 answers of more than 400 characters.

    Governor:

    An expert whose answer got voted for 20 times.

  • Expert
  • 116 Answers

I'd hate to break this too you, but if you're both smelling burnt up antifreeze and loosing it at the same time. I'd definitely take a look at the exhaust. Start the motor and let it idle. Watch the exhaust for either water, or steam / whitish smoke. If you're seeing a lot of vapor after the engine is warmed up you're loosing anti-freeze into the engine itself. Most likely due to a blown head gasket or could be as bad as a cracked head (which the windstars were pretty good for), or even the chance of a cracked block.

If it was me, I'd take the van to a good mechanic and have them do a pressure test on the cooling system. If it's loosing pressure then it's definitely a problem. One major overheat can cause a blown head gasket or worse. So, definitely find the cause and problem there.

Also, as for the OBD reading a lean on bank 1, it could be from the O2 sensors reading water vapors in the exaust. It could be clouding a reading and causing such a problem.

Personally, as I've said, I'd run it to a good mechanic who can pressure test your cooling system. It definitely sounds like you have a blown head gasket to me. It could possibly be a cracked head, but more likely towards the gasket. Do the small test I told you with the exhaust. Let it idle and check the exhaust, then even hit the throttle and see if it shows then. If you're smelling anti-freeze out the tailpipe, it's definitely not a good sign.

(Water of course will cause this rough idle as well. It will hurt the combustion process and give you the rough idling.)

I hope this helps, and I hope it's not a major problem. But, I'd definitely find out if it's leaking water into the motor.

Posted on Sep 25, 2008

  • Level 3:

    An expert who has achieved level 3 by getting 1000 points

    All-Star:

    An expert that got 10 achievements.

    MVP:

    An expert that got 5 achievements.

    Vice President:

    An expert whose answer got voted for 100 times.

  • Master
  • 335 Answers

Put a cooling system pressure tester on the radiator, do not start the engine when you do this test. pump it up to about 18PSI and look for leaks, Fix any you find and retest. If you see no leaks just leave it on there and keep it pumped up to around 18PSI or more and look for any leakage at all. If none Take out all the spark plugs and leave the cooling pressure tester on. Somehow look into the cylinders and look for evidence of coolant which will indicate a bad headgasket or cracked head.

I don't think a compression test will reveal cracks, also a CHEMICAL BLOCK TEST may reveal a headgasket or similar problem but only maybe very hit and miss, depending on the severity of the problem.

NO! not a fuel pump thats why he works there and is not a technician.Several things could be goin on there.
A vacuum leak at the intake manifold on that bank.
A plugged or defective fuel injector (remember the key word here is lean ,lack of fuel)
A fuel injector that is not being pulsed by the PCM (computer)
Coolant leak into a cylinder on that bank diluting the air/fuel mixture
A bad 02 sensor giving a "false lean" message to the PCM
A code reader is NOT a scan tool You need a professional Diagnostic Technician to check your car out sure it may cost you $200. or more but at least you will know exactly what is wrong and not just a wild guess, with YOUR money.
Please let me know if I can help in anyway but here in Fixya not too many people can help you other that give you false hope Im being honest
The most accurate way of finding a stubborn vacuum leak is a SMOKE MACHINE we have to use them here in Seattle because of this is an Emissions state and Smoke machines are a very important part of an accurate drivability diagnostics to make cars pass emissions failures.
Please send any feedback to fixincars@yahoo.com Thank You,Randy


Posted on Sep 25, 2008

Add Your Answer

Uploading: 0%

my-video-file.mp4

Complete. Click "Add" to insert your video. Add

×

Loading...
Loading...

Related Questions:

1 Answer

Obd light on, idle rough, smell, no throttle


The obd light with tell specifically what it is, is it gas or rotten egg - the latter means catalytic converter, gas smell probably flooded or not firing on one or more cylinders, need more details. Also, if the light is flashing it's warning of catalytic damage - raw fuel hitting the cat, smell could be heat from cat trying to burn off raw fuel,it will glow red hot.

Dec 15, 2013 | Chevrolet Aveo Cars & Trucks

1 Answer

I have a 2004 Chevy Impala. 3.4l v6. About two months ago, the fuel pressure regulator went out, and I forced it home. My mechanic replaced the fuel pressure regulator and said I had an EGR code, so I...


White smoke and foam in the gas tank indicates antifreeze leaking into the engine somewhere. Do you smell antifreeze? You may have an engine seal leaking, most likely head gasket. It may be affecting the various engine sensors.

Aug 23, 2013 | Cars & Trucks

4 Answers

There is white smoke coming out the tailpipe no smell of antifreeze


If it doesn't smell like sweet then you most likely got a bad tank of gas. Just to be safe keep an eye on your engine temp. and coolant levels.

Mar 26, 2011 | 1993 Dodge Intrepid

1 Answer

1990 Nisan Maxima threw all 3 serp. belts-crankshaft pulley went bad. Replaced all of these and then it started to rough idle (head gasket leak?) installed stop leak (ceramic) and it starts well one time...


there is a good possibility that your engine may have ingested some of that antifreeze and if it did thats one of the reasons why your engine idle is rough the reason why its hard to start is becaus the anti freeze is being compressed by the pistons when you start the engine check the tailpipe for white smoke or an antifreeze smell As far as the stop leak its sometimes a temporary fix for a bigger problem .Check your antifreeze level (when it cools down).for a low fluid level

May 03, 2010 | 1990 Nissan Maxima

2 Answers

Rough idling, poor gas milege


Usually the rotten egg smell is a clogged CAT. Is the engine light on and if so did you retrieve any codes?

Apr 29, 2010 | 2000 Chevrolet S-10

1 Answer

My car overheated one day and found out it didnt have antifreeze. i put new antifreeze and changed the thermostat. now it shakes and eventually turns off when idling.


Do you know where the antifreeze went that left the coolant system. Is there a leak you can see on the ground where you park? Is it burning it through the engine? If so you might have antifreeze building up in the cylinders and that will cause your car to run rough. When it does run, do you have white smoke coming out the exhaust? Does it smell like antifreeze? Let me know

Dec 15, 2009 | 1995 Suzuki Swift

2 Answers

When i run my 1996 dodge ram 1500 it smells like antifreeze. i had the head changed but it smells like antifreeze. what could be the problem?


check the coolant level to see if it has dropped.Then look under the engine,for any leaks.Look for pools of coolant on top of the engine,or run down on the sides of the engine.Then look for radiator hoses,ans heater hoses that are leaking.If you are loosing antifreeze ,and you are sure the coolant is going somewhere,you may sill have a head,or head gasket,that are bad.If it has not been long before the head change,then the antifreeze may be still present in the exhaust,or on the engine,so you may have to wait a little longer for smell to disapate.Cleaning the engine can help.

Oct 10, 2009 | 1996 Dodge Ram 1500 Club Cab

1 Answer

1996 ford f250 rough idle, strange oder from exhaust, engine cuts out at high speeds


 if it smells like antifreeze could be head gasket, if it smells like varnish could be old or bad gas,  

Oct 04, 2009 | 1996 Ford F250 Crew Cab

1 Answer

Low coolant and oil smells like gas. No white/blue


let your car idle go back to the tail pipe if it seems to be steaming alot , and or smells like antifreeze then you have a head gasket problem or a gasket leak alowing in directly into your engine

Apr 28, 2009 | 2002 Ford SVT Focus

2 Answers

Engine falls below 500rpm lights dim and engine stalls out


I had a bad air conditioner compressor that caused this same problem. It had almost completley seized and gave the car some real trouble starting. The burning smell I had was caused from the belt rubbing around the seized pully.

Jan 08, 2009 | 1997 Pontiac Grand Prix

Not finding what you are looking for?
1998 Ford Windstar Logo

473 people viewed this question

Ask a Question

Usually answered in minutes!

Top Ford Experts

yadayada
yadayada

Level 3 Expert

61249 Answers

Colin Stickland
Colin Stickland

Level 3 Expert

21949 Answers

Fordexpert

Level 3 Expert

5331 Answers

Are you a Ford Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...